Kohler 12K RES where are links for the installation /setup of the controller? thanks

Hi,

if possible please check your speed sensors within your generator to make sure each is still functioning properly. Otherwise, you might have to replace the sensors before the code goes away.

Thank you.

if you have an scr pack, that has 6 pins, there are two for ac, two for gates, and two for the excitation field.
The two gate wires come off your adc controller.

http://www.kohlerpower.com/home/home-generators/products?prodNum=12RES

Website shows 5 yr 2000 hrs. <?>.

You will likely need to reference your instruction manual for that specific control panel.

Kohler Generator issue 20 RES - YouTube

? 0:24
www.youtube.com/watch?v=CT9u64dZna0
Apr 28, 2012 - Uploaded by Jeremy vanEyk
Brand new Kohler Generator Test cycle issue. ... Oh, and Mike, good call on the carb--that happens on some 20RES models. ...Indicates Locked Rotor (Lr). ... I'm on my second 20 RES-L,home depot swapped out the 1st one. ... Kohler 20KW RESA Whole House Standby Electrical Generator - Duration: ...

If it won't start in manual, you have a short and/or a bad control board. Make sure battery polarity is correct, did you disconnect battery charger before removing old battery? If not charger can push DC volts over 20V and can damage control board.

Check the inlet fuel pressure, on exervise there is no load, when power is out it is loaded and demands more fuel. Also check for bugs blocking gas regulators vents etc

replace the (either) O rings or washer, if its a washer setup I recommend replacing the seat also you can click on this link to see a normal repair for your problem ,, http://www.youtube.com/watch?v=ubp2W-3thOo Please take a moment to rate my reply and research for your problem,, Thanks Good Luck

Is the outside air temp cold. These generators will backfire if it is real cold and if the propane pressure is low. It is suppose to be 11 to 12 inches of water colume at the generator fuel input. drygwals