05 year lt 35 2.5 tdi turning over but not starting intermittent problem

Generally the click is the starter solenoid engaging the fly wheel. The starter needs way more power than anything else in the car. It doesn't matter that the lights work. If the battery can't supply 10.5 volts under load, the starter won't turn. See if you can jump start the car and get to an auto parts store to have the battery checked.

Sometimes battery cables can short the circuit; try getting them away from any metal or each other.

Glad you solved it.

might be a burned spot on the starter contacts where the brushes power the motor.
tap the starter to see if problem goes away.
sometimes you can clean the contacts but that is a temporary fix.

This is very common bad starter, replace the starter and the problem will be solved, some of these isuzu starter are a pain to replace, good day

Its a hot start issue.

Can be related to low fuel pressure or problem with crank sensor.

Also it can be weak battery or starter.

But possibilities are to be inspected to confirm what exactly it is.------

To troubleshoot and confirm the issue,i suggest you refer few solved help links with similar types of problem like yours:------

Click the link below:------

1991 Toyota Trecel: Engine Starts fine but dies when gets Warm?

http://whatisbyme.blogspot.in/2012/05/1991-toyota-trecel-engine-starts-fine.html

-------------

1994 Toyota Pickup: Starts fine but dies in few seconds?

http://howtobyme.blogspot.in/2012/05/1994-toyota-pickup-starts-fine-but-dies.html

------------

1995 Lexus LS400: Running Hot?

http://whatisbyme.blogspot.in/2012/05/1995-lexus-ls400-running-hot.html

------------

2002 Toyota Camry: Puff of Blue or White Smoke while Starting?

http://whatisbyme.blogspot.in/2012/05/2002-toyota-camry-puff-of-blue-or-white.html

------------

Multiple problems on car: Car runs hot, A/C blows hot and car starts surging?

http://schematicsdiagram.blogspot.in/2012/04/multiple-problems-on-car-car-runs-hotac.html

--------------

Delay starting on Toyota Prius?

http://schematicsdiagram.blogspot.in/2012/02/delay-starting-on-toyota-prius.html

-----------

Honda car will not start intermittently?

http://technoanswers.blogspot.in/2012/02/honda-car-will-not-start-intermittently.html

--------------

Vehicle Starts, Runs and Loses Power

http://whoisbyme.blogspot.in/2012/07/vehicle-startsruns-and-loses-power.html

--------------

Intermittent starting issues on Volvo 760?

http://schematicsdiagram.blogspot.in/2012/02/intermittent-starting-issues-on-volvo.html

-----------

Car starts and cuts off immediately?

http://repairhelpcenter.blogspot.com/2012/01/car-starts-and-cuts-off-immediately.html

-----------

Car won't start when cold?

http://schematicsdiagram.blogspot.com/2011/12/car-wont-start-when-cold.html

===========

These details will help.

Thanks.

Yes the flywheel would be the problem here. It can be warped or has broken teeth.

I have the same problem, except this happens below 29 degrees. If jiggling keys dont work. I loosened the steering wheel adjusted and banged it up and down a couple times it worked every time so far. also the engine stopped 3 times while driving on interstate, restarting worked. this is a 2003 tdi with 90k miles on it. I am not going to try to repair until next winter. if the problem comes up. i will replace starter key switch. I think is has something with cold and wireing retracting when cold.

dont trust the tyre pump when you pump them, up there never right one knock and it puts them out

You have a bad starter. A faulty starter will function when its cold but when it heats up, it takes more energy to get the starter to engage. Your problem is exhibiting the classic symptoms of a bad starter. I hope this solves your problem and the best of luck to you.