My pajero 2.8 turbo rattles when cold OK when hot

http://www.pajero.guru/mitsubishi-pajero-maintenance-schedule/

https://www.ebay.com.au/itm/Oil-Air-Fuel-Filter-Kit-fit-Pajero-NS-NT-NX-NW-4M41T-3-2L-Diesel-10-2006-2015-/401077257757

https://www.gumtree.com.au/s-2008+mitsubishi+pajero+diesel/k0

its likely the fan. if it sounds like metal clicking or grinding, its the fan bearings.

it could also simply be the plastic fan case rattling/rubbing against another hood accessory.

Your best bet for this type of info is search through Pajero Owners forums and clubs to see if anybody has already done this.

Could be a number of issues, first could be an injector pr

get a procedure manual from your dealer their are many steps to avoid damage issues to other components contact a dealer for this manual

Hi, there is a little cable that in on the starter motor, probably you have just disconnect it, it happens to my pajero lot of times. look around the starter motor for a cable that is not going somewhere and then locate the little connector on the top and rear part of the starting motor. if this is not the case then try another battery, pretty sure one of the two is the problem.

Ioannis

I can send you the timing marks and procedures. Email me: [email protected]
Cheers.
Give me the engine number...4D55 or 4D56 Turbo/Non turbo.
Cheers

there is a little mark on the crankshaft which you line up with the 'o' mark on the casing ..
remove the cam cover and look at the cam you should see a nob on the cam about 3 th lob and that should be facing just left of the engine ..
if you have a turbo there is two notchs on the injection pump pully ..if turbo there is a 't' mark on the rear of the cover the notch on the pully should mark up with the 't'..
the timing is set..

hi you need to change the fuel pump seals, whats happening is there letting in air causing engine to cut out a commom fault with this vehicle.