Egg head switch - Toastmaster Egg Head 7 Egg Cooker 6506 Electric W/ Poacher/poaching Trays

egg burst most likely damaged door latch / switch or a circuit

Hello,

Here are instructions from another website along with various links to download manuals and lead you to other forums talking about egg incubators:

Operating steps:
1. Put the mesh with the rail(big mesh)(fig.1) into the incubator.
2. Put the moveable egg tray (fig.2) on the mesh with rail, please do it within the rail.
3. Put the egg tray grille ( fig.3) into moveable egg tray according to size of egg for incubation.
4. Put the hatching egg into moveable egg tray(fig.5) for incubation, pay attention that after each egg is put into the grille, there should be 5mm clearance at least for convenient turning of hatching egg, inject 100ml water into the base after the hatching egg is put, check once for every two days so that the incubator is not short of water. Every water injection shall not be more than 100ml, take down the date of placing hatching egg so as to well control the hatching time. It's best to place the incubator on 60-100cm for convenient insertion of link rod.
5. When closing the cover(fig.7) , the link rod must insert the shifting slot of moveable egg tray, so that the egg tray can shift normally.( in other words, the cercley thingy coming out of the top with a rod in it has to be attached to the egg tray by putting the rod into the egg turner square hole to make sure that the incubator turns the eggs well)
6. Switch on the power supply after closing the cover, and set temperature according to push-button instruction and incubation technology. If the user has no time to care about the temperature, the temperature can be set at 38'c from the first day of hatching, and it can be set as 37.5 - 37.8C since the following day of hatching.
7. It moves to hatching tray 3 days earlier than incubation period for other poultry
8. It usually takes 3-4 days less than the number of incubation days for egg tray replacement, replace the egg tray once one or two hatching eggs are seen hatched, take all of the hatching eggs off from the incubator firstly, then take the moveable egg tray with mesh with rail out, check the water level, then put the hatching mesh( fig. 10) and egg tray in and put the hatching egg on the egg tray, shown as fig. 11.
9. After closing the cover and switching on the power supply, the hatching situation can be observed.

This was originally posted here: Janoel 12 incubator help

Best wishes,
Joe

I’m happy to help further over the phone at https://www.6ya.com/expert/mark_7bbaa7a1174e0903

it is happen to old engine because the oil that escape from the engine(engine cover near the exhaust) when it is got hot it sends bad smell but after how many minutes if it already dried up because of heat it will gone (like frying using the used cooking oil in pan there is a different smell).

I have exactly the same as you, to use the egg poacher
1. put water in inner pot
2. wipe outside portion of inner pot, put inner pot into unit, turn it slightly from left to right to ensure the pot and the heating plate has a good contact
3. connect electrical cord and press switch to start cooking
4. let the water boil
5. break each egg into the hole of the poacher
6. put the egg poacher on top of the inner pot
7. cover the unit
8. cook for 3 to 5 minutes

this is what it says in the manual I hope it helps

Mite need to have its firmware reloaded. or the machines NVRAM may be gone>

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/normanj_7893313f0751935f

Look on the internet. Go to it's website.

Hard: 1 egg/8 TB; 3 eggs/7 TB; 5 eggs/6 3/4 TB; 7 eggs/6 1/2 TB. Medium: 1 egg/4TB; 3 eggs/3 3/4 TB; 5 eggs/2 3/4 TB; 7 eggs/2 1/2 TB. Soft: 1 egg/2 1/2 TB; 3 eggs/2 TB; 5 eggs/1 3/4 TB; 7 eggs/1 1/2 TB. Note:oddly, the amount of water goes down instead of up for more eggs.

Egg Genie cooks up to 7 eggs at once-with no guesswork, no underdone or overdone eggs.

Just add the indicated amount of water.

Press "on"and your work is done.

The Egg Genie automatically steams eggs and alerts you when they're ready.

Here are the amounts in teaspoons of water:
4 tsp = 6 soft boiled eggs
5 tsp = 5 soft boiled eggs
6 tsp = 3 soft boiled eggs
7 tsp = 1 soft or 7 med
8 tsp = 6 med boiled eggs
9 tsp = 5 med boiled eggs
10 tsp = 3 med boiled eggs
11 tsp = 2 med boiled eggs
12 tsp = 1 med boiled egg
14 tsp = 7 hard boiled eggs
15 tsp = 6 hard boiled eggs
17 tsp = 5 hard boiled eggs
18 tsp = 4 hard boiled eggs
20 tsp = 3 hard boiled eggs
21 tsp = 2 hard boiled eggs
23 tsp = 1 hard boiled egg

i say it was chicken.
chicken has evolved from ancient turtle. turtle got tired of being slow and to hide in its shell from predetors.,so he decided to grow wings and fly away. but at first try he failed.thats why we have chicken ,. he tried again . he thought he needed to be biger to fly.so he evolved to ostrich.it did not work either.thats why ostrich hide his head under the sand .he cant fly and he doesnt have a shell to hide in.
i hope you got the answer .

Yes the internal fuse will have blown. I would also think the door latch switches and monitor switch will also need re adjustment