Question about Boating

1 Answer

I have a 1989 15 Hp suzuki 2 stroke outboard. it has an electric start and charging system but this was all disconnected by the previous owner. I have the starter hooked up and working but don't have information to hook up the charging system. Also I can't get the motor to ideal at low speed. Thanks

Posted by grsurfsail on

Ad

1 Answer

Fabrice Wolters

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Sergeant:

    An expert that has over 500 points.

  • Expert
  • 331 Answers

Normally there are just a positive battery lead ( 25mm sq), a negative battery lead (25mm sq) and a multipole plug to the remote control and Dashboard.
The charging circuit is internal to the engine. Normally it's never disconnected.

Maybe describe more for your idle speeds trouble.

Posted on Dec 26, 2017

Ad

5 Related Answers

mcgyver468

Mark L. Roberts Jr.

  • 710 Answers

SOURCE: 40hp 1987 yamaha outboard motor will run for 30-60

Sound like the fuel pump is not keeping up with the engine's demand. Check it out. Good luck. Hope this helps.

Posted on Apr 27, 2009

Ad

Anonymous

  • 11 Answers

SOURCE: suzuki 4hp two stroke impellar

Dropp the lower unit, should be only 4 bolts holding it on. Impellar housing should be located right on top of the lower unit. four screws it the housing slides off the shaft, insall in reverse order with ne gaskets, make sure you re- align the waterhose/pipe from the lower unit back to the head

Posted on May 01, 2009

Anonymous

  • 2 Answers

SOURCE: 9.8 hp mercury outboard shutting off in low idle speed.

My problem ended up being the spring on the reed valve being weak.But at the same time and while I had already had my carb broke down I took a can of carb cleaner to it and cleaned it. In order to replace the spring on reed valve you will have to buy a new one, but don't worry I only payed about $6.00 for mine. You may also look into replacing your primer bulb if you haven't already because may allowing air to build up in your gas line while you are basically idiling.Once you get the carb straightened out you may have to reajust it again. If I might be able to help you again you may contact me at [email protected].

Posted on Jun 16, 2009

Editor925

Dean

  • 285 Answers

SOURCE: Missing operators manual for Evinrude 2 hp outboard motor

Your best bet is ebay for a replacement user manual. Take a look around, you will come across one... For the meantime, gas oil ratio should be 50 parts gas to 1 part oil, i.e. 50:1. General care: Dont go full throttle for any length of time. Cruise of 3/4 throttle... Always flush engine after use in saltwater, including washing down exterior. Keep spark plugs in good order and check prop for fishing line wrapped around in near the prop hub. Otherwise, get a yearly service and have them check the water pump and replace as needed, get it tuned etc and gearbox oil changed.

Posted on Jun 20, 2009

buffalonyman

buffalonyman

  • 1865 Answers

SOURCE: oil weight to use for 1989 evinrude 2 stroke 90 hp

The oil is mixed with the gas, just buy 2 cycle engine oil and follow ratio mixture

Posted on Sep 29, 2009

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Yamaha 25hp 4 stroke stator Installed new one and it went bad in one day why


Check your battery wires. If the battery disconnects even for one second or the grounds are bad then the stator has no where to put the charge and it will fry.

Aug 18, 2018 | Clymer Marine Maintenance and Repair...

2 Answers

2010 150 Evinrude E-Tech. Motor was running great then just shut off. Will not start again.Could it be it needes to be reset, all 4 lights at tach light up showing good.


first bit of advice
do not use e-mix fuels in outboard engines
WHY
because ethanol separates from the fuel if not used continuously so letting it stand between outings is not good
secondly ethanol is hygroscopic which means that it absorbs moisture from the air that is going in via the tank vent and that results in corroded aluminium parts and rusted fuel tanks and outboards operate in a very moisture laden environment
now for the problem
being a late model engine , it should be a 4 stroke and like any 4 stroke engine , check the timing belt/chain, crank/cam position sensors , ignition module
it is important to check all harness connections as salt water rapidly causes corrosion in electrical connections and components
have the service agent do a scan for fault codes remember this
Suzuki out board 2 stroke motors were used in the early suzuki 4x4 cars and modern 4 stroke engines are simply car engines on end

Sep 18, 2017 | Clymer Evinrude/Johnson 5-70 Hp...

1 Answer

I need a manual for my 4 stroke 100HP Susuki outboard


Frans, Check the attached links,instruction and guides, Good luck
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."
suzuki 100 hp outboard specifications Google Search
Suzuki
https://www.tradebit.com/filedetail.php/142965517-suzuki-outboard-service-manual-df90-100-115

May 02, 2016 | Boating

1 Answer

Are the controls for a 1998 15 HP 2 stroke Mercury outboard compatible with a 2011 30 HP 4 stroke Mercury outboard


If your old engine/control has the same 'options' as the30hp, yes everything is compatible... (Electric start or trim )
The throttle and shift cables are allways compatible...

Jun 25, 2015 | Mercury Marine 15hp & 20hp 4 Stroke...

1 Answer

What pins on the ignition switch are energized when when you turn the key on a 2003 mercury 15 hp 4 stroke outboard?


Red is Battery +
Red/purple is ignition
Yellow/red is startermotor
Black/yellow is motor kill
Black is ground

To have ignition, black/yellow wire must be disconnected
On is red/purple on bat+
To start Yellow/red on batt+
To kill: black/yellow on ground

Jul 29, 2017 | Boating

1 Answer

Does my 1979 johnson outboard charge the battery thru the powerpack?


Some models charged through a Magneto, but see if you can find the 1979 Year Manual. I have a 1979 engine myself in a 15Hp which is a Manual start(no battery) and I have a Sailhorse Johnson 8HP which has an electric port and is Manual start. I believe the 8HP would charge a battery as on a Sailboat the running lights needed power. The 8HP could power the lights directly.

Johnson offered options for electric start in lower HP units and options in charging systems to contain costs. You might get a better answer from someone by listing the HP of your motor. I was the original owner of the 15HP and remember the 9.9HP and others in the same Sales brochure. The Sales brochure may advertise more about the charging systems.

Jul 21, 2014 | Light Outboard Motor Boat Bass Fishing...

1 Answer

I have a 65hp suzuki outboard motor wont start just makes clicking noise and tilt aint working now motor was running season before


try installing a fully charged battery or charge the battery for 24 hours then jump start the boat from a car

Jun 24, 2014 | Suzuki Service Manual, 2 - 65 HP Outboards...

Not finding what you are looking for?
Boating Logo

Related Topics:

456 people viewed this question

Ask a Question

Usually answered in minutes!

Top Boating Experts

ray gallant

Level 3 Expert

71004 Answers

Andrew Taylor
Andrew Taylor

Level 3 Expert

35843 Answers

Bill Boyd

Level 3 Expert

53816 Answers

Are you a Boating Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...