20 Most Recent V-Twin Horizontal OHV Engine with Electric Start - 610cc, GX Series - Page 6 Questions & Answers

need new needle and seat for carb

try cleaning carb

sounds like the coil

Hi,
Use an ohm meter ot check and see if you are shorted somewhere, that would discharge the battery quickly...
It also is not uncommon for those batteries to go bad and short internally.. the vibration will do that to them..You may need to replace the battery...

heatman101

You may have a bad coil, or check you clearence between the flywheel and coil. Should be between 0.016-0.008in.

Everything you need to know about your engine is here, in PDF mode:

http://www.honda-engines-eu.com/en/images/1000.pdf

Not getting enough fuel or you wouldn't need the choke. Need a clean spark plug and take carb apart and clean. Sounds like it has been sitting a long time and gummed up.

Hi there,

Please download your manual from http://www.honda-engines.com/Engines_owners_manuals/ownersmanuals/00X37Z6C6030.pdf.

You can find the wiring diagram at page 18.

Regards,
Jeep Brainy

Hi there,

It looks like that the problem is in the Oil pressure switch or must be as dealer said problem is in the air jet, you need to check tham both.

Good Luck!!
Thanks

Make your own timing marks with a piece of chalk. The important thing to remember is the timing mark should be in the same place (if using a timing light) and not bounce around.

yes there is a timing chain in the engine

NO THEY ARE DESIGNED FOR SPECIFIC VEHICLES

Probably done by design to stop a joyrider jumping in and driving off. Contact Avital direct. FWIW, remote starters are a whole lot of trouble. Let me know when you burn out your first starter motor because it does't release, or it locks you out and won't let you start.

https://www.youtube.com/watch?v=aRPmRBlqRqM https://www.lindec.com/download/14043667571_Honda_GX630-660-690-workshop_manual.pdf

Gravity feed tank need no fuel pump.....

I got this free Pdf manual from reliable-store for free and I don't think Ive visited a mechanic or fixya for help for more than 3-4 times out of the 20 times I fixed the chipper in these 4 yearsmust try this bitman and reliable-store. Both are good

hello u will find a lot of wiring diagrams and circuit diagrams help books and stuff like this .. im a frequent buyer there since Im a mechanic so take help from there

If it is an electronic accelerator pedal you have, perhaps poor contact on the wires/connector on the pedal. Lay down on the floor, and check if the connector is in it's place and no loose cables. I had same problems with brake pedal and signals from that one.