Orion HCCA-D2400 Car Audio Amplifier - Answered Questions & Fixed issues
Trying to increase volume on car deck when doing
Disconnect all speaker connections and rca cables. Leave power, ground and remote wires intact. Try turning on again. If you still have a protection light your amp is faulty. Hopefully you have warranty. Please check impedance on speakers as they coyld be fried as well.
A thumbs up would be greatly appreciated if this answer is helpful to you
Schematic for orion HCCA-D2400
The schematic or service manual doesn't appear to be available online. You may have to contact Orion. Verify the REM input to the amp. It should be 12V when the car is on and 0V when the car is off.
When I turn car off amp still stays on without keys in ignition
the constant power should be run to the battery. The "turn-on power" should be run to your radio which only comes on by the ignition. If it still comes on then your radio is wired to come on without key. Then you have to check the constant and turn-on wires for it.
The fuses blew but then
If you are a lucky person..maybe.. but i highly doubt it. ..Sorry.. Smoke is never a good sign when it comes from within the amplifier.
Be aware i am advising according to the info you provide.
Have it checked and repaired if required, it is a good amp. (find an authorized technician)
dreamsystems
When i adjust the controls on my orion2400 hcca
your amp is shorting internaly most likely from be handled rough the only thing i recemond is replaceing it cause it will fail completly it just a matter of time & it could be a fire hazared in you car
Yellow light start blinking
do you have a power cap, if not your amps not getting the power it
wants what size wire you running should be 2gage
Schematic diagram for Orion hcca 275r
+12V
'
'
Fuse '
(30A) '
'
+-----------+
'
'
Power LED
(Green)
'
'
+-----------+
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
+-----------+
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
+-----------+
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
' '
+-----------+
'
'
-12V
(Ground)
This is a very basic diagram showing the power input, power LED, and the three output channels for the HCCA 275R amplifier. The specific wiring and connections may vary depending on the setup and configuration of the amplifier.It is important to note that working with electronics can be dangerous and any modifications or repairs should be done by a qualified technician. Additionally, it is important to refer to the manufacturer's manual or documentation for accurate and detailed information on the specific amplifier model.
What orion cobalt sub is good for this amp?
You do not have enough listed for specifics but you do need to match your sub with the amp from an ohm standpoint and a wattage standpoint. I am sure your amp can handle down to 4 ohms but may handle 2 ohms. Find that out and then check on the output wattage of the amp. A lot of people have separate amps for the sub itself and run the system off of another amp. Either way is acceptable.
Not finding what you are looking for?