20 Most Recent
3d Rose Londons Times Funny Cow Cartoons - Cow Country Club - Golf - Light Switch C - Page 2 Questions & Answers
Have 36 volt club car w/coils
Recheck your battery wiring. The batteries should be wired in series, neg to pos to neg. I believe one of the batteries behind the driver's side is the main negative and one on the passenger side is the main positive. There is usually a #6 green wire coming from the for/rev switch to a positive battery post, however , it might be a different color, but that one is the reverse wire, It can be on any positive post, just count the number of batteries between green wire and main neg, multiply by 6 and that would be total reverse voltage. If wired correctly all 6 batteries are used for forward.
1998 48V electric club car
If you go to
www.studmonkeyracing.com/forums/cc48v.jpg you will find a schematic for what I believe will be close to wiring of your cart. A systematic check of volts to the various components should get you going. 1st port of call, you should see 48 volts on both sides of the keyswitch when it is on. Check the fuse in line with the red wire from the solenoid to the on-board computer.
It may simply be that you have one battery terminal too loose and it just wont allow you to draw enough current to run anything but the buzzer. Does the buzzer stop when you press your foot on the gas? If so it really does point to a loose battery connection.
I replaced the fwd / rev switch on my Club Car 1985
I recently replaced a F/R switch and just happened to write down which wires went where so maybe I can help. The front switch ( closest to front of cart) green/white wire to top contact, white/black to bottom.
Middle switch red/white to top, orange to bottom.
Rear switch green to top, black to middle and white to bottom.
Club car on off switch gets no power
This is a gas or electric 48 v or 36 v? what year model? F/R switch is a lever or a rocker arm? Club cars have made many changes over the years.
Cannot turn off power
Sounds like you may just have some bare wires touching,Trace the wires from the ignition switch.
Need manual with the schematics for the wiring of
Need to know what year the club car is. No drawings are in the owner's manual and there are no free service manuals available.
But all is not lost, try buggiesunlimited website for downloadable wiring diagrams. If you still have problems I can maybe help lead you through some trouble shooting steps. email is
[email protected]
Club Cart Golf Cart Reverse only
You don't have it connected right. The DC motor is 'polarity reversed' to change direction. That's what the controller does is reverse the polarity to the motor to change direction. If the motor is still working in reverse, then the controller is 'probably' okay. Recheck the connections you made. If you need further help, I’m available over the phone at
https://www.6ya.com/expert/craig_3fa289bf857b1a3c
We are searching for a schematic for a Legend electric golf cart
THE BATTERIES ARE RUN IN SERIES THAT MEANS THAT THE WIRES GO POS. TO NEG. NEG. TO POS. STARTING IN THE BACK AND THEY RUN LIKE THIS TILL YOU GET TO THE OUTPUT FROM BATTERIES TO MOTORS THE CURRENT GOES IN ONE SIDE OF BATTERY AND OUT THE OTHER BY CONECTING ALL POSITIVES YOU MAY HAVE JUST KILLED THE BATTERIES
Not finding what you are looking for?