Honda EU6500iS Inverter Generator - Answered Questions & Fixed issues

Stops generating and just idles

Check if there any alarm on monitor by pressing button several times. It has code like E-number. Replace spark plug, fuel filter. Clean carburator, spark arrester. Check wiring of thermosensor.

Honda EU6500iS... | Answered on Apr 28, 2017 | 212 views

1 Answer

How to change recoil rope

How To Replace The Starter Rope On Your Recoil ...

? 4:47
www.youtube.com/watch?v=Q3NjVomUQJM
Feb 25, 2009 - Uploaded by craig1974 Me showing you how to replace your starter rope on your recoilassemblies.

Honda EU6500iS... | Answered on Sep 15, 2015 | 356 views

1 Answer

Honda es6500 won't start has fire,compression , gas, not voltage at carb, oil light on then goes out when cranking

If you run 12volts to the carb, will it run? I assume since it has no power at carb as you stated, that it has a fuel shut off at carb and will need voltage to activate magnet.

Honda EU6500iS... | Answered on May 25, 2014 | 1,023 views

1 Answer

I have a eu 6500is generator inverter that will run perfectly for any amount of time, then with no warning just stop generating and idle. No overload alarm. No oil alarm. Nothing will just idle. If yo

this sounds like a capasitor/resistor that is getting hot under load once it is switched off and cools down it works until it gets hot again similar to that of a cars ignition coil which will get hot and cut the vehicle out but once it cools it will start again.

Honda EU6500iS... | Answered on Dec 07, 2013 | 316 views

3 Answers

I have a gas generator a Honda and someone put 2cycle feul in it now it starts and runs for 20 to 30 minutes and. Stops it displays trouble code E-0A

The error code is for incorrect air/fuel ratio. The first thing to try and most common cause is a bad fuel filter. Try replacing the fuel filter. It is possible that the 2 cycle mix, since it contains oil, had gummed up the filter. I would also run some carburetor cleaner through it.

Honda Electrical... | Answered on Nov 27, 2020 | 17 views

2 Answers

Why wont my governor pull in when my Honda ex1000 is under load?

you may have a faulty actuator that governs it for you need to check if coil of actuator is excited with power when you draw current

Honda Electrical... | Answered on Aug 23, 2020 | 760 views

1 Answer

Honda generator GX270 idles but won't speed up under load

yes this load sensor module has a coil that is wrapped on a single line of stator output.this board may utilize a 12 volt source from alternator

Honda Electrical... | Answered on Aug 22, 2020 | 1,866 views

1 Answer

Require a wiring diagram for a honda copy 7.5kva diesel generator, please

Maybe you can ask your supplier to get the wiring diagram

Honda Electrical... | Answered on Jan 06, 2020 | 120 views

1 Answer

No Spark On Ems 4500 Honda Generator

Check oil alert switch, ignition switch and connections.

Honda Electrical... | Answered on Dec 30, 2019 | 96 views

2 Answers

I have a EB3500 honda generator that trips the AC circuit breaker when there is no load on it. What could it be?

Honda generator? Please ask your supplier for the answer. They can help you.

Diesel generator set problem support: www.dieselgeneratortech.com

Honda Electrical... | Answered on Dec 04, 2019 | 765 views

1 Answer

Honda 8750 blackmax no electricity

If you need more support, we recommend you a support website, you can search your answer on the website: www.dieselgeneratortech.com

Honda Electrical... | Answered on Oct 15, 2019 | 119 views

1 Answer

Honda em 600 generator puts out to much voltage

If you need more support, please visit www.dieselgeneratortech.com

Honda Electrical... | Answered on Oct 10, 2019 | 118 views

1 Answer

HONDA EM650 Generator starts but wont power anything up

For your question, i have replied many people, why generator set can start but not generate electricity?
Here is some reasons for reference:
1.After the diesel generator is stopped, the residual magnetism is often lost, because the material used for the magnetic pole of the exciter is close to the soft steel, and the residual magnetism is small. After the shutdown, when there is no current in the excitation winding, the magnetic field will disappear.
2.The magnetic pole of the diesel generator loses its magnetic properties.
3.Damage of excitation circuit components or circuit breakage, short circuit or grounding phenomena.
4.The exciter brush is not in good contact with the commutator and pressure of brush holder is insufficient.
5.Excitation winding wiring error, opposite polarity.
6.Stator winding and rotor winding of generator set open circuit.
7.Poor contact between diesel generator brush and slip ring, or insufficient brush pressure.
8.Diesel generator lead wire wiring is loose or switch contact is poor.
9.The fuse box is fused.
10.The "auto-manual-de-excitation" switch on the control panel is in the de-excitation position (automatic generator set has "auto-manual-de-excitation" switch).
11.The voltmeter is damaged.
12.Rotary rectifier module is damaged.

Honda Electrical... | Answered on Oct 09, 2019 | 143 views

1 Answer

MY BLACKMAX 7000/8750 RUNS GOOD BUT THERE IS NO ELECTRICITY GENERATING, HOW DO I FIX THIS?

Most of the time it is either the Capacitor or AVR that has blown (depending on what is fitted on your generator.). Check out our videos on how to test them.
We hold a full range of Generator AVRs and Capacitors. https://www.generatorguru.com

We have a whole Help Center and Engineers dedicated to helping people fix their Portable Generators. In addition to this we have a "Parts Search Service" if the part is not listed on our site. Check us out on our site. https://www.generatorguru.com/
Parts Spares for Generators and Small Engine Machinery

Honda Electrical... | Answered on Aug 19, 2019 | 177 views

3 Answers

When I plug in a tool, it runs fine, when I plug it into my house with the breakers all off, it blows the breakers on the generator? My Honda 2200 watt works fine this way?

I think there is overload .kindly measure ur load of consumption. Do not run the generator set with high load it can be cause of circuit breaker Tripp off .

Honda Electrical... | Answered on Jul 27, 2019 | 182 views

1 Answer

Honda eg 550 generator starts but if i conect the plug from astatior the motor labour

you probably have either a bad capacitor or more likely a short stator winding due to previous overloading

Honda Electrical... | Answered on Jun 03, 2019 | 189 views

1 Answer

Hi guys i have a Honda GX 160 petrol generator that is only producing on the 110 volt socket, 220 volt does not produce

Verify that the double gang circuit breaker is good on both sides. Check for loose wire on breaker or receptacle.

Honda Electrical... | Answered on Jun 03, 2019 | 232 views

1 Answer

13 hp honda engine on a North Star 8000 Generator ppg Pro series generator - generator keeps cutting off

Hi!

We have a put together a guide here to assist you in these situations. It will guide you through testing and repairing the Generator. : https://www.generatorguru.com/need-help/
If you need any further help our Generator Engineers are happy to assist you.

Regards,The Generator Guru Team
Parts Spares for Generators and Small Engine Machinery

Honda Electrical... | Answered on May 31, 2019 | 162 views

1 Answer

Ok so i have a Honda EU3000 inverter generator & last weekend while camping the generator overheated in our shed & now will not start. any ideas?

check engine oil....there is no engine oil...

Honda Electrical... | Answered on May 25, 2019 | 171 views

1 Answer

Es6500 honda generator running smooth then all sudden goes wide open with no load put a govenor ki in in replaced the oil pump and timing belt and still doing it what could it be

What happens when you trurn off "auto-throttle"<?>.

Honda Electrical... | Answered on Apr 13, 2019 | 213 views

Not finding what you are looking for?

13 questions posted

Ask a Question

Usually answered in minutes!

Are you a Honda Electrical Supply Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Have a manual for Honda EU6500iS Inverter Generator? Or just drag it here!

Honda EU6500iS Inverter Generator - Answered Questions & Fixed issues

Stops generating and just idles

How to change recoil rope

How To Replace The Starter Rope On Your Recoil ...

Honda es6500 won't start has fire,compression , gas, not voltage at carb, oil light on then goes out when cranking

I have a eu 6500is generator inverter that will run perfectly for any amount of time, then with no warning just stop generating and idle. No overload alarm. No oil alarm. Nothing will just idle. If yo

I have a gas generator a Honda and someone put 2cycle feul in it now it starts and runs for 20 to 30 minutes and. Stops it displays trouble code E-0A

Why wont my governor pull in when my Honda ex1000 is under load?

Honda generator GX270 idles but won't speed up under load

Require a wiring diagram for a honda copy 7.5kva diesel generator, please

No Spark On Ems 4500 Honda Generator

I have a EB3500 honda generator that trips the AC circuit breaker when there is no load on it. What could it be?

Honda 8750 blackmax no electricity

Honda em 600 generator puts out to much voltage

HONDA EM650 Generator starts but wont power anything up

MY BLACKMAX 7000/8750 RUNS GOOD BUT THERE IS NO ELECTRICITY GENERATING, HOW DO I FIX THIS?

When I plug in a tool, it runs fine, when I plug it into my house with the breakers all off, it blows the breakers on the generator? My Honda 2200 watt works fine this way?

Honda eg 550 generator starts but if i conect the plug from astatior the motor labour

Hi guys i have a Honda GX 160 petrol generator that is only producing on the 110 volt socket, 220 volt does not produce

13 hp honda engine on a North Star 8000 Generator ppg Pro series generator - generator keeps cutting off

Ok so i have a Honda EU3000 inverter generator & last weekend while camping the generator overheated in our shed & now will not start. any ideas?

Es6500 honda generator running smooth then all sudden goes wide open with no load put a govenor ki in in replaced the oil pump and timing belt and still doing it what could it be

Not finding what you are looking for?

Ask a Question

Popular Products

Honda 3000 Watt Portable Generator

Honda 6370C - Parallel Power Kit For EU3000i

Honda Mmd 5000 Watt Electric Start Generator W/ Engine...

Honda 86 87 88 89 Accord Alternator Lxi Sei

Honda Mmd 5000 Watt Generator W/ Engine Ngk 6000H

Top Honda Electrical Supplies Experts

Sheldon Dedek

Mike

Marvin

Are you a Honda Electrical Supply Expert? Answer questions, earn points and help others

Manuals & User Guides