Question about 2004 Suzuki GSX-R 1000

1 Answer

My 2004 GSXR 1000 shut down as I was riding. When I got it a few months ago, I noticed the headlights wouldn't change from bright using the switc. Last month they started flickering intermittently. Today I was able to control bright and dim using the switch, but the bright light indicator was going crazy- flickering on and off very rapidly. I rode about 70 miles today, and just as I was a couple of miles from home going 65, it just shut off. I tried to start it using the clutch and using the starter button. turned it off and back on, then it started. Rode a few miles and it happened again. Could it be the stator?

Posted by kturne on

Ad

1 Answer

Gregg Mahin

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    One Above All:

    The expert with highest point at the last day of the past 12 weeks.

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

  • Suzuki Master
  • 64,961 Answers

Hi, Kturne and the usual suspects are:
1. Severely discharged or a damaged battery should have 12.5 volts or better and be able to pass a proper "LOAD" test if necessary your battery may show 12.5 volts or more but have little or zero amps and must be replaced.
2. Failed alternator/generator and or voltage regulator.
3. Loose or corroded battery terminals and or cables especially the "NEGATIVE" cable, look for loose, corroded, or broken connectors inside the cable harness at "BOTH" ends.
4. Failed main circuit breaker or ignition switch, check for loose connections and continuity.
5. Failed system and or ignition relay, check for continuity.
6. Failed ignition coil, ignition/electronic module.
7. Failed CKP, CPS, CMP, MAP, TPS, or BAS sensor, corroded, loose or broken wire connector pins/sockets.
8. Throttle cables and or idle speed improperly adjusted hot idle speed should be 950 RPM to 1000 RPM.
9. Fuel tank empty.
10. Fuel tank contaminated with ethanol sludge.
11. Water or dirt in the fuel system, or clogged filter.
12. Restricted, blocked or kinked fuel line.
13. Faulty fuel pump.
14. Faulty pressure regulator.
15. Faulty or clogged fuel injectors.
For more information about your issue and valuable "FREE" downloads that you need please click on the blue links below. Good luck and have a wonderful day.
Shuts down while riding
engine shuts off while riding please help
Suzuki GSX R1000 Service Manual
OEM parts for Suzuki
Suzuki GSX R1000 Owner Manual

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

Posted on Apr 12, 2017

Ad

4 Related Answers

Anonymous

  • 10 Answers

SOURCE: killing batteries

yes and yes. check with your local honda dealler for a possible free replacement.

Posted on Mar 12, 2009

Ad
jmgldsmth

Jim Goldsmith

  • 2005 Answers

SOURCE: 06 s83 won't start. Rode for 70 miles, parked in

replace your battery although you have 12 volts your battery is producing very little amps not even enough to energize your start relay let alone your starter motor

Posted on May 03, 2009

co7196

Ned C Cook

  • 3433 Answers

SOURCE: Re: 06 s83 won't start. Rode for 70 miles, parked in

WHAT ARE WE DOING, OR NOT DOING?

Posted on Jun 10, 2009

Anonymous

  • 190 Answers

SOURCE: Replaced stator, brand new battery, died after 10k ride

sounds if regulator is not working or poor connections within charging circuit

Posted on Jul 04, 2009

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Why is one of my headlights dim/bright mode reversed?


It could have the wrong bulb or the connector is broke inside forcing a short

Nov 20, 2016 | Ford F-150 Cars & Trucks

1 Answer

C42 suzuki gsxr 1000


check the coil the low side of it may have blown . get a spark plug tester to check it.

Dec 20, 2013 | Suzuki Cars & Trucks

1 Answer

2002 Suzuki GSX-R 1000 headlight not working


Hi, Anonymous if your headlight is not working, intermittent, only one beam works, keeps burning out, blinking, dim or surges from bright to dim to bright the first thing you need to check is the headlight bulb for damaged filaments then check your light circuit fuse, then check your headlight bulb socket ground wire for a clean tight connection, that being said the usual suspects are:
1. Faulty ground or power supply wire to headlight bulb socket.
2. Worn down solder contacts or loose fit of the bulb base in the socket due to vibration.
3. Worn, chafed, or broken wires in the light circuit.
4. Corroded, broken, or loose pins/sockets in wire connectors.
5. Faulty hi/low beam switch.
6. Faulty ignition switch.
7. Fuse is good but no continuity on both sides.
8. Faulty headlight relay.
9. Faulty wiring between battery positive and headlight bulb socket.
10. Weak charging alternator/generator/lighting coil
11. Faulty voltage regulator/rectifier ground or overcharging.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Headlight won work GSXR com
GSXR Headlight not working
Suzuki 2001 GSX R1000 Service Manual
https://www.partsfish.com/page/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki/suzuki-gsx-owners-manuals

Aug 22, 2013 | 2002 Suzuki GSX-R 1000

1 Answer

My Front Load Affinity washer shuts off after a few minutes


Good Afternoon Lori - Thank you for your post! Based on the symptoms you are describing, you may either have a communication error from the main control board or the timer itself may not be operating correctly. If you noticed a humming noise, then once again it could either be a clogged drainage hose or pump that needs to be cleaned, or it could possibly have another issue with the door lock assembly. I would personally contact a professional to accurately diagnose the washer to determine the root cause to reduce the risk of unnecessary parts.

Jul 11, 2013 | Frigidaire Affinity ATF7000E Front Load...

1 Answer

Problem with the Headlight control swtich on 2010 Sebring


it is your bcm which is your body control module

Dec 09, 2012 | 2010 Chrysler Sebring

1 Answer

2006 Suzuki GSX-R 1000 instruments and horn not working


Hi, Zridin if some or all of your instrument cluster goes dark/blank immediately upon startup or a few minutes later riding down the road the usual suspects are:
1. Blown instrument fuse.
2. A bad ground in the instrument circuit.
3. Faulty wiring before or after the fuse.
4. Faulty wiring or connector between the fuse and the instrument cluster.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Horn not working GSXR com Speedo and tach are not working Suzuki GSX Motorcycle Forums Gixxer com Suzuki GSX R1000 Service Manual https://www.partsfish.com/page/oem-parts-for-suzuki http://mybikemanuals.com/suzuki/suzuki-gsx-owners-manuals

Jan 27, 2010 | 2006 Suzuki GSX-R 1000

1 Answer

99 jetta headlights wont turn on, replaced 4mo ago.


If the bulbs and relays are good, then the switch is faulty.

Sep 13, 2009 | 1999 Volkswagen Jetta

2 Answers

Headlights, Digital gauge, tachometer not working.


check all wireing loose connection somewhere/

Aug 24, 2009 | 2004 Suzuki GSX-R 750

Not finding what you are looking for?
2004 Suzuki GSX-R 1000 Logo

Related Topics:

614 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

6480 Answers

Gino Cussen
Gino Cussen

Level 2 Expert

217 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...