How to access the battery on a 2001 Suzuki Intruder Volusia 800

They look identical. The plug connector as well

07

https://www.amazon.com/Suzuki-Ignition-Boulevard-Intruder-37100-41F70/dp/B06XHRSGKH


01 - 04

https://www.ebay.com/itm/01-04-SUZUKI-INTRUDER-VL800-800-VOLUSIA-BLVD-C50-IGNITION-SWITCH-37100-41F10-NEW-/371054828151

I figure that engine and gearbox use the same oil filling; but check the following:

1. Need 2002 Suzuki Volusia 800 Owners Manual - Suzuki ...

   www.volusiariders.com/.../186127-need-2002-suzuki-volusia-800-owne... Apr 26, 2009 - Suzuki Volusia Forums : Intruder Volusia and Boulevard Forum ... Thanked 0 Times in 0 Posts. Need 2002 Suzuki Volusia 800 Owners Manual ...

is it popping from exhaust, if yes it is drawing cold air in, this causes it to pop. check all seals, and manifold bolts.

To replace the battery:

1- remove the rear (passenger) seat by removing the single bolt behind it. Remove the seat by lifting it up and back

2- Remove the front (driver's) seat). Remove the two bolts behind it and remove the seat by lifting it up and back.

3- Removing the seats will give you access to the battery under the driver's seat.

4- Carefully remove the positive and negative battery cables from the battery, then lift the battery straight up.

5- Place the new battery in the bike

6- Replace the cables, red is positive (+), black is negative (-)

7- replace the seats, and you should be good to go!

Hi, the oil for a vl 800 intruder 2001-2004 is
10w40 SG, it holds 3.4 litres, buy 4 litres and recheck level after initial starting,
Regards Paul

Use the allen wrench from the on board tool kit to remove the bolt behind the passenger seat pad, above your rear wheel. Pull the pad backwards to reveal 2 more bolts. Same allen wrench removes these two and the strap that secures the passenger pad. Pull the saddle back and you are done. Note that the bolt for the rear seat and the 2 for the saddle are not the same lengths when you go to put your cycle back together.
Battery is under the saddle.

Normally it's found under the driver seat

your battery is under your bike just behind the motor.if you remove or replace it. note the order of battery bolt length.

just type Suzuki VS 800 Intruder in google search. haynes on line will appear and you will see their posted manual.