Question about Keeway Motorcycles

2 Answers

Keeway 200 Superlight no brake light

My Keeway 200cc superlight speedometer is showing red light beam this happened after I washed the motorcycle and also the brake light stopped working need [email protected]

Posted by Aaron Lomax on

Ad

2 Answers

Gregg Mahin

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    One Above All:

    The expert with highest point at the last day of the past 12 weeks.

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

  • Keeway Master
  • 61,843 Answers

Hi, Aaron moisture, condensation, rain, or bike washing can make the bike run sluggish, not able to rev, and misfire. Older bikes, engine configuration, and exposed electrical components are at the front of the line for acting up. During the diagnostic procedure spray Electrical Contact Cleaner on corroded wire connectors/pins/sockets etc. and apply a liberal amount of "DIELECTRIC" grease to the mating harness/wire connectors. WD40 works great for eliminating suspect areas in your quest to find the real offending gremlin.
For additional insurance you can spray a High Temp Clear Coat on the most vulnerable areas it will work like Scotch Guard does on fabric. Fabricate a rubber or plastic splash guard to deflect water coming off the front wheel getting to the front cylinder spark plugs. The design should be adequate for its purpose with the least amount of airflow restriction to cool the cylinders. The usual suspects are:
1. Air filter soaked with water.
2. Water in the fuel system gas tank and carburetors.
3. Wet ignition coil packs.
4. Spark plug boots wore out or loose allowing water to enter.
5. Spark plug cables old and cracked check for spark leakage in the dark.
6. Spark plug wells filled up and drain holes clogged.
7. Water in a wire harness that has exposed open ends and have a sharp bend or crimp allowing the liquid to form its own pool of potential threats to chaffed wiring.
8. Sensitive fuel tuners and downloaded ECM remaps may get confused with the abnormal cylinder temperature difference in a V-4 engine configuration.
If your bike will not run right or even start after going through the checklist, despair not, letting it sit for a couple of days in a warm environment is like an eviction notice for the Gremlins and then your bike will be back to its old self.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Rear brake light not working fixed
Motorcycle Dash Warning Lights
Keeway superlight 125 service manual
Keeway Superlight 200 Parts Catalog pdf
Keeway RKV200 Electrical Diagram Eng pdf
Keeway Cruiser 250 Owners Manual Eng pdf

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

Posted on Nov 03, 2017

Ad

Francisco Padilha

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    New Friend:

    An expert that has 1 follower.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 81 Answers

Hi, be carefull red lights are always a sighn of trouble !!!
in your case please check the wiring connection at the oil pressure gauge (usualy in the front of crankcase ) As for the tail bake light, also check wiring connections at the brake pedal switch and front brake switch ( under brake lever) Also check bulb. It will bea good idea to spresd som wd40 all over the electrical connections . Hope this helps

Posted on Nov 03, 2017

Ad

5 Related Answers

Anonymous

  • 146 Answers

SOURCE: l head light low beem not working

You probably have the low side of your bulb blown check the bulb if that dont fix it ck your conector.if your dimmer switch was bad it wouldnt work on eather side. I will try to get you a diagram for the fuse box. PHIL.

Posted on Jan 06, 2009

tombones

  • 3567 Answers

SOURCE: keeway superlight 125 adjusments

Pull the slide out of the carb then move the clip on the jet needle down one or two notches. This will richen the low range fuel mix. You can also get a rear sprocket with about 4 more teeth. This will get you off the line and out of the corners faster BUT it will also lower your top speed.

Please rate this solution. Thanks supergunner!

Posted on Apr 17, 2009

tim winter

  • 200 Answers

SOURCE: 2 broken side panels for keeway superlight 125

This is something you should contact a Keeway dealer for....good luck...Tim

Posted on May 10, 2009

Anonymous

  • 4 Answers

SOURCE: i need service manual for machine for my keeway

Here it is:

Look for manuals.

http://keewaysuperlight.blogspot.com/

Posted on Aug 02, 2009

Anonymous

  • 20 Answers

SOURCE: were I can download keeway

this a the keeway website

http://www.keeway.me/models/superlight125/index.php

although recently the manual wont open i think it may be under maintance/update. but it is always worth going back to the website now then just to check.

best of luck.

Posted on Sep 04, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2007 Keeway Superlight 125 choke position


Hi, John for this scenario you will need your service manual that has all fastener torque specs and a wiring diagram on the back pages, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere $15 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
2007 Keeway Superlight 125 choke position Google Search
How to Adjust the IDLE on the Keeway Superlight 125
Service Manual 2006 Keeway Superlight 125 150 Motorcycle Download Manuals... $15
Keewayparts com Genuine Keeway Parts Shipped Worldwide
Keeway Superlight 125 2007

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


May 01, 2018 | 2007 Keeway Superlight 125

Tip

Tips & Tricks for Keeway Superlight (In Spanish)


Here is my small contribution for all Superlight owners:

http://keewaysuperlight.blogspot.com/

Enjoy!

on Jan 20, 2009 | 2008 Keeway Superlight 125 II

1 Answer

2009 Keeway Superlight 125 lights are not working


Hi, Neil if your headlight is not working, intermittent, only one beam works, keeps burning out, blinking, dim or surges from bright to dim to bright the first thing you need to check is the headlight bulb for damaged filaments then check your light circuit fuse, then check your head light bulb socket ground wire for a clean tight connection, that being said the usual suspects are:
1. Faulty ground or power supply wire to headlight bulb socket.
2. Worn down solder contacts or loose fit of the bulb base in the socket due to vibration.
3. Worn, chafed, or broken wires in the light circuit.
4. Corroded, broken, or loose pins/sockets in wire connectors.
5. Faulty hi/low beam switch.
6. Faulty ignition switch.
7. Fuse is good but no continuity on both sides.
8. Faulty headlight relay.
9. Faulty wiring between battery positive and headlight bulb socket.
10. Weak charging alternator/generator/lighting coil
11. Faulty voltage regulator/rectifier ground or overcharging.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Newbie on Keeway Superlight problem after problem
Ignition turned on but no power at all Bike just stop working
Keeway superlight 125 service manual
Keewayparts com Genuine Keeway Parts Shipped Worldwide KEEWAY Speed 125 User Manual

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

Feb 17, 2018 | 2009 Keeway Superlight 125

1 Answer

How to change the radiator in my keeway superlight...???


Hi, Anonymous for this scenario you will need your service, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Keeway superlight 150 service manual
Keeway Parts Keeway Parts Suppliers and Manufacturers at Alibaba com
http://http2.internetarchitects.be/keeway_superlight_150_user_manual.pdf
Keeway Superlight 150 2015
Keeway Superlight

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

Aug 29, 2017 | Keeway Motorcycles

1 Answer

Keeway Superlight knocking noise from engine


Hi, Killian I would love to help you with your engine or chassis noise but I just loaned my brand new pair of listening ears to your local dealer's chief technician so he could take your bike for a test ride and give you his professional opinion and estimate about your noise and repair cost. If you are a little short on "DRACHMA" and a Dealership is not on your list of fun places to visit then perhaps the list below will help soothe your worried mind so you can make an informed decision.
1. Bearings---SCREECH
2. Belts---CHIRP
3. Brake Rotors---BUZZ
4. Chains---RATTLE
5. Clutches---CHATTER
6. Cylinders---PING
7. Fronk Forks---Plunk
8. Gears---WHINE
9. Head Gasket---HISS
10. Hydraulic Lifters---TAP
11. Pistons---SLAP
12. Rear Shocks---SQUEAK
13. Shifting Trans---CLUNK
14. Solid Lifters---TICK
15. Starters---CLICK
16. Connecting Rods Go---KNOCK-KNOCK---who's there, it's me "*****"
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Performance Scooter Tuning Maintenance Repair
How to diagnose problem by the noises your bike makes
KEEWAY SUPERLIGHT 125 150 SCOOTER SERVICE REPAIR MANUAL 2006 2012 Download... $10 cheap
Keeway Superlight 200 Parts Catalog pdf
KEEWAY Speed 125 User Manual

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

Apr 23, 2017 | Keeway Motorcycles

1 Answer

Ajusting tickover on keeway superlight 125


Hi, Anonymous for more information about your question and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
Keeway Superlight 125 carb issue
Keeway Superlight 125cc 2008 After riding for while difficult to put...
RM 125 IDLE ADJUSTMENT
PDF Moto Manual

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


Apr 23, 2014 | 2007 Keeway Superlight 125

1 Answer

Top speed keeway superlight 200


Hi, Anonymous for more information about your question and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
How to up the speed on my 125
Keeway Superlight 200 Price Specs Review Pics Mileage in India
Rks keeway 200cc topspeed
PDF Moto Manual

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


Oct 02, 2013 | 2007 Keeway Superlight 125

1 Answer

Tyre Pressures for Keeway Superlight 125 II


I also have a keeway super light 125 and the tire pressure is 33 PSI in the front and back.

Mar 27, 2013 | 2008 Keeway Superlight 125 II

2 Answers

2 broken side panels for keeway superlight 125


This is something you should contact a Keeway dealer for....good luck...Tim

Mar 13, 2009 | 2008 Keeway Superlight 125 II

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

187 people viewed this question

Ask a Question

Usually answered in minutes!

Top Keeway Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

richard libby

Level 2 Expert

209 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

6342 Answers

Are you a Keeway Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...