Question about 2008 Genuine Scooter Roughhouse R50

1 Answer

Dead battery 2008 Genuine Scooter Roughhouse R50

Dead battery for genuine roughhouse @

Posted by Anonymous on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    One Above All:

    The expert with highest point at the last day of the past 12 weeks.

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

  • Genuine Master
  • 59,350 Answers

Hi, Anonymous before testing any electrical component in the Charging System it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage, the battery is faulty and must be replaced. AGM type batteries fall into this scenario more so than lead-acid batteries.
1. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
2. To check the regulator unplug it from the stator. Take a test light and clip it to the negative terminal of the battery and then touch first one pin and then the other on the plug that goes to the regulator. If you get even the slightest amount of light from the test light the regulator is toast.
To do this with a meter: black lead to battery ground, red lead to each pin on the plug, start with the voltage scale higher than 12vdc and move voltage scale down in steps for each pin. Any voltage is a bad regulator.
3. On the other part of the disconnected regulator plug. Set the multimeter for Ohms x1 scale and measure for resistance across the pins of the stator. You should read something around 0.1 to 0.2 ohms for a 32 amp system.
4. Then check for continuity between each pin on the plug and frame/engine ground. The meter needle should not move (infinite resistance)(digitals will show infinite resistance) if the meter needle does move (indicating continuity)(digitals will show some resistance), recheck very carefully. If the meter still shows continuity to ground the stator is shorted (bad).
5. Set the meter to read A/C volts higher than 30 volts (the scale setting for voltage should always be higher than the highest voltage you expect or you may fry the meter). Start the bike, and measure from one pin to the other on the plug (DO NOT cross the multimeter probes! - touch them to each other). You should read roughly 16-20 vac per 1,000 rpm.
6. If the battery was good under load test, if the stator is NOT shorted to ground, and the stator is putting out A/C voltage, then the regulator is bad (most likely even if passed step 2)
For more information about your question and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
http://www.scooterloungeonline.com/genuinebuddybatteries
http://www.modernbuddy.com/forum/topic9056.html
http://www.epfguzzi.com/scooterpunks/manuals/index.html
https://www.scootertuning.ca/en/3005-genuine-roughhouse-50?gclid=EAIaIQobChMI58Pbz_nb5QIV04NaBR0gggKvEAAYASAAEgK5yPD_BwE
https://absolutelyscooters.net/pdf/CGEN_dawg_scooter_manual.pdf

Posted on Nov 09, 2019

Ad

2 Suggested Answers

6ya6ya

6ya staff

  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad

Joe Hogan

  • 10865 Answers

SOURCE: I just bought 2009 Roughhouse

hello andy. true. just a reminder to keep an eye on the fuel level. /J.

Posted on Jul 16, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Scooter will start but will not rev up when throttle is advanced


I would start by cleaning the carb , take the float bowl off and blow out the jets .

Nov 19, 2014 | 2010 Genuine Scooter Roughhouse R50

1 Answer

Can i start my scooter without my key


if you cut or connect the correct wires you can bypass post ignition switches

Nov 13, 2014 | 2008 Genuine Scooter Roughhouse R50

1 Answer

An English word with hh in the spelling


From shh to highhandedness you quite a few words.
The longest one : highhandedness. If you want to use some plural form of it you will have a longer word.
Hitchhike, roughheaded, roughhoused,

Jan 15, 2014 | Computers & Internet

1 Answer

Word containing letters


From shh to highhandedness you quite a few words.
The longest one : highhandedness. If you want to use some plural form of it you will have a longer word.
Hitchhike, roughheaded, roughhoused,

Jan 15, 2014 | Computers & Internet

1 Answer

Where is the battery In a roughy house 50 scooter ?


The battery is in the floorboard. You should see a small section of the floorboard secured with a screw or screws. Once that cover is removed you can access the battery and fuse.

Nov 10, 2013 | 2008 Genuine Scooter Roughhouse R50

2 Answers

Where is the battery in a rough house 50 scooter ?


While I don't own a Roughhouse, I have owned a couple other Chinese made scooters. There is a very good chance the battery is located under the floorboard of the bike. I looked at a few photos of the scooter online ad it looks like there is a small door in the middle of the floorboard. I believe they like to put the batteries low on these bikes to help keep the center of gravity low.

Good luck.

Nov 10, 2013 | 2008 Genuine Scooter Roughhouse R50

1 Answer

Microsoft genuiune software


Tell me if Your prob is product key? I will give it to you, or How you install? Simply insert your cd or dvd then click install, product key, next, next, & i accept.

May 26, 2011 | Microsoft Office Professional 2007 Full...

Not finding what you are looking for?
2008 Genuine Scooter Roughhouse R50 Logo

Related Topics:

40 people viewed this question

Ask a Question

Usually answered in minutes!

Top Genuine Experts

Marvin
Marvin

Level 3 Expert

85206 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

5954 Answers

ANTISPAMMER

Level 3 Expert

33381 Answers

Are you a Genuine Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...