Question about 2003 Suzuki GZ 125 Marauder
My Suzuki gz Marauder 125 keeps losing power over 30mph @
Hi, Arron and the usual suspects are:
1. Dirty or clogged air filter.
2. Faulty spark plug.
3. Bad Gas.
4. Improper oil level.
5. Improper chain adjustment and lubrication.
6. Low tire pressure.
7. Dirty or contaminated carburetor needs cleaning and tuning.
8. Clogged or faulty fuel pump or injectors.
9. Improper valve adjustment.
10. Slipping clutch.
11. Improper timing.
12. Low compression.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Suzuki GZ125 Marauder 1998 2005 Service Repair Manual Download Manuals... $15
Posted on Apr 08, 2019
hi i am a locksmith you have on the ignition 2x dome head bolts closest to fuel tank the only way to remove the ign is a hammer and centre punch use the punch to tap bolt undone
hope this helps
Posted on Jun 17, 2009
SOURCE: Carb Problem GZ 125cc
First check the throttle cable free operation. Check rubber manifold couplings for air leak. If programmable firing control is used check the switch. Refer user guide.
Check program switch operation. This is coupled to the throttle cable. This switch sets the ignition timing advance or ******. This is called power mode operation switch.
Clean the carburetor with diesel or kerosene. Do the cleaning out-doors. Clean all the jet orifices with air. Use correct tools. Especially the flat blade screw driver tip.(end should not be sharp )
Note down pilot jet air screw position. Note the number of turns you screw out. This is needed for resettling the air screw. If it is a CV carburetor check the rubber diaphragm for stiffness or damage.
Needle jet is coupled to this diaphragm. Throttle cable opens the circular gate only. Due to velocity of the air the diaphragm positions the needle. Try the easy checks first. Finally main chain tension. Follow the solution given by Fixya GURU also
Posted on Jul 21, 2010
SOURCE: my suzuki 125 maruader gz
Be sure to put a new spark plug cap on your coil, it may have been the cause of the problem to begin with. It is possible to wet foul a new spark plug, therefore if the new plug got wet it could also be causing the problem. Do not be afraid to try third spark plug just in case the new one went bad. Also check the intake manifold for cracks or separation. The manifold could also have a cracked o-ring or a leaking gasket. An air leak on the intake side could be causing the misfire.
Posted on Apr 05, 2011
Tips for a great answer:
Apr 13, 2017 | 2000 Suzuki GZ 125 Marauder
Feb 15, 2017 | 2003 Suzuki GZ 125 Marauder
Dec 01, 2017 | 2000 Suzuki GZ 125 Marauder
Sep 09, 2010 | 2003 Suzuki GZ 125 Marauder
Sep 02, 2010 | 2000 Suzuki GZ 125 Marauder
May 15, 2010 | 2003 Suzuki GZ 125 Marauder
Jun 15, 2009 | 2003 Suzuki GZ 125 Marauder
Aug 12, 2020 | kawasaki Motorcycles
Aug 08, 2013 | Motorcycles
73 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: