Suzuki RM-Z 250 - Recent Questions, Troubleshooting & Support - Page 8


http://www.bikebandit.com/suzuki-motorcycle-rmz250-2004/o/m6667

Here is a link to bike bandits carb page for the rmz. Looks like the stock pilot is 35 and the main is 168, it looks like there are two other jets too, starter and power.

2004 Suzuki RM-Z... | Answered on Oct 07, 2009


dirt on disc/dirt in the caliper take the caliper off and clean it with a wire bruch and get back to me

2005 Suzuki RM-Z... | Answered on Sep 27, 2009


de decompressor as to be there....those four stroke need a good kickstart to fired ( without decompressor can broke you're kickstart pedal or hurt you badly..) i sugest you recheck valve clearance and make sure the timing is done when you are at top death center and you're exhaust cam is about to be open shortly after top death center.( that means you are in the right position to align the mark on both cam to each side of the head....also you can check out for fire problemme ( timing or firing at wrong time) you said it as fire then just put gaz into the spark plug hole (a spoon) then it should start right away or try to....then if it wont start you know carburation is not an issue because you by pass the carb by injected gaz right on top of piston...then only thing left is fire and compression...if you have all that one with care....let me know ill find away to make that things [email protected] .....stephane.

2004 Suzuki RM-Z... | Answered on Sep 24, 2009


hi buddy these picture will help you the axle block will have a line in the middle and it will line up with the marks on the frame 960859f.jpg
8522dbc.jpg

2005 Suzuki RM-Z... | Answered on Sep 23, 2009


200 pound for a rmz250 tell them to take a run mate atleast £1300 minimum depending on condition

2004 Suzuki RM-Z... | Answered on Sep 15, 2009


Did you forget the crankshaft seal or install the wrong part behind the flywheel? It should be replaceable when the flywheel is pulled. I'm not sure what that has to do with blue smoke coming out of the exhaust. Did you over-oil the rings when you put it together? The smoke may clear itself after running a while. Other than fouling the plug and alerting the EPA, it won't hurt it to smoke a little while. Did you check to see that the oil level in the crankcase was correct?

2005 Suzuki RM-Z... | Answered on Sep 03, 2009


Clean the spark plug first and try to start by pressing the choke.If still facing the problem check the kicker socket by a mechanic. This should work.

2004 Suzuki RM-Z... | Answered on Aug 31, 2009


Sounds like the timing may be advance too far or the carb could be needing adj.

But since its running hot first check with the timing....there may be other issues such as wear or lack of oiling causeing your problem as well

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/sean_54c3a3dc48a7773c

Suzuki RM-Z 250... | Answered on Aug 29, 2009


Change the induction coil or change the spark-plug.

2005 Suzuki RM-Z... | Answered on Aug 25, 2009


  • Do you see spark? If not, check the side stand kill switch. It kills the engine so that you don’t start out with the side stand down. If broken or out of adjustment, it would kill the spark. Check for a broken wire at the side stand switch and coupler. Try moving the side stand kill switch by hand. If that doesn’t work then wire a jumper around the switch to bypass it.
  • Is the handlebar kill switch on? Is it shorted out?
  • Check the fuses.
  • Check the operation of the ignition switch and all kill switches with a volt ohmmeter. Check the wiring harness. Did a wire come unplugged? Are all wires clean and with solid connections? Any abraded or pinched wires?
  • Is the bike in neutral and the neutral light is lit up? If no neutral light, check the neutral switch and neutral switch wire on center or side casing.
  • If still no spark, get CDI system and coils checked at the dealers shop.

2005 Suzuki RM-Z... | Answered on Aug 14, 2009


hi mate fill it until the sight glass is 1/2 - 3/4 full or if there is a dipstick fill it to the correct requirements on the stick

2004 Suzuki RM-Z... | Answered on Aug 08, 2009


You mean the flywheel? You need a puller for that, and it threads into the flywheel with left handed threads!

2005 Suzuki RM-Z... | Answered on Aug 08, 2009


YOUR VALVE CLEARANCES NEED TO BE ADJUSTED BACK TO FACTORY SPECS...IN OTHER WORDS GET IT SERVICED AT A BIKE SHOP

2004 Suzuki RM-Z... | Answered on Aug 06, 2009


YOUR BIKE HAS A POWER VALVE (DIAPHRAM FUEL PUMP) THAT GIVES A SHOT OF GAS EACH TIME THE THROTTLE IS TWISTED. WHEN THE BIKE IS HOT, IT FLOODS EASILY. DON'T HIT THE THROTTLE WHEN STARTING THE BIKE WHEN THE ENGINE IS HOT.

2004 Suzuki RM-Z... | Answered on Jul 31, 2009


Like I told somebody earlier to day lower the octane rating of the gas you are using....repost if you need anything futher......

2005 Suzuki RM-Z... | Answered on Jul 26, 2009


get the thermal wrap under the gas tank then if you can afford it buy the new vortec clutch it helps with starting a four stroke

2005 Suzuki RM-Z... | Answered on Jul 21, 2009


i usually adjust tension by lifting the chain from rest to 1/2 inch & when it starts to resist its at that point !
make sure you adjust both sides of the rear axle the same amount or the wheel will be out of alignment!

Suzuki RM-Z 250... | Answered on Jul 20, 2009


needs the carb cleaned out.

2004 Suzuki RM-Z... | Answered on Jul 13, 2009


Use 10w40 motor oil in the gear box. Don't use any synthetic oils, oil marked "EC", or oil with "special" additives. Stick with the major brands; Pennzoil, Quaker State, Mobil or Shell. If in a hot area like Texas or New Mexico go with 20w50.
2dffcc1.gif
Use TWO STROKE ENGINE OIL in the pump. If not using an automatic oil pump, then mix the gas and oil 32 to 1. That equals 4 ounces of TWO STROKE ENGINE OIL to one gallon of gas. NEVER use motor oil in the gas. Only two stroke engine oil.

2004 Suzuki RM-Z... | Answered on Jul 13, 2009


it mite be getting in to the magneto(under the cover near your gear stick) you can test it by starting it at home and get the hose and squirt it or the wires mite have been damaged.

2004 Suzuki RM-Z... | Answered on Jul 05, 2009

Not finding what you are looking for?
Motorcycles Logo

183 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Suzuki Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

6495 Answers

Gino Cussen
Gino Cussen

Level 2 Expert

217 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Suzuki Motorcycles

  • Forum

View Most Popular

  • Suzuki Motorcycles
Loading...