20 Most Recent 2005 kawasaki ZRX 1200 R Questions & Answers


Well there only one way the fuel can get into the crankcase and that's from the fuel tank. The petcock must be draining and the float needles are not stopping the fuel flow. Do you have a prime position on the petcock? If so do not run the bike in the position. Try topping the tank off with gas and letting it sit for a while and see is the gas has gone down and then check the crankcase and see if there's fuel in it again. i still say its got to be your petcock.

2005 kawasaki... | Answered on Nov 26, 2015


piston rings gone fuel is passing the rings or the valve seals are gone best to take to a garage as its a very difficult/technical job

2005 kawasaki... | Answered on Oct 01, 2009


Hi there,
download service manual from the below link
http://rapidshare.com/files/46199220/Kawasaki_20ZRX_201200_20-_20Service_20Manual.pdf

its free of cost. i am also try to find owners manual for you but there are no one on net.
Good Luck!!!

neo

2005 kawasaki... | Answered on Apr 08, 2009


USUALLY THIS IS A FUEL PROBLEM, OR COULD BE THE CARBS NEED BALANCING

kawasaki ZRX... | Answered on Sep 09, 2014


Is this the sound of 4 pistons goin up an down???

kawasaki ZRX... | Answered on Aug 21, 2014


What is the bike ?

kawasaki ZRX... | Answered on Jan 31, 2012


Fairl straight forward job, start at the top avoiding any tight bends with the wheel clear of the ground insert the cable whie turning the wheel this will hellp locate the cable a small amount of grease wouldnt heart

kawasaki ZRX... | Answered on Sep 17, 2011


The wires are not replaceable. They are part of the coils

kawasaki ZRX... | Answered on Apr 29, 2011


Know that most shops will probably refuse to do repairs on your bike if it is more than 10 years old. Most all shops use this same standard. Parts availability is the main problem. In any event, below are things to look for if getting a used bike.

Does the engine start easy and idle smoothly? Does it accelerate without hesitation?
Any smoke when it starts or when pulling away from stop light? (Bad valve guides).
Any smoke when riding at 30mph? (Piston rings worn or possible previous seize up).
Does the clutch engage and disengage smoothly? Clutch lever easy to pull?
Any oil or coolant fluids leaking after a ride?
Do all gages work? Lights, horn and flashers?
Any red lights on the gages lit up? Any computer codes flashing?
Do front and back brakes operate and stop smoothly?
Is the motor oil pretty clean or really dirty? (Sign of how well the owner has cared for the bike).

Is the oil "white-ish"? (water in the oil. If motor is water cooled it's usually bad water pump seals).
Any funny sounds from the gear box? Anywhere else?
Does it shift smoothly up and down the full gear range? Neutral light come on properly?
Sprockets still have rounded tips not pointed? Well lubricated chain?

Good tires? How old is the battery? All lights work properly?
Is the upholstery good? Plastics cracked or broken?
Gas tank badly rusted inside? Do the wheels run true or weave?

Do the forks look bent from a side view or front view?
Does it drive nice or is the bike squirrely to drive? How about around curves and corners?
Ever been wrecked? What service work has been done in the past?
With the handlebars driving straight ahead, is the front wheel pointing a slightly different direction?
Do all accessories work properly?
Ask what doesn't work on the bike. What known problems do exist?

.
These are things to look for. I hope this helps.

A “very helpful” rating for this answer? Thanks!

kawasaki ZRX... | Answered on Jul 26, 2009


remove the top of the carburator, compress the spring on the jet, you will see the end of the throttle cable, unhook it from the holder, unthread the top of the cable from the carburator, pull the cable out. Now it is disconnected from the carburator, now disconnect from the throttle handle by removing the the two screws on the handle, unscrew the adjustment, then detach the cable. Replace in repeat order.

kawasaki ZRX... | Answered on Jul 05, 2009


WE HAVE NO IDEA IF IT WILL OR NOT

kawasaki... | Answered Yesterday


ask kawi about a service manual

kawasaki... | Answered on Nov 18, 2020


See if it is coming from the rocker cover above it. If not, it is oil off the cylinder bore that is seeping out instead of being burned. Replace the exhaust gasket.

https://kawasaki.ph/motorcycles/barako-ii/barako-ii/

..

kawasaki... | Answered on Nov 17, 2020


Contact Kawasaki directly to request the wiring diagram.

kawasaki... | Answered on Nov 03, 2020


Ideal spark plug gap varies slightly depending on brand - check the online application catalogue for the brand of plug fitted to your bike and the recommended gap will be found in the relevant entry.

kawasaki... | Answered on Nov 01, 2020


Google would have a manual then for a 1986 Kawasaki KX80 manuals and EBay too.

kawasaki... | Answered on Jul 31, 2020

Not finding what you are looking for?
2005 kawasaki ZRX 1200 R Logo

6 questions posted

Ask a Question

Usually answered in minutes!

Top kawasaki Experts

Arnie Burke
Arnie Burke

Level 3 Expert

6487 Answers

Marvin
Marvin

Level 3 Expert

85239 Answers

Gino Cussen
Gino Cussen

Level 2 Expert

217 Answers

Are you a kawasaki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

ZRX 1200 R kawasaki

  • ZRX 1200 R kawasaki

Most Popular Question

air box crank case fuel flooding problem

  • Motorcycles
Loading...