2002 Kymco Hipster 125 - Answered Questions & Fixed issues


Hi, Anonymous before testing any electrical component in the Starting System it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage, the battery is faulty and must be replaced. AGM type batteries fall into this scenario more so than lead acid batteries.
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter.
4. Bank angle sensor needs a reset or is faulty.
5. FOB battery low or dead.
6. Faulty ignition switch.
7. Faulty starter button.
8. Faulty kickstand, clutch, neutral safety switch.
9. Security alarm needs a reset.
10. Starter relay, solenoid, starter motor or circuit wiring faulty.
11. Starter armature or field coils have failed.
12. Main fuse or circuit breaker may be blown or faulty.
13. Faulty ignition relay.
14. The electric starter is working but starter clutch has failed.
15. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Bike won start any ideas
What Do Check When My Motorcycle Won Start Honda Shadow Forums Shadow...
Kymco Hipster 125 150 Motorcycle Complete Workshop Service Repair Manual... $20
Genuine Kymco spare parts
Manuals Kymco

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2002 Kymco... | Answered on Sep 11, 2017 | 72 views


the valve timing mark is on the flywheel on the Hipster's.

Remove the large flat blade screw from the top of the left hand side casing. Turn the engine either by hand (using kickstart with ignition off), turning rear wheel in gear, or by removing the "kymco" badge with three 8mm bolts and using a 19mm deep socket on the crank, until you see two marks (one says F one say T) the F one is the advance firing mark, the T mark is the timing mark. Keep turning the engine over and watch your valves, wait for the exhaust valve to close, inlet valve to open and then close again then the next time you see the T line will be TDC. This is where you set your valve timing from.

2002 Kymco... | Answered on Aug 18, 2013 | 348 views


  • Back tyre 130/90-15

2002 Kymco... | Answered on Sep 16, 2010 | 166 views


10w40 motor oil. Never use synthetics or oil with " Special " additives.

2002 Kymco... | Answered on Sep 02, 2010 | 314 views


Hi, Barrieandroe for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Kymco, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Clock not working
Fuel Gauge Sending Unit Troubleshooting
Manuals Kymco
http://kymcopartsonline.com/catalog/table_overview.php?s_fk_manufacturers_id=21&s_fk_model_ye
http://kymcopartsonline.com/catalog/table_overview.php?s_fk_manufacturers_id=21&s_fk_model_ye
https://www.manualslib.com/manual/767692/Kymco-Agility-City-50.html#product-Agility%20City%20125

Kymco Hipster... | Answered on Jul 10, 2019 | 94 views


Hi, Anonymous for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Kymco, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.manualslib.com/manual/1329507/Kymco-Movie-125.html?page=40
Chinese motorbike adjust valve clearance 1
Manuals Kymco
Kymco Scooter Parts ATVs Scooter Parts Performance Scooter Parts...
https://www.kymcousa.com/admin/dealeronly/ownerman/onroad/Movie150-OwnersManual.pdf

Kymco Hipster... | Answered on Jul 10, 2019 | 31 views


Hi, Anonymous for the wobble the usual suspects are:
1. Improperly loaded motorcycle. Non-standard equipment on the front end such as heavy radio receivers extra lighting equipment or luggage tends to cause unstable handling.
2. Incorrect air suspension pressure.
3. Damaged tires or improper front-rear tire combination.
4. Irregular or peaked front tire tread wear.
5. Incorrect tire pressure.
6. The shock absorber is not functioning normally.
7. Loose wheel axle nuts. Torque to recommended specifications.
8. Excessive wheel hub bearing end play.
9. Improperly vehicle alignment.
10. Steering head bearings improperly adjusted.
11. Tire and wheel unbalanced.
12. Rims and tires are out-of-round or eccentric with the hub.
13. Rims and tires are out-of-true sideways.
14. Loose spokes.
15. Shock absorber improperly adjusted.
16. Worn engine stabilizer links.
17. Damaged rear engine isolation mounts.
18. Swing arm pivot shaft improperly tightened or assembled.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.bikechatforums.com/viewtopic.php?t=48595
https://advrider.com/f/threads/kymco-agility-125-slow-warm-up-and-stumbling-idle-issues-problem-resolved.1086377
Manuals Kymco
Kymco Scooter Parts ATVs Scooter Parts Performance Scooter Parts...
https://www.kymcousa.com/admin/dealeronly/ownerman/onroad/Movie150-OwnersManual.pdf

Kymco Hipster... | Answered on Jul 10, 2019 | 21 views


Check your fuses and if they're good, check the connections at the far end of the battery cables. If they are clean and tight, check the battery cables themselves for continuity. If all of the above are good, start troubleshooting from the keyswitch back. If you know which terminals to jump out at the keyswitch for the lights, jump them out; if the lights light up, suspect the switch.

Kymco Hipster... | Answered on Jun 25, 2011 | 240 views


check your connection..first check the battery power, if the power is full, check the fuse just connected not far from the battery, if is also good, check the starter moter,,i hope u will be helped

Kymco Hipster... | Answered on Mar 30, 2011 | 146 views


http://www.repairmanualclub.com/motomanuals/index.php

Kymco Hipster... | Answered on Feb 27, 2011 | 41 views


Get manual here

http://www.repairmanualclub.com/motomanuals/index.php

Kymco Hipster... | Answered on Feb 27, 2011 | 266 views


get a manual here free


http://www.repairmanualclub.com/motomanuals/index.php

Kymco Hipster... | Answered on Feb 24, 2011 | 82 views


Hi ice_basher

You need to check the following

1) . The carborator & air filter are proper or not.
2). The race & pickup is adjusted or not.
3). Ask your mechanic to chk the power output in bhp. Match it with the pescribed one.
4). The accelerator & clutch are properly working or not.

Your problem can be because of any of these. Please do a through check.

Kymco Hipster... | Answered on Feb 04, 2011 | 483 views


get a screwdriver and cross the start solanoid and see if it turns over and the buzzing might be from a low battery try charging your battery up first

Kymco Hipster... | Answered on Jul 25, 2009 | 406 views


Duplicate question already answered

Kymco... | Answered on Jun 22, 2020 | 26 views


Hi, John for this scenario you will need your service manual that has all fastener torque specs -fluid capacities and a wiring diagram on the back pages, parts fiche, and owners manual if you can not find the best tool you ever bought for your Kymco, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.kymcoforum.com/index.php?topic=24309.0
https://www.kymcohealthcare.com/uploads/userguide/20150409101920.4534.pdf
http://docs.monsterscooterparts.com/kymco/agility_servicemanual.pdf
https://www.monsterscooterparts.com/scooterparts/street-brands/kymco/kymcoagility50
https://www.manualslib.com/manual/393386/Kymco-Agility-125.html#product-AGILITY%2050%20-%20SERVICE
https://www.manualslib.com/manual/766732/Kymco-Agility-125.html

Kymco... | Answered on Jun 22, 2020 | 31 views


Yes ... and ..........

Kymco... | Answered on Jun 05, 2020 | 28 views

Not finding what you are looking for?
2002 Kymco Hipster 125 Logo

Popular Tags

9 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Kymco Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Muntejaya Ginting
Muntejaya Ginting

Level 3 Expert

10422 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

6418 Answers

Are you a Kymco Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...