20 Most Recent 2008 Keeway F-act 150 Questions & Answers


Hi, Ripper8594 for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.amazon.com/Throttle-Cable-125cc-150cc-Scooters/dp/B0083WMRAI
https://www.youtube.com/watch?v=KtgPY9TNSKA
https://www.carlsalter.com/jonway-service-manuals.asp
https://www.monsterscooterparts.com/scooterparts/street-brands/jonway-parts
https://absolutelyscooters.net/pdf/CGEN_dawg_scooter_manual.pdf

2008 Keeway... | Answered on Oct 04, 2019


Hi, Hibbyswa before testing any electrical component in the Starting Circuit it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage, the battery is faulty and must be replaced. AGM type batteries fall into this scenario more so than lead-acid batteries.
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Engine Run Switch is "FAULTY" or corroded.
4. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter.
5. Bank angle sensor needs a reset or is faulty.
6. FOB battery low or dead.
7. Faulty ignition switch.
8. Faulty starter button.
9. Faulty kickstand, clutch, neutral safety switch.
10. Security alarm needs a reset.
11. Starter relay, solenoid, starter motor or circuit wiring faulty.
12. Starter armature or field coils have failed.
13. Main fuse or circuit breaker may be blown or faulty.
14. Faulty ignition relay.
15. The electric starter is working but starter clutch has failed.
16. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=wiring+diagram+2008+Keeway+F-act+150&tbm=isch&source=univ&sa=X&ved=2ahUKEwjMt8zrsIHlAhUB2qwKHXFUBVAQsAR6BAgIEAE&biw=1440&bih=757
http://www.scooterfocus.com/scooter_troubleshooting.html
http://en.keeway-club.com/manuals.php?ddlb_category=11
http://keewayparts.com/
https://absolutelyscooters.net/pdf/CGEN_dawg_scooter_manual.pdf

2008 Keeway... | Answered on Oct 04, 2019


I am having the same problem and i have tried pulleng too

2008 Keeway... | Answered on Nov 22, 2012


colour code for CDI on jonway spray

2008 Keeway... | Answered on Sep 07, 2012


The problem may be the accumulator (battery). If you don't have a kicker, try changing the battery

2008 Keeway... | Answered on Jul 25, 2010


G'day bigknc.Never heard of a jonway before.I think they really wanted to call it a "john Wayne"but they probably thought 2 first names sounds a bit geeky.Anyway....First you will have to find the source of the leak .If that beast is leaking coolant from the overflow on the radiator tank then that tells us of a pressurised system either though overheating or a leaking head gasket.If it's leaking from the weep hole on the engine where the propeller pump is then you've got a leaking seal.Could also be a loose hose clamp.Look for the easy fix options first . but you will need to pin point where the leak is....Hope i could help..Tabbycat 282

2008 Keeway... | Answered on Oct 02, 2009


I found that if I run 87 octane gasoline the engine accelerates up to full speed without the skipping and bogging down at any point it is running. It is worth trying. also try putting some "Sta-bil" fuel stabilizer in the gasoline - it has the ability to keep the carbureator cleaner. Not just during the time you are storing it, but rather all the time.

2008 Keeway... | Answered on Jun 03, 2009


Hi, Darren for this scenario you will need your service manual that has all fastener torque specs and a wiring diagram on the back pages, parts fiche, and owners manual if you can not find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?sxsrf=ACYBGNScpkE9obydjb63HvgcK_kirf4-Zw:1583163967471&q=Where+is+the+fuse+box+location+on+a+keeway+125cc+superlight&tbm=isch&source=univ&sa=X&ved=2ahUKEwietpuvkfznAhWyd98KHXoqBM0QsAR6BAgJEAE&biw=1440&bih=757
https://www.youtube.com/watch?v=1TEyqJCXmrI
https://www.slideshare.net/DanielRosario1/keeway-superlight-125-service-manual
https://www.chinesemotorcyclepartsonline.co.uk/manufacturers/Keeway
https://www.manualslib.com/manual/1002130/Keeway-Speed-125.html

Keeway... | Answered on Mar 03, 2020


Hi, Yvonne for this scenario you will need your service manual that has all fastener torque specs and a wiring diagram on the back pages, parts fiche, and owners manual if you can not find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.troublecodes.net/pcodes/p0685/
https://www.obd-codes.com/p0685
https://www.slideshare.net/DanielRosario1/keeway-superlight-125-service-manual
https://www.motor-x.com/czesci-do-motocykla,keeway,rks-125-2
https://www.manualslib.com/manual/1076829/Keeway-2015-Rks-125-26.html

Keeway... | Answered on Jan 02, 2020


Hi, Slicks_engin for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://kosonorthamerica.com/faq/how-to-change-speed-unit-from-kmh-to-mph/
https://www.youtube.com/watch?v=O91iSuioxtQ
https://www.manualslib.com/manual/922664/Keeway-Rkv125.html
http://keewayparts.com/
https://www.manualslib.com/manual/1076829/Keeway-2015-Rks-125-26.html

Keeway... | Answered on Oct 07, 2019


Hi, Braderechill and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Quick disconnect check ball stuck.
14. Compression below 75 PSI.
15. A stuck-bent-burnt valve.
16. Improper valve clearance (too tight)
17. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
18. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
19. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
20. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections are loose or connected to the wrong cylinders.
21. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
22. Faulty neutral, clutch, kickstand safety switch.
23. Faulty fuel pump or fuse or relay.
24. Faulty or corroded run/stop switch.
25. Tilt sensor needs a reset.
26. Security system not disarming alarm needs a reset.
27. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.killermotorsports.com/scooter-power-no-start/
https://www.motorcyclecruiser.com/what-to-do-if-your-motorcycle-doesnt-start/
http://www.49ccscoot.com/manuals/Keeway_50cc_2T_Service_Manual.pdf
http://keewayparts.com/
https://waimh2018.org/keeway-x-ray-owners-manual.pdf

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.bikechatforums.com/viewtopic.php?t=325147
https://www.google.com/search?q=Sidelight+replacement+Keeway+RKV+125&tbm=isch&source=univ&sa=X&ved=2ahUKEwjhiJ2ju4rlAhUjqlkKHaSOBAEQsAR6BAgIEAE&biw=1440&bih=757
https://www.manualslib.com/manual/922664/Keeway-Rkv125.html
http://keewayparts.com/
https://www.manualslib.com/manual/1076829/Keeway-2015-Rks-125-26.html

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Quick disconnect check ball stuck.
14. Compression below 75 PSI.
15. A stuck-bent-burnt valve.
16. Improper valve clearance (too tight)
17. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
18. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
19. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
20. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections are loose or connected to the wrong cylinders.
21. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
22. Faulty neutral, clutch, kickstand safety switch.
23. Faulty fuel pump or fuse or relay.
24. Faulty or corroded run/stop switch.
25. Tilt sensor needs a reset.
26. Security system not disarming alarm needs a reset.
27. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
http://www.andalucia.com/forums/viewtopic.php?t=30404
http://www.scooterfocus.com/scooter_troubleshooting.html
https://www.manualslib.com/manual/846068/Keeway-50cc-Series.html
http://keewayparts.com/
https://www.manualslib.com/manual/645856/Keeway-Hurricane.html

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous and the usual suspects are:
1. Improper clutch adjustment or not disengaging.
2. Bent shift shaft.
3. Shift fork bent or seized.
4. Gear seized on the shaft.
5. Gear positioning lever binding.
6. Shift return springs weak or broken.
7. Shift return spring pin loose
8. Shift mechanism arm spring is broken.
9. Shift mechanism arm is broken.
10. Shift drum is broken.
11. Shift lever loose on the shift shaft.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=Will+not+shift+Keeway+RKV+125&tbm=isch&source=univ&sa=X&ved=2ahUKEwj8sNLktIrlAhUQnFkKHa5mCwUQsAR6BAgCEAE&biw=1440&bih=757
https://www.youtube.com/watch?v=qYFtHRwSI7o
https://www.manualslib.com/manual/922664/Keeway-Rkv125.html
http://keewayparts.com/
https://www.manualslib.com/manual/1076829/Keeway-2015-Rks-125-26.html

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous the vast majority of service, parts fiche, and owners manuals on the internet are "FREE" to download and all service manuals contain wiring diagrams in the back pages. The rest usually charge a modest fee of $15 and there is a handful of obscure, rare, obsolete, and very old models that are no longer or never were available and some were never printed in English. The Indian and Philippine markets are usually in E-book format only, for these rare occasions I shall look on eBay and find the cheapest one available. Most of the manuals will cover your exact make, model, and year otherwise one will be provided that comes as close as possible to your bike and will have most of the same info that an exact manual would have. If there is no $ sign after the manual link it is free to download.
To download your manual for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.manualslib.com/manual/1176268/Keeway-Rkv200g.html
http://keewayparts.com/
https://www.manualslib.com/manual/922664/Keeway-Rkv125.html
https://bikez.com/motorcycles/keeway_rkv_200_2013.php
https://dandev.weebly.com/keeway-motorcycles.html

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous the best way to charge a battery is slowly. I like to use this analogy, would you rather be awakened from a deep sleep with gentle nudging or a violent kick in the rear.
1. Remove the battery and check for corroded or damaged terminals clean any dirt, corrosion or electrolyte that is on top of the battery as this will cause premature battery drain, inspect for cracks and swollen/expanded sides which are a sign of overheating and replacement should be seriously considered.
2. Acid plate type batteries should be checked with a hydrometer with recorded readings for each cell to be compared with after charging readings and for sulfation, the cell will appear milky, and incorrect acid level. Fill low levels with distilled water to the upper level and remove acid from overfilled cells with hydrometer until the level is at the upper mark and dispose of acid in the sink mixed with a quart/liter of water.
3. Connect a voltmeter set on the DC scale to the battery and record the reading for comparison after charging.
4. Attach a drain hose that is not pinched, kinked, or plugged to the nipple on acid plate type batteries and let the other end hang into a plastic or styrofoam cup.
5. Connect a 1-2 amp trickle charger that has an automatic charge rate reduction if possible and let charge for 24 hours.
6. After charging recheck each cell with a hydrometer a 100% fully charged cell will have a specific gravity reading of 1.270-1.280 and 1.180-1.190 has only a 25% charge battery should be load tested and considered for replacement if necessary. Reconnect your voltmeter and
any readings in the 10-volt range means you have a dead cell and the battery needs to be replaced. Readings between any 2 cells of 50 points or more indicate the battery has failed and needs to be replaced.
7. No maintenance AGM or GEL batteries need to have a voltmeter reading of 12.8-13 volts for a full 100% charge and 12.2 volts is only a 25% charge and should be load tested and replaced if necessary.
For more information about your issue and valuable "FREE" downloads that you will need for viewing and printing please click on the blue links below. Good luck and have a wonderful day.
https://www.wemoto.com/bikes/keeway/tx125sm/11
https://www.wikihow.com/Charge-a-Motorcycle-Battery
https://www.slideshare.net/AndyDexter1/keeway-tx-125-manual
http://keewayparts.com/
https://www.slideshare.net/LeslieFreeman9/keeway-tx-125-owners-manual

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=Battery+location+Keeway+Partner+110&tbm=isch&source=univ&sa=X&ved=2ahUKEwiHuOS5sIrlAhVQnlkKHcazAAsQsAR6BAgIEAE&biw=1440&bih=757
https://www.youtube.com/watch?v=upPlr91nuuA
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
http://keewayparts.com/
https://absolutelyscooters.net/pdf/CGEN_dawg_scooter_manual.pdf

Keeway... | Answered on Oct 07, 2019


Hi, Anonymous for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Keeway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=Seat+removal+Keeway+RKV+125&tbm=isch&source=univ&sa=X&ved=2ahUKEwiPjuPB4ojlAhWvwFkKHSCuBQMQsAR6BAgIEAE&biw=1440&bih=757
https://by-clips.com/rev/keeway+superlight+125+seat+removal/
https://www.manualslib.com/manual/922664/Keeway-Rkv125.html
http://keewayparts.com/
https://www.manualslib.com/manual/1076829/Keeway-2015-Rks-125-26.html

Keeway... | Answered on Oct 06, 2019

Not finding what you are looking for?
2008 Keeway F-act 150 Logo

Popular Tags

13 questions posted

Ask a Question

Usually answered in minutes!

Top Keeway Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

richard libby

Level 2 Expert

209 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

6347 Answers

Are you a Keeway Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

F-act 150 Keeway

  • F-act 150 Keeway

Most Popular Question

keeway won 39 t start

  • Motorcycles
Loading...