20 Most Recent 2006 Kymco Xciting 500 - Page 3 Questions & Answers


No pillion passenger - about 30 psi when the tyres are cold. The pressure rating should be on the tyre sidewalls. If it's in kg/cm3 or kPa just use an online conversion table to calculate psi.

Kymco... | Answered on Oct 28, 2018


Based on the number of repair question on this brand I assume they are just junk, sell it.

Kymco... | Answered on Sep 16, 2018


More than likely the ignition module is the cause or the ignition pickup.

Kymco... | Answered on Jun 13, 2018


Error code 2 is a motor fault, normally brushes. Companies charge a call out fee to send an engineer to you or you can always send it back yourself.

Kymco... | Answered on May 24, 2018


the sump plug will be on the bottom of the engine but theseold Honda copy (GY) engines don't use an oil filter they have a wire mesh gauze screen that sits on top of the sump plug bolt so make sure this comes out with the sump plug and is free from any dirt/debris. so drain oil clean the gauze screen then refit and refill your oil. check your oil level if its low or black and burnt this could be your over heating problem but I would also check to make sure the auto choke isn't sticking on. Best of luck hope this is of some help

Kymco... | Answered on Feb 08, 2018


Hello P Smurf,

Well... don't feel bad...!!
The KIMCO drawing is TRASH (in my humble opinion).

Just start the engine!
- ignition switch on (powers on CDI module)
- short B+ 12V to "S" lead (small terminal on solenoid switch = cranking motor (until it starts (or within reason... do not burn out starter)).

Really... you can short BATTERY to the starter solenoid... as long as you have the ignition on... It SHOULD RUN (if it can).

You only have the REAL two issues you need to start...
Fire & fuel... (everything else is mere confusion).

IGNORE IT ALL... until you get the engine started...!!

I've been reading schematics, circuit drawings, operational diagrams... All of it for more than my adult life... (mere seconds away from 70) amateur radio, patent holder & highly skilled professional... (into full spectrum optics)....

I pulled up the appropriate Kymco "drawing"... and while I'll say it is very pretty (colorful) it is also TOTALLY USELESS...!!
(top reference below... avoid it!).

Whom-so-ever (clown who posted it) that put it together
didn't (still doesn't) know their posterior from 75 cents
(six bits).
I can't even tell if the generator & starter are one-in-the-same
(which would be the first place you want to go...

Useable VERSION immediately below...


Quite Useless:
http://www.enmoto.com/enmotoonline/downloads/Specifications/Kymco/Schaltplaene/Quannon.pdf

I found another source... that has the COMPLETE information:
http://binatani.com/wp-content/uploads/2013/02/wiring-diagram-Kymco-Super8-125cc-engine.jpg http://binatani.com/wp-content/uploads/2013/02/wiring-diagram-Kymco-Super8-125cc-engine.jpg

If you don't have a spark tester just have a friend pull the HIGH-VOLTAGE wire loose enough to see the spark jump...

Else find the CDI Module/Coil... & replace it
(better to get a SPARK test tool...)...
I'm just saying

Comment me back... every tractor & tiller in the world has the same starter circuit
(some just have points & coils in lieu of CDI Modules).

I'll be here!!

Kymco... | Answered on Sep 28, 2017


Hey Tammy,
I hope you mean carburetor -- Motorcycle carburetors have numerous tiny passages, screws that need to be removed to access some of these tiny passages, jets that need cleaning, etc.
This is NOT a job for a shade tree mechanic.. Any good motorcycle dealership SHOULD have a mechanic that can clean and set your carburetor..regardless of make!!

Kymco... | Answered on Sep 07, 2017


How many kilometers has it done? Either one of these is the culprit; battery, spark plug, ignition coil, or CDI. CDI normally seems to go around 25000-30000kms.

Kymco... | Answered on Aug 13, 2017

Not finding what you are looking for?
2006 Kymco Xciting 500 Logo

2 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Kymco Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Muntejaya Ginting
Muntejaya Ginting

Level 3 Expert

10422 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

6495 Answers

Are you a Kymco Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Xciting 500 Kymco

  • Xciting 500 Kymco

Most Popular Question

wheres gear oil filler kymco 500

  • Motorcycles
Loading...