Question about Mitsubishi Montero Sport

1 Answer

How do I remove the rear rotors on a Mitsubishi Montero Sport 4X4 3.0

Posted by carr199 on


1 Answer

robert DIBBLE

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points


    An expert that got 10 achievements.


    An expert that got 5 achievements.


    An expert who has achieved Level 3.

  • Master
  • 448 Answers

1 first remove the tire only after blocking the car
2 remove the caliper and brakes
3 now you must remove the housing that holds the caliper
3 you will find two big bolts on the back side holding it on
4 look at the rotor to see if it is being held on by 1 or 2
4 phillups screws if so remove them
5 you are ready to remove the rotor some times they
5 will fight you so spray some w-d 40 or 556 lube on it
5 you might have to hit it on the back side to get it off
5 with a (SMALL) hammer they will brake its soft metal

hope this helps you

Posted on May 18, 2011


Add Your Answer


Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

Rear bumper removal montero sport

No, you don't have to remove any thing from the inside. Inner fender covers have to come off. Then the rest are plastic plugs..

Sep 03, 2015 | Mitsubishi Cars & Trucks

1 Answer

How do I get the front end rotors off a 2001 Mitsibishi Montero Sport?

take tire off, remove the two bolts on the back side of the brake caliper, remove brake caliper(with a coat hanger/stiff wire suspend caliper for it does not strain the brake line, remove rotor. Hope this helps Tim

Oct 15, 2010 | Mitsubishi Montero Sport Cars & Trucks

1 Answer

How do I eplace the front rotors on a 1997 Mitsubishi Montero Sport 4wd? Is there a special tool required to remove and replace the rotor and is there an adjustment needed inside the hub?

jack up the car, first break lugs, and remove tire. There are two bolts on the front back side, if it like are endeavor then I compressed the caliper piston and then I had to take apart the caliper as the old pads did not come out, those are the two bolts on each end. then put back on. Once the caliper is off the rotor will come off as it is held on by the caliper. Just be careful with the caliper once it is removed as it is a brake line, you can use a hanger for it does not pull on the line when it is off the rotor. Good Luck Tim

Oct 03, 2010 | 1997 Mitsubishi Montero Sport

1 Answer

How do you replace front rotors on mitsubishi montero sport 1999

its alot easier for you to get a service book then explain b/c you would never understand the steps which are to long to write here..

Apr 03, 2010 | 2000 Mitsubishi Montero Sport

2 Answers

How to remove front brake rotor on 1999 mitsubishi montero sport?

6290230.gif Here's an exploded view, you'll need to pop off the grease cap #6 then remove the snap ring #8 to get the hub off to get the rotor off. Hope it is of some always are.

Dec 16, 2009 | 1999 Mitsubishi Montero Sport

1 Answer

How hard to change rotors for 2002 mitsubishi sport

Not hard at all. Simply remove the brake caliper and then unbolt the hub (rotor). Pull it off and then put the replacement on.

Aug 30, 2009 | 2002 Mitsubishi Montero Sport

1 Answer

I cannot get the back rotor off

Rear wheels are more suseptible to corrosion than are the front. A corrosion ring forms between the brake rotor and the wheel hub assembly. Use a large rubber mallet or a baby sledge to hit along the top edge of the rotor in order to break the corrosion ring. Some care may be needed if you are trying to re-use the rotor after they are turned down, otherwise you can hit the rotor much harder, and they should break free.

If not, apply some heat to the seam area between the rotor and hub. It will smoke, but do not get it red hot. Remove the heat and try using the hammer once again. Be careful not to grab the hot portion of the rotor when it breaks free.

Jun 01, 2009 | 2000 Mitsubishi Montero Sport

1 Answer

Changing Front Rotors

I'm at the exact same spot.... if anyone can throw us a bone on this I would greatly appreciate it!

Apr 19, 2009 | 2003 Mitsubishi Montero Sport

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

239 people viewed this question

Ask a Question

Usually answered in minutes!

Top Mitsubishi Experts


Level 3 Expert

85239 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8984 Answers

Are you a Mitsubishi Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides