Question about Toyota Corolla

1 Answer

How can i get the heater core out of my 2006 toyota corolla

Posted by press54321 on

Ad

1 Answer

Kolawole Ayede

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Expert
  • 327 Answers

Hello, the heater core is a small heat exchanger located inside the truck, similar to the radiator at the front of the truck. Coolant is circulated from the engine through the heater core and back to the engine. The heater fan blows fresh, outside air through the heater core; the air is heated and sent on to the interior of the truck. For Toyota Pick-ups/Land Cruiser/4Runner 1989-1996 check this reference repair guide...



Heater Core - REMOVAL & INSTALLATION
(see Figure 1)

  1. Drain the cooling system.
  2. Remove the heater unit assembly. Have a lot of towels handy for the leakage of coolant that may spill into your interior.
  3. Remove the fasteners securing the core to the unit, remove the plates and clamps. Pull upwards to remove the core from the unit.
To install:
  1. Inspect the core fins for any blockage. Using compressed air, clean them.
  2. Install the core into the unit placing the plates and clamps into position. Tighten the core screws.
  3. Install the heater unit into the vehicle.
  4. Fill the cooling system.
how can i get the - 85a96e3.jpg

Thanks

Posted on Aug 12, 2010

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Toyota 2006 Corolla heater fan not working on Hi settings


heater fan motor has a relay
or vacuum or electronic motor works the internal flaps

if it is the fan motor
how to replace one
2006 Toyota Corolla Removing AC Heater Blower

Jul 04, 2016 | Toyota Cars & Trucks

1 Answer

Temperature control does not work


There is a mode door in those that controls where the air comes out and there is a blend door that controls the temp of the air. If you cant change from hot to cold then the problem is the blend door. You should be able to see it behind the glove box. The glove box door has stoppers on it that you can remove so that it drops out of the way, then you can see the plenum that holds the heater core and the fan. There is also a filter in the plenum for in cabin air filtration. Change the temp settings and see if any of the levers on the plenum move. If they move then the blend door is either loose or broken off inside the plenum.

Apr 04, 2014 | 2006 Toyota Corolla

1 Answer

Block heater installation on 2012 toyota corolla


if the cores are blocked the the only fix is to replace it with a new one . C heck first that the heater controls and the hoses are working and clean.

Apr 03, 2014 | 2012 Toyota Corolla L Sedan 1.8L 4-cyl....

1 Answer

2006 toyota corolla bad coolant flow thru heater core


Check for clogged radiator and/or faulty thermostat. Most likely a faulty thermostat.

Dec 17, 2013 | Toyota Corolla Cars & Trucks

1 Answer

2006 toyota corolla bad flow thru heater core


Disconnect both hoses at firewall and blow out.

Dec 17, 2013 | Toyota Corolla Cars & Trucks

1 Answer

Toyota 2006 Corolla wet floor mat passenger side


It sounds like your heater core is done. That is in a tight spot in behind the glove box. Get a new one for around $60.00.

Jul 22, 2012 | 2005 Toyota Corolla

1 Answer

No heat/defrost 01 corolla


Sounds like you have air trapped in the heater core when you flushed the heater core. loosen the upper most heater core hose and run the engine untill coolant seeps out. Wait until the coolant has reached running temperature.

Jan 17, 2010 | 2001 Toyota Corolla

1 Answer

Heater unit access and removal 1995 toyota corolla


theres a box behind the glovebox it should be cyclindrical in shape with three skrews in the bottom of it remove these and the heater motor will fall out

Oct 15, 2009 | 1995 Toyota Corolla

1 Answer

Where is the heater core on a 1996 toyota corolla located? Is it accessible to a novice mechanic?


the heater core is located under the dash but you have to take the whole dash out of the car and yes you can do it but your looking about 4-5hours to fix maybe more

Feb 24, 2009 | 1996 Toyota Corolla

2 Answers

Heater only blows out cold air


Check the valve that controls coolant flow to the cabin

Feb 11, 2009 | 2005 Toyota Corolla

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

462 people viewed this question

Ask a Question

Usually answered in minutes!

Top Toyota Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8984 Answers

Are you a Toyota Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...