Question about 2002 Ford Explorer

1 Answer

How do you replace the regulator for the power window on the 2002 ford explorer

Posted by vthompson268 on

Ad

1 Answer

ZJ Limited

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Ford Master
  • 17,970 Answers

Regulator - Power Windows - Front Door

  1. Remove the front door trim panel as follows:
    1. Remove the front door handle bezel.
    2. Remove the front door window/lock control switch bezel.
    3. Disconnect the window/lock control switch electrical connectors.
    4. Remove the 3 front door trim panel screws.
      CAUTION To avoid damaging the trim panel, do not pull directly outward to carry out this step.
    5. Lift the door trim panel by pulling directly upward on the armrest to disengage the panel clips.
    6. Remove the exterior mirror control switch from the front door trim panel.
  2. Remove the front door speaker.
  3. Remove the interior molding.
  4. Disconnect the door lock actuating rod at the door handle assembly:
    1. Release the door lock actuating rod clip.
    2. Position the door lock actuating rod aside.
  5. Remove the front door weather shield.
    CAUTION Make sure the holes in the glass bracket do not become enlarged during the rivet removal process. If the holes become enlarged, the new rivets may become loose, resulting in clicking noise concern.
    NOTE Some vehicles may use rivets to attach the window glass to the window regulator assembly. Use a 4.5 mm (0.1772 in) drill bit to drill out the glass-to-regulator rivets.
  6. Remove the 2 front door window glass-to-regulator bolts or rivets.
  7. Position the front door window glass as necessary to access the front door window glass-to-regulator bolts or rivets.
  8. Secure the front door glass in the full up position with tape.
  9. Disconnect the window regulator motor electrical connector.
  10. Remove the 4 window regulator assembly nuts.
  11. Remove the window regulator assembly.

    how do you replace the regulator for the power - 0b00886.jpg

    Fig. Exploded view of the front door and power window components-2005 Explorer and Mountaineer

To install:
  1. Position the window regulator assembly.
  2. Install the 4 window regulator assembly nuts. Tighten to 89 inch lbs. (10 Nm).
  3. Connect the window regulator motor electrical connector.
  4. Remove the tape securing the front door glass in the full up position.
  5. Position the front door window glass as necessary to access the front door window glass-to-regulator bolts or rivets. Install the bolt and tighten the bolts to 62 inch lbs. (7 Nm), or install new rivets.
  6. Install the front door weather shield.
  7. Connect the door lock actuating rod at the door handle assembly:
    1. Position the door lock actuating rod into proper location.
    2. Attach the door lock actuating rod clip.
  8. Install the interior molding.
  9. Install the front door speaker.
  10. Install the front door trim panel as follows:
    1. Install the exterior mirror control switch from the front door trim panel.
    2. Position the door trim panel onto the armrest to engage the panel clips.
    3. Install the 3 front door trim panel screws.
    4. Connect the window/lock control switch electrical connectors.
    5. Install the front door window/lock control switch bezel.
    6. Install the front door handle bezel.

  1. Raise the front door window glass to the full up position.
  2. Remove the interior door handle.
  3. Support the front door window glass.
  4. Disconnect the front door window regulator motor electrical connector.
  5. Remove the equalizer bracket nuts.

    how do you replace the regulator for the power - 4945f24.jpgrc="/uploads/images/4945f24.jpg" alt="4945f24.jpg" class="h_mi" />
    Fig. Remove the equalizer bracket nuts-2005 Explorer Sport-Trac
  6. Remove the front door window regulator by removing the rivets and nuts.
  7. Remove the front door window regulator motor retaining bolts andhow do you replace the regulator for the power - 52a6816.jpgove the motor.

    52a6816.jpg

    Fig. Remove the front door window regulator motor retaining bolts and then remove the motor-2005 Explorer Sport-Trac
To install:
  1. Installation is the reverse of the removal procedure.
  2. Tighten the regulator motor mounting bolts to 8 ft. lbs. (11 Nm).

Hope this help (remember rated and comment this).

Posted on Mar 25, 2010

Ad

5 Related Answers

BILL RICHARDSON

  • 508 Answers

SOURCE: 2003 explorer front passenger window regulator/motor replcement

You will first need to remove the door panel on the inside. Then you will need to remove the window glass from the track it rests in. Then you need to undo all the screws that attach the regulator inside the door. At the top of the door where the glass slides up and down remove the inner and outer window track guides. Then very carefully maneuver the regulator up and out the top of the door. Reverse the procedure to replace. It sounds easy, but you need to almost be double jointed to do this. So, have great patience while doing this task. Good luck.

Posted on Feb 26, 2009

Ad
alicantecoli

Colin Stickland

  • 22485 Answers

SOURCE: 2002 ford explorer front wheel bearing assembly

remove hub ,take retaining circlip out and knock it out with a big big hammer supporting it on an old wheel rim and a tree trunk.this job is easy to do but unless you have the right tools entrust it to a garage who will have a nice press .

Posted on Feb 02, 2009

Anonymous

  • 27 Answers

SOURCE: replace rear wheel bearing 2002 ford explorer 4x4

you must remove brakes, then remove axle nut, then remove upper control arm and finally tie rod stabilizer, remove axle from car then bearing can be accessed. this is a difficult job that requires special tools so be careful

Posted on Aug 15, 2009

providencefe

  • 1 Answer

SOURCE: I have a 2002 ford explorer that the passenger

I have the identical problem. I am suspect of the drivers side master switch or the wiring harness but not sure any help would be appreciated.

Posted on Dec 18, 2009

ZJLimited

ZJ Limited

  • 17970 Answers

SOURCE: 2002 explorer power window fuse where

In the battery Junction Box check fuse # 6-60AMP will feed Central Junction Box (under driver side), the inline circuit breaker #47-30AMP, through the Accessory Delay Relay, powered by fuse #17-15AMP to the Window Control Circuit. Check the fuses, and for 12v at the points. Then check for 12v at the driver side door switch pannel.

Also uou should check the plug into the main window button console in your drivers door. The little piece of plastic around the door handle pops out when pushed towards the front of the vehicle. This gives you access to the buttons and harnesses.

Good luck (remember rated this help).

Posted on Mar 09, 2010

Testimonial: "good but windows only opens when drivers door open"

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

4 Answers

Windows stopped working all of a sudden. first rear passenger side then the rest. how can I fix this?


Check fuses and wire harness to door for correct connection. Check on the fuse box cover as it will show a relay that can also be faulty.

Jul 16, 2014 | 2002 Ford Explorer

2 Answers

How do i change the drivers side window motor an an 05 kia sedona


You have to remove the inner door panel to
access the window regulator

You remove the regulator & then the motor from it

You Tube Video will provide a visual of several
similar window motor replacement jobs

Go there-- enter your car,question ,details,etc--- then move
around the site to watch various things

Dec 09, 2012 | 2005 Kia Sedona

1 Answer

Thank yo for the schematic Ernesto. It says Nissan 1996, so is the 2008 still using the same schematic?


It can be issue with motor itself.If its not going up,then how its working down.But still it feels like weak window motor or is issue with power window switch.Get the voltage tested at switch and motor.Also try another working window motor at not working window side.
==========For more troubleshooting i suggest go through the help links mentioned below:-----
Its complete details with troubleshooting steps:------
-------------------
Car windows will go down but come right back up
http://schematicsdiagram.blogspot.com/2011/06/car-windows-will-go-down-but-come-right.html
---------------

Power windows will not go up and relay clicks when switch is pressed?

http://technoanswers.blogspot.com/2012/01/power-windows-will-not-go-up-and-relay.html

-------------

Electric Window Motor REMOVAL and INSTALLATION on ford vehicles?
http://schematicsdiagram.blogspot.com/2011/06/electric-window-motor-removal-and.html
------------
Driver side power window wont go up on ford expedition?
http://howtobyme.blogspot.com/2011/10/driver-side-power-window-wont-go-up-on.html
-------------
How to replace window motor and regulator on jaguar S-Type?
http://howtobyme.blogspot.com/2011/09/how-to-replace-window-motor-and.html
-----------
How to remove window motor and regulator on Volkswagen Car?
http://howtobyme.blogspot.com/2011/09/how-to-remove-window-motor-and.html
-----------------
power locks, power window and power mirror on the passenger side not working on Ford Windstar
http://howtobyme.blogspot.com/2011/09/power-locks-power-window-and-power.html
-------------
All power windows not working on 2003 Cadillac CTS?
http://howtobyme.blogspot.com/2011/09/all-power-windows-not-working-on-2003.html
-----------------
How to remove the door panel to install a new window regulator on Cadillac Deville?
http://howtobyme.blogspot.com/2011/08/how-to-remove-door-panel-to-install-new.html

--------------How to Remove Electric Window Motor on Acura Integra?
http://repairhelpcenter.blogspot.com/2011/11/how-to-remove-electric-window-motor-on.html
--------------
How to replace power window motor in car?
http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-power-window-motor-in.html
--------------
HOW TO REPLACE A POWER WINDOW SWITCH
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-window-switch.html
-----------
How to Replace a Window Motor
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-motor.html
--------------
HOW TO REPLACE A WINDOW REGULATOR WITH MOTOR
http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-window-regulator-with.html
-------------
HOW TO REPLACE WINDOW RUN CHANNEL SEALS
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-run-channel-seals.html
------------
HOW TO REPLACE A WINDOW REGULATOR
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-regulator.html
--------------
How to replace power window regulator for 2006 Dodge Dakot
http://schematicsdiagram.blogspot.com/
------------
How to remove passenger side power window motor on Dodge Grand Caravan?
http://schematicsdiagram.blogspot.com/2011/09/how-to-remove-passenger-side-power.html
------------
How to replace automatic window motor unit for the front passenger side on 2001 jeep grand cherokee
Laredo ?
http://schematicsdiagram.blogspot.com/2011/09/how-to-replace-automatic-window-motor.html

------------

how to replace passenger side power window motor on 2001 Dodge van
http://technoanswers.blogspot
--------------
All power windows not working on mercury sable?
http://technoanswers.blogspot.com/2011/09/all-power-windows-not-working-on.html
---------------
How to replace electric window regulator for mitsubishi 380 ?
http://technoanswers.blogspot.com/2011/09/how-to-replace-electric-window_05.html
-------------
how to remove window motor on driver side door panel on 1994 Oldsmobile Cutlass Ciera
http://technoanswers.blogspot.com/2011/08/how-to-remove-window-motor-on-driver.html
-----------------
driver side window problem on Mercury Sable
http://technoanswers.blogspot.com/2011/06/driver-side-window-problem-on-mercury.html
---------------
How to remove door panel, door window motor and regulator on 1991 cavalier?
http://technoanswers.blogspot.com/2011/05/how-to-remove-door-panel-door-window.html
---------------
how to replace the power window switch on 2005 BMW 325i?
http://technoanswers.blogspot.com/2011/03/how-to-replace-power-window-switch-on.html
--------------
How to replace window switch on bmw?
http://technoanswers.blogspot.com/2011/03/how-to-replace-window-switch-on-bmw.html
---------------
ford explorer window motor, regulator and door panel removal?
http://technoanswers.blogspot.com/2011/02/ford-explorer-window-motor-regulator.html
-----------------
How to Replace a Window Switch on a 2002 Ford Explorer ?
http://technoanswers.blogspot.com/2011/02/how-to-replace-window-switch-on-2002.html

-------------

Ford F-150 Power Windows Not Working?
http://schematicsdiagram.blogspot.com/2011/12/ford-f-150-power-windows-not-working.html

--------------

Power windows works intermittently?

http://schematicsdiagram.blogspot.com/2011/12/power-windows-works-intermittently.html

-------------------

Pontiac grand am power window not working?

http://repairhelpcenter.blogspot.com/2012/01/pontiac-grand-am-power-window-not.html

-------------

Auto open close feature not working for Toyota Avalon?

http://technoanswers.blogspot.com/2012/01/auto-open-close-feature-not-working-for.html

--------------

Lexus ES300 Power window out of time?

http://repairhelpcenter.blogspot.com/2012/01/lexus-es300-power-window-out-of-time.html

--------------------

Rear power windows not working on Ford Mustang?

http://technoanswers.blogspot.com/2012/01/rear-power-windows-not-working-on-ford.html

-------------

All power windows not working on Ford Explorer?

http://technoanswers.blogspot.com/2012/01/all-power-windows-not-working-on-ford.html

-------------

2003 Chevy impala power windows not working?

http://technoanswers.blogspot.in/2012/02/2003-chevy-impala-power-windows-not.html

------------

Diagnosis & Testing Power Windows?

http://repairhelpcenter.blogspot.in/2012/02/diagnosis-testing-power-windows.html

-------------

All Power Windows Not Working

http://whatisbyme.blogspot.in/2012/07/all-power-windows-not-working.html

---------------

1977 Chevrolet Corvette Power Windows Not Working?

http://technoanswers.blogspot.in/2012/04/1977-chevrolet-corvette-power-windows.html
---------------
These details will help.Thanks.

Nov 27, 2012 | 2007 Nissan Frontier SE Crew Cab

2 Answers

How do i replace the power window door regulator?


auto zone can print for you the step by step instructions, they have alldata

Jan 21, 2010 | 2002 Ford Explorer

1 Answer

How do I get to the power window motor after I get the panels off my 2002 ford explorer? There appears to be a loose cable heading into the motor housing. Power widnow goes down but not up


You should see three star screws, Remove these and the motor should come off. Check the plastic plugs in the motor and replace with plugs or ball bearings, pack with wheel bearing grease. You may have a defective window regulator. To remove. using a /14 inch punch punch out the rivits and replace with 1/4 nuts and bolts. Drill out the aluminum inserts using 1/4 drill. When replacing the regulator do not over tighten the bolts holding in the glass.

Nov 27, 2009 | 2002 Ford Explorer

1 Answer

2002 Ford Explorer, rear driver side door


Wil it work at the door switch or not at either switch? If not make sure you have power and ground to the motor in up and down positions. if so suspect the motor.Also the cable operated regulators break and will not let the window go up or down

Jul 30, 2009 | 2002 Ford Explorer

1 Answer

I have a 2002 ford explorer that the passenger side front window will go down but not up. I replaced the regulator and motor and am still not getting 12v to the up side of the motor.I tried a new switch...


I have the identical problem. I am suspect of the drivers side master switch or the wiring harness but not sure any help would be appreciated.

Jun 28, 2009 | 2002 Ford Explorer

2 Answers

Rear window regulator broke


The regulator is attatched to the glass using the rivets through plastic disks. You need to drill them out before the glass can be removed.Save the plastic parts for reassembly.Good Luck

Aug 25, 2008 | 2002 Ford Explorer

Not finding what you are looking for?
2002 Ford Explorer Logo

2,557 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Thomas Perkins
Thomas Perkins

Level 3 Expert

14850 Answers

Mike

Level 3 Expert

4369 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...