Question about Ford Cars & Trucks

1 Answer

2002 ford f 350 7.3l diesel want to know the location of fusible link

Posted by John Baker on


1 Answer

Mike Duffy

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points


    An expert that got 20 achievements.


    An expert that got 10 achievements.


    An expert that got 5 achievements.

  • Ford Master
  • 884 Answers

It looks like one battery has 2 cables coming off the positive post one wire goes to the other battery while the other goes to a junction block there are 2 fuse links coming out of that junction box. I hope this helps. Take care.

Posted on Jun 30, 2020


Add Your Answer

Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

Where is the fuse for alternator on 2002 ford explorer?

The alternator fuses are called fusible links and are located on the side of the under hood junction box.

Sep 27, 2017 | Ford Cars & Trucks

1 Answer

What is the alternator fuse number for 2002 Buick rendezvous

It's a fusible link , do you know what it is ? Here is a youtube video showing location of fusible link . On the video he talks at the vehicle starting , alternator gets power the same way. How to Replace Fusible Link Car won Start If you pull on it an the insulation stretches it's brunt inside .
Fusible Link
In line to the generator, near the positive battery cable
Did you check for B+ voltage at the heavier gage wire on the back of the alternator ? The turn on signal comes from the PCM - engine computer .

Oct 08, 2016 | 2002 Buick Rendezvous

1 Answer

Where is the in line fuseable link located on a 94 ford ranger 2.3 motor

    Alternator fuse link repaired my way. - YouTube

    ? 2:10
    Dec 24, 2013 - Uploaded by Potskie
    I had the exact same situation with my ranger. ... I found thefuse links for the charge or alt output but not the one I ..... In line fuse, battery, or alternator? ... Of Key-Off Battery Drain (Parasitic Draw) - Duration: 18:14. by Motor Age.Missing: 2.3

    Fusible links and inline fuses? - Ford Truck Enthusiasts Forums
    Sep 17, 2009 - Location: Kuna ID ... The PO had replaced one of the fusible links with an inline 30amp fuse. .... 81-F-150-Explorer is a splendid one to behold .... to charge the battery goes through that link when needed, and/or the battery to the other components when the engine is off. ... 91 ford ranger 2.3 daily driver 1994 Ford Ranger XLT 2.3L man. trans. - Ford Truck ...
    Jul 6, 2014
    86' Ranger cutting out!!! Fuel ? - Ford Truck Enthusiasts Forums
    May 10, 2012
    90' 302 fusible link for fuel? - Ford Truck Enthusiasts Forums
    Nov 2, 2010
    1988 ranger headlights won't work??? help - Ford Truck ...
    May 17, 2009
    More results from
    Missing: 94 images for Where is the in line fusible link located on a ...

Dec 30, 2015 | Ford Cars & Trucks

1 Answer

How to change fusible link to alternator on 2002 ford tausus

IF your car even has a fusible link it will be on the positive battery cable which goes to the alternator. Make sure you disconnect the negative cable from the battery also when you go to remove the positive cable. This is also a dealer item so you'll have to go to FORD to buy the new cables which they usually only sell as a set. Be prepared to pay $75 - $100 for the cables.

If the fusible link is blown, I'd suggest testing the Alternator to make sure it isn't over charging or spiking, that fusible link should be good for about 175 amps so it really shouldn't blow unless there's another problem like a faulty regulator.

Feb 19, 2015 | 2002 Ford Taurus

1 Answer

Where is the fusible link on my 2002 ford explorer located?

The fuseable link for the starter is attached to the starter or the solenoid, and the fuel pump is in the gas tank in the back of the truck.

Dec 19, 2012 | 2002 Ford Explorer

1 Answer

Have f250 7.3 diesel. Have batteries replaced and alternator checked. Having problem with it eratically showing charging then lights will go dim. Then it will show it charging again. Seems to be worse when...

Check the wiring on the Alternator leading back to the Firewall. On some models there is a split in the wiring and one side has a fusible link on it. Sometimes the wiring rests on metal parts and wears through from vibration. Check for this and tape the wires to avoid the rubbing.

Ford in the past has put fusible links near the Batteries and when the Batteries are removed, the wires are brittle and possibly corroded. Its just a matter of failing a little earlier from being disturbed than from corroding through. Check all of your connections.

Make sure your Batteries are fully charged. They should be at 13.2 to 13.4 Volts. I know of an increasing amount of Ford products having charging problems immediately after a Battery switch.
Alternators have stopped charging while the vehicles are on the E-way. The charging systems are being disconnected by something built into the vehicle. I suspect the Anti-theft or Battery-saver systems.

I hope my solution helps you.

Feb 04, 2011 | 2002 Ford F250 Super Duty SuperCab

1 Answer

Where are the fusible links located on an f350 diesel

They will be on the battery side connection,of the starter solenoid switch,on the firewall.

Jul 09, 2010 | 2003 Ford F350 Super Duty DRW SuperCab

1 Answer

2001 F250 Diesel. Truck cranks but wont start. Replaced fuel filter and still wont start

Look for a fusible link that has gone bad. If you are not familiar with this please read some before you explore. The 'fusible link' from a distance looks like any other wire but on close exam it is rubbery and some what stretchy as well. There are several wires coming from the solenoid so be careful and pull gently on each one until you find the one that feels stretchy. Try and find an obvious 'burn' area and or a total split in the line. I hope this helps.
Again be sure to read some on fusible links.

Here is a generic pic of some fusible links - so you know they look just like a regular wire but their sheath is different as in more stretchy :

Best of it.

Jan 17, 2010 | 2001 Ford F250 Super Duty Super Cab

1 Answer

Where abe the fusible links in a 2002 f350

Some are located under the hod to the driver side fender under plastic rectangular.
Some are under steering wheel column behind plastic cover that has 4 plastic fasteners.

Jan 03, 2010 | 2002 Ford F250 Super Duty SuperCab

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

24 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts


Level 3 Expert

85239 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

gerry bissi

Level 3 Expert

4388 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides