Question about 1999 Kia Sportage

Open Question

1999 Kia Sportage power steering pump O ring what size

Posted by Mike Wallace on

Ad

5 Related Answers

rrguyer

Robin Guyer

  • 1 Answer

SOURCE: No Fuel 2001 Kia Sportage

dosee a KIA Sportage have fule pump reset and if so were is it ?

Posted on Nov 10, 2008

Ad

Anonymous

  • 25 Answers

SOURCE: A 1999 Kia Sportage. Heater core leaking.

tie both hoses together

Posted on Jun 25, 2009

Ad
c17hydro

Greg Bernett

  • 2989 Answers

SOURCE: 1999 kia sportage timing marks

dfd3ea1.gif Crankshaft match marks


Align marks on timing belt pulley and pump body.

Camshaft pulley alignment marks
9f1c7ef.gif

  1. Align marks on camshaft pulleys with alignment marks on seal plate.
  2. Install timing belt. NOTE: No looseness should exist on the tension side and at the camshaft pulleys.
  3. Loosen tensioner lock bolt.
  4. Turn crankshaft 2 revolutions in direction of rotation and check that timing marks are still in alignment.
  5. Tighten timing belt tension lock bolt to 27-38 ft lb (32-52 Nm).
  6. Apply a force of 22 lbs to timing belt between camshaft sprockets.
  7. Belt deflection should measure 0.30-0.33 in (7.5-8.5 mm)
  8. NOTE: Replace tensioner spring if timing belt deflection is excessive.
Timing Belt Installation


eb770f2.gif
  1. Install lower timing belt cover.
  2. Install upper timing belt cover.
  3. Install power steering drive belt and adjust belt tension.
  4. Install fan pulley.
  5. Install generator drive belt and adjust belt tension.
  6. Install A/C drive belt and adjust belt tension.
  7. Install splash guard.
  8. Install fan and fan shroud.
  9. Install 4 fan bolts. Tighten to 24 ft lb (33 Nm).
  10. Install fan shroud mounting bolts.
  11. Install fresh air duct.
  12. Connect hose to resonance chamber.
  13. Connect battery negative cable.

Posted on Jul 26, 2009

c17hydro

Greg Bernett

  • 2989 Answers

SOURCE: the power steering belt is broke on a kia sportage

I would replace it yourself....very simple to do! The belt is $13.00 Power Steering Pump Belt

  1. Disconnect the negative battery cable.
  2. Remove the A/C and alternator drive belts for access.
  3. Loosen mounting lock bolt (A) and mounting bolt (B).
  4. With tension released removed the belt.
To install:
  1. Properly route drive belt around the pulleys.
  2. Carefully pry on the power steering pump using a suitable lever. Adjust belt tension is 22 ft. lbs. (30 Nm) when measured at deflection point shown.
  3. Retighten bolts (A) and (B) to 31 ft. lbs. (42 Nm).
  4. Reinstall the A/C and alternator drive belts.
  5. Connect the negative battery cable.
a30e7b7.jpg

Posted on Oct 10, 2009

kirkx

Kirk Augustin

  • 2019 Answers

SOURCE: kia sportage will not start no power to the fuel

The fuel pump is always controlled by a relay. The relay is controlled by the ignition switch and some sort of safety cut out. But once you locate the relay, you can look at the diagram on its side, and figure out how to temporarily jumper the pump to on. But you will still have to figure out if the relay is bad, there is no ignition voltage, or if there is an inertial accident sensor that needs to be reset.

Posted on Apr 04, 2010

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Intermitting power steering


In relation to these problem there is solved help link,i suggest you to go click the link below and troubleshoot the problem:-----




POWER STEERING TROUBLESHOOTING, STEERING SQUEAKS, POWER STEERING FLUID LEAKS, FAULTY POWER STEERING PUMP, POWER STEERING NOT WORKING, POWER STEERING BELT,


http://alltypesofpartsreplacing.blogspot.com/2012/12/power-steering-troubleshooting-steering.html

---------

These will help.

Thanks.

Dec 12, 2012 | 2008 Kia Sportage 2.0

1 Answer

Where is the fuse box in a 1999 kia sportage?


The fuse box is located under the dash near the steering column, to the left I think.
____________
FGTech Galletto 2-Master EOBD2

Sep 23, 2012 | 1999 Kia Sportage

2 Answers

Fuel consumption of 1999 kia sportage


The revised figures for the 1985 - 2007 mpg estimates to make them comparable to the new 2008 (and later) mpg estimates are:

City 17
Highway 21
Combined 19

Hope this helps. Happy motoring

Wheelspin

Jan 14, 2011 | 1999 Kia Sportage

1 Answer

My kia sportage 1999 has a hard stearing wheel and will make a purring sound when veered to the right.. what do you think is the problem. if a component/part needs replacement do you know the...


mcdevito75 here, Sounds as though you have a problem in the rack & pinion steering, that is where the power valuse to direct and assist with power steering are located, that is a shop repair item only. If I;m right figure $175.00 ---- $250.00

Jun 16, 2010 | 1999 Kia Sportage

1 Answer

My KIA Sportage has lots of loose play in the steering and tends to wander at high speed. Has been checked by mechanic and re-aligned. Mechanic says I've been spoilt by rack and pinion steering and just...


FIND ANOTHER MECHANIC!!!!!!!! No REAL mechanic would tell you that. Your steering should have NO play in it. (Over time a little) Have your steering box checked

Apr 12, 2010 | 1999 Kia Sportage

2 Answers

My granddaughter's 1999 Sportage steering makes quite a bit of noise when she turns the wheel...hard left at low speeds...especially when she has been parked.


Check your Power steering fluid, lines, and pump. It sounds like your pump is going out, however, check the lines before hand to make sure you haven't just lost the pressure.

Mar 19, 2010 | 1999 Kia Sportage

2 Answers

The power steering belt is broke on a kia sportage 2001 is it very expensive to fix..


I would replace it yourself....very simple to do! The belt is $13.00 Power Steering Pump Belt
  1. Disconnect the negative battery cable.
  2. Remove the A/C and alternator drive belts for access.
  3. Loosen mounting lock bolt (A) and mounting bolt (B).
  4. With tension released removed the belt.
To install:
  1. Properly route drive belt around the pulleys.
  2. Carefully pry on the power steering pump using a suitable lever. Adjust belt tension is 22 ft. lbs. (30 Nm) when measured at deflection point shown.
  3. Retighten bolts (A) and (B) to 31 ft. lbs. (42 Nm).
  4. Reinstall the A/C and alternator drive belts.
  5. Connect the negative battery cable.
a30e7b7.jpg

Oct 10, 2009 | 2000 Kia Sportage

1 Answer

Need to replace the water pump on a 1999 Kia Sportage not exactly sure where the pump is located


It's at the front of the engine, RH-side.
Look in http://www.kiatechinfo.com after registering. You can find the manual there.

Jun 25, 2009 | 1999 Kia Sportage

1 Answer

Power steering


you will have to do this from under the vehicle first lossen the pump bolts then use a pry bar to push the pump out to put tension on the belt then tighten the pump bolts (be careful not to get the pump crooked)

Jul 10, 2008 | 1999 Kia Sportage

Not finding what you are looking for?
1999 Kia Sportage Logo

Related Topics:

59 people viewed this question

Ask a Question

Usually answered in minutes!

Top Kia Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8984 Answers

Brad Brown

Level 3 Expert

18520 Answers

Are you a Kia Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...