Question about 1995 Isuzu Trooper

1 Answer

How to change gearbox oil - 1995 Isuzu Trooper

Posted by Anonymous on

Ad

1 Answer

_-__-___-_

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Isuzu Master
  • 20,706 Answers

Gear + BOX
so is the transfer case, box. or the 5 speed stick box or?
what?
we drain it then fill it, to the mark.
on all gear boxes.
if A/T we RTM read the operators guide. for how to do it right,
most dont and wreck the tranny. the #1 reason they removed the filler.
when posting car issues, stated what it is.
like this.
95 Trooper, 4wd M/T , i want to change the 5speed box lube.
what do i need to do that.?
ill spin the wheel of fate, and land on 5speed box.
and answer for TR5 and NV1500 boxes.

For all transmissions except for the Borg-Warner T5R, replace the transmission fluid at the first 15,000 miles (24,000 km) and then every 30,000 miles (48,000 km) thereafter. The Borg-Warner T5R transmission does not require periodic changing of the transmission fluid. (they lie)

  1. Raise the vehicle and support safely on jack-stands. Place a fluid catch pan under the transmission drain plug.
  2. Remove the fill plug from the side of the transmission, then remove the drain plug. Be cautious when removing the drain plug: the transmission fluid can be very hot. Allow the transmission fluid to drain into the pan.
  3. Install the drain plug and tighten to 20 ft. lbs. (27 Nm) for all models except the 1996 Hombre, which requires 27 ft. lbs. (37 Nm).
  4. Refer to the manual transmission fluid recommendations for the proper viscosity of engine oil, or type of transmission fluid to be used for the T5R and NV1500 transmissions. Fill the transmission by pouring the new fluid through the fill plug hole in the side of the transmission. Fill until the fluid starts to dribble out of the filler hole. Install the fill plug to 17 ft. lbs. (23 Nm), then lower the vehicle.
so next you ask, what fluid
sure.
Use engine oil for all of the manual transmissions, except for the Borg-Warner T5R and the NV1500 (1996 Hombre). Make sure to use engine oil of the correct viscosity for these transmissions, as follows:
  • Except 1992-96 Rodeo and Trooper, high temperature-SAE 40
  • Except 1992-96 Rodeo and Trooper, normal temperature-SAE 5W-30SF
  • 1992-96 Rodeo and Trooper, high temperature-SAE 15W-40, 20W-40 or 20W-50
  • 1992-96 Rodeo and Trooper, normal temperature-SAE 5W-30
he Borg-Warner (B-W) T5R is found on Rodeo models with the V6 engine. The 1991-93 B-W T5R uses DEXRON-II automatic transmission fluid, whereas the 1994-96 B-W transmission uses DEXRON- III automatic transmission fluid.

use the highest Dexron number, on the shelf, mark III is not made today.

Posted on Aug 10, 2014

Ad

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Does a 2011 caddyTDi250 1.6 ltr need the gearbox oil changed when the vehicle has its regular service?its 5 speed manual gearbox,and is there a filter to be changed?


No but check with the dealer or your service/owner manual for the manufacturer recommended gearbox oil change periods.
There is no filter on the manual gearbox .
Whatever the manufacturer recommended period is for a gearbox oil change, change the gearbox oil twice as frequently as recommended to maintain it in good condition. If, for example, a change every 50000 miles is stipulated then do it every 25000 or so.

Nov 02, 2015 | Cars & Trucks

1 Answer

Gear shifting problems in Honda Prelude with Automatic transmission only when gearbox is cold


While just change ATF oil or CVT oil in transmission & old filter too. your car problem will be solve....

Nov 21, 2013 | 1998 Honda Prelude

1 Answer

2010 Touran 1.4 how often change the oil for the gearbox and what type and quantity of oil


VW 1.4i with manual gearbox 5 speed transmission:
1. Oil type: VW G50 & G51, full synthetic oil SAE 75 W 90

2. Gearbox refill = 1,9 litres
3. Filling plug location: Side of transmission

Nov 07, 2012 | Volkswagen Cars & Trucks

1 Answer

Golf mk2 gearbox oil change


Look for 2 plugs one lower to drain oil... one midway to fill.

Sep 05, 2012 | Cars & Trucks

1 Answer

How do I put gearbox fluid in ? Where is the level glass? I have a 1997 mitsubishi magna


Gearboxes usually have no oil dipstick / looking glass. On the side of the gearbox there's a bolt with (brass) washer. This is where the gearbox oil goes. To check the level is to stick one finger in downwards, when there's no oil at this level its usually too low.

On the bottom of the gearbox there's a similar bolt with washer to drain the old oil. The bolt can be magnetic - and can look a bit like a mushroom. Tiny particles from the gears stick on there - this is normal. Large bits of metal can be a cause for concern.

Always use the specified gearbox oil - wrong oil makes changing gears hard.

Jul 05, 2011 | Mitsubishi Galant Cars & Trucks

1 Answer

Drain and refil gearbox oil on toyota conquest 1990


Here is a link to a step by step instructions on how to change the gearbox oil. If you don't want to change it, go to the refill portion of the instructions.
Fill it until the gear oil starts to run out of the fill hole.

http://toyotaownersclub.com/forums/index.php?showtopic=101692

Oct 05, 2009 | Toyota Corolla Cars & Trucks

1 Answer

Gearbox oil


how do you top up the gearbox oil on a kia sedona 2.9diesel on a 03 plate and i have friction noises when driving changing gears.

Apr 08, 2009 | 2003 Kia Sedona

1 Answer

Oil Change queries SUBARU IMPREZA RS 2.5 2005 MODEL non turbo


I am confused - I have a simple query and logged on to your site as you offered free advice! Do you not offer the service as described on your website. I definitely don't need a team of experts to answer my very simple question.

Regards

Vic Fenn

Jan 25, 2009 | 2005 Subaru Impreza

1 Answer

Transmission


Well, I'm not sure. Try changing the gearbox oil and try again. I saw on the other postings that most Audi gearbox problems pointing to a gearbox swap can be solved through oil change. I just had mine changed and it has reduced sluggishness and shuddering at low temperatures (from cool engine). It's a special gearbox oil you need to get from Audi, by the way.

Jun 14, 2008 | 2001 Audi A6

Not finding what you are looking for?
1995 Isuzu Trooper Logo

394 people viewed this question

Ask a Question

Usually answered in minutes!

Top Isuzu Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Thomas Perkins
Thomas Perkins

Level 3 Expert

14850 Answers

Are you an Isuzu Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...