Question about 1990 Ford Thunderbird

1 Answer

Location of cooling fan fuse

What size fuse is used for cooling fan

Posted by lolaree11571 on

Ad

1 Answer

dttech

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Master
  • 4,803 Answers

The radiator cooling fan on your 1990 Ford Thunderbird Super-Coupe is supplied power via the BLACK, 18 Gauge, fusible link near the battery.
If your cooling fan is not getting any power to operate (and you are certain that the fan motor is in good working order) the most likely cause of you fan not working is a failure in the Constant Control Relay Module (CCRM), which is mounted to the upper radiator support.

I have replaced many of these because the circuit boards inside them like to burn.

HERE IS HOW TO TEST IT:

Check for power at the CCRM on pins 3 and 4 BLACK/ORANGE wires. If there is power there, the fusible link is good. If there is no power at these connectors, repair the fusible link or the circuit between the fusible link and the CCRM.

Then, the Powertrain Control Module (PCM) turns the fan on by grounding the fan relays inside the CCRM at Pins 14 and 17.

So if you have power on the BLACK ORANGE wires, You should be able to manually turn the fan on by grounding Pin 14 (TAN/ORANGE) for fan LOW speed and Pin 17 (GREEN/PURPLE) for fan HIGH speed.

If grounding these wires does not get the power to come on at the fan motor, then the CCRM needs to be replaced.

If this makes the power come on (at the motor connector) but the motor will not run, then you need to replace the fan motor.

If grounding these wires makes the motor run, you have a problem with the engine coolant temperature sensor or the PCM.

Posted on Apr 23, 2012

Ad

2 Related Answers

for_df_250

  • 2 Answers

SOURCE: need to find circuit/relay location for cooling fan. fuse is good, fan motor tested fine. need wiring schematic

where is the cooling fan relay located on a 92 taurus

Posted on Dec 15, 2009

Ad

Anonymous

  • 2 Answers

SOURCE: My 2000 lincoln ls cooling fan will not turn on.

Radiator cooling fan is not electric, it is driven by a silly hydraulic pump which is located low on the passenger side of the engine above the alternator. All 2000-2002 LS's have this system. Most likely either the motor or pump has failed.

Posted on Aug 17, 2010

Testimonial: "good advice"

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Hi, I have a 2013 KIA FORTE the fan stopped working and overheating. How do I check the fan and is there a fuse to check and if so where? any other ideas are more the welcome thanx


Cooling fan relay could be bad . cooling fan fuse - C/FAN 40 amp. under hood fuse box , as are C/FAN lo & C/FAN HI relay's . Video's on youtube on testing relay's an power an control circuit's at the relay base .socket etc... Do you know what a wiring diagram is ? Free wiring diagrams here http://www.bbbind.com/free-tsb Enter vehicle info. Year , make , model an engine size. Under system click on engine , then under subsystem click on cooling system . Click the search button then the blue link . Looking at the diagram i see the ECM controls the cooling fans relay's . You mite want to take your vehicle to a qualified repair shop.

Aug 19, 2018 | Kia Cars & Trucks

1 Answer

Fuse box on 2000oldsmobile aurora what is#36 start 1 mini relay


Start 1 relay is for starter control . Three relays for cooling fans , hooked in series parallel circuit. Free wiring diagrams here http://www.bbbind.com/free-tsb Enter vehicle info. year , make , model an engine size. Under system click on engine , then under subsystem click on cooling fans , Click the search button then the blue link .
Relay Driven Dual Cooling Fan Diagnostics

Apr 05, 2018 | 2000 Oldsmobile Aurora

1 Answer

The primary radiator fan does not come on.


Check Maxi fuse #3 60 amp in the under hood electrical center #1 .This is power for the #1 cooling fan . Also check the #1 fan control relay in the same under hood electrical center .
These vehicles use 2 360 mm (14.2 in) cooling fans to aid air flow through the radiator. Electric motors drive the cooling fans. These motors are attached to the radiator. Motor size varies with each engine option.
A coolant temperature switch activates the fan motors. This switch regulates voltage to the cooling fan relay. This switch operates the fan whenever the engine coolant temperature exceeds 110°C (230°F). For location and diagnosis, refer to Electrical Diagnosis. A transducer can also activate the circuit, depending on the A/C compressor head pressure going to the condenser.
The engine cooling fan relays provide the high current required for the cooling fan motors using a low current signal coming from the Powertrain Control Module (PCM). This signal is a function of various inputs.
Refer to Electrical Diagnosis for further information and diagnosis of the cooling fan relay.
Electrical Center #1, Underhood (U/H)
RH side of the engine compartment, forward of the strut tower

Jun 08, 2016 | 1996 Pontiac Grand Prix

1 Answer

My fuse to my cooling fan keep blowing out


Maybe a problem with cooling fan or wiring circuit? You may even have to check your fuse box itself. I don't know the year--make--model--engine size?

You could remove the fan, then use jumper wires off the battery with same size inline fuse, if it still blows, what else could it be but the fan?

Jul 20, 2015 | Cars & Trucks

1 Answer

Relay for cooling fan on 2009 suzuki forenza


USA answers.. all.
which of the 6 engine you have?
we cant guess them. you must say
open hood, look up , see that EPA sticker there,
the engine type and size, is there.
cooling systems are different by ENGINE.

most fan relays are in the fuse boxes. did you look in all fuse boxes
yet>? if not, do so , its marked, read the markings.

Jun 23, 2014 | 2005 Suzuki Forenza

1 Answer

I don't have car manual and I have a missing fuse on the fuse block under the hood. It is for the cooling fan and I don't know what size goes in there.


Contact a Local Parts store give them your year make and model ask about cooling fan relay fuse Will be a 12Volt for sure

May 09, 2011 | Toyota Corolla Cars & Trucks

3 Answers

I want to put after market flexlite radiator and fans in my 1989 iroc. 350 can I bypass factory wiring ? And use after market?


You could, but if you do that, no matter what, always add a fused circuit. All the circuit would have to be is a thermostat, a connection to the battery, the fan, and a fuse, but always have the fuse.

Jan 28, 2011 | 1989 Chevrolet Camaro

1 Answer

2004 mitsubishi outlander cooling fans not operating


TAKE A PEEK UNDER THE HOOD IN THE FUSE PANEL FOR THE FUSE AND RELAY FOR THE COOLING FAN. IF THE FUSE IS BLOWN THEN REPLACE IT. IF YOU SUSPECT THE RELAY TO BE BAD THEN TEST IT BY SWAPPING THE FAN RELAY WITH ANOTHER ONE WITH THE SAME PINS ON THE BOTTOM. MAKE SURE IT IS THE SAME SIZE AS WELL. HOPE THIS HELPS.. PLEASE KEEP ME POSTED. THANKS FOR AN HONEST RATING AND FOR USING FIX-YA. GOOD LUCK

May 16, 2009 | 2004 Mitsubishi Outlander

Not finding what you are looking for?
1990 Ford Thunderbird Logo

999 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8984 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...