2003 Suzuki Grand Vitara - Answered Questions & Fixed issues

check whether you do have a problem with your cam or crank sensor. Or the fuel pump whether when it gets warm stop working,(loosing the pressure ) These things you do need a specialist to check the sensors and the fuel pump.

What about...? Good luck Mai

most are a simple "V" shaped slide in so gently hit the underside of the bracket upwards and it will slide up and out of the section stuck on the glass

Do the procedure below, do it exactly as discribed or it will not work.
Here is the common cause of surges, stalls at stops, slow idle speed, erratic idle speed, rough idle and engine hesitation (and other problems), it is in most cases the idle speed control air-bypass valve and or throttle valve and upper intake, these area's get full of gunk and combustion residue over the miles and cause idle issues (stalls, low idle) like yours, Get a can of intake cleaner from any local parts store, not carb spray, intake cleaner, it is made by a company called CRC, remove the air intake hose to the engine, hold the idle high so the engine won't stall, then spray the can of cleaner into the intake while keeping the engine running, use at least 1/2 the can, shut down the engine and disconnect the battery for 5 minutes, then restart and complete a number of mixed driving cycles, town, freeway, stop and go etc., after a few days the problem will go away as the system will relearn to the clean intake

04 here ,tracker or GV, should be here http://www.fixkick.com/engine/2.5L%202004%20Tracker/fusebox1w04.JPG

Sorry in the tank

Danielle, On the driver side you may have stuff in the way, which may have to be removed, to change bulb. Sometimes it is easier to remove headlight then change bulb and reassemble. Videos attached make it look fairly easy to change he bulb with out removal of headlight. Check the attached links,instruction and guides, Good luck. "I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info." Suzuki Grand Vitara Headlight Bulb Replacement Headlight Change 1999 2005 Suzuki Grand Vitara 2003 Suzuki Grand Vitara 2... Auto Repair Maintenance How to Replace Headlight Bulbs How to replace Suzuki Grand Vitara Tail Light Bulb

SUZUKI GRAND VITARA SERVICE REPAIR MANUAL 1998 1999 2000 2001 2002 2003... for the easy solution download the pdf file

so when did car last run perfect.why was battery replaced.it cranks and runs now.but never dies driving it?never dies in neutral?get car serviced?read the chapter on idle re-calibration.here,,https://suzukipitstopplus.com/Category/3-suzuki-service-manuals.aspx

They are located on the exhaust system, one is before the catalyst and one after. If it is a v6 or a v8 it will have 4 o2 sensors. If your codes read sensor 2 it means the one after the catalytic converter.

hinge pins are probably badly worn, which will soon damage latch if not already. links to videos of different hinges pin install below press the helpful button Door Hinge Pin SAGGING CAR DOORS FIX YOUR HINGE IN 30 MINUTES OR LESS

That is usually from not enough fuel pressure.

answering for USA cars only on this USA forum.... so does the A/c work right. does the fan (blower ) surge are there other lights winking? the A/C light if blinking and the A/C main clutch does not cycle at each blink,? then.... that means just the lamp is bad, (or its wiring or contacts to it) are bad. not a big deal. id ignore it. good luck finding Suzuki parts.... they bugged out here. typical suzuki bs, no drawings, (sparse to none) id sell this dog if in usa. sure would, http://www.suzukicarparts.com/parts/2003/Suzuki/Grand%20Vitara/Base/index.cfm?siteid=214820 our last 04, this lamp assembly comes out. and can be replaced, the problem is finding parts and the wreckers here, have not suzuki anythings. its a dealer only part, but where are the dealers, answer they stopped dealing here. they do have a repair system. but you';d need to call them. (warranty repairs are still done for at least 8 years , epa laws)

Weep hole for antifreeze

which engine (G16, J20, H25/27?)??????????? do you want a list of 50 things, surely not. what do you want? say what you want. ill answer in physics. (shorter list) 1: cooling system , weak. 2: engine producing too much heat and above same time. on a new car, it can have #2 and #1 hides this fact.

1. from a bad rad cap all the way to...
2. to cracked block or head.

why guess? we can test or Guess. so here comes first questions does it overheat parked or moving or both.? is the coolant fresh and 50% ratio, and level good in RAD neck full, up dead cold????????

see the slide show. yet. http://www.fixkick.com/engine/20Liter/html/index.html

check all fuses

Bad glow plugs or coil

read the operators guide yet? google suzuki pit stop. then click that, and bingo.

no symptoms stated. so no context.....zero. no engine. stated. we cant guess engines here (posted 10,000 times) and still no engines ever stated. so ill guess. 2.5L H20 engine. and is here. btw, you can go to dealer dot com and see all parts for all cars. just go there and look, see your engine,they ask in step 2. after year. see page 28 ID 26 , BINGO http://www.fixkick.com/hubs/vitara/new-vit-hubs.pdf on the real photo you can see the gallery to the left of the pump and the hole here clearly. see photo page 5 left bank , no sensor but see that threaded hole to the left CL of filter. mount? bingo 2. the sender checks the pressure dead center on the main OIL Gallery.