20 Most Recent 2004 Chrysler PT Cruiser Questions & Answers

Hi there's this website something like reliable-store and it is very amazing for manual for repairing servicing anything
someone on fixya recommended it to me and I thank him even today
They have full manuals and it's verrrrry cheap and mine
I got free in offers
3rd time I bought it, I also had an issue with the file so the girl replaced it in 30 mins
there is one website more but i don't remember its name it was 2 years back bitman something link this
Try these out brother

2004 Chrysler PT... | Answered on Jan 07, 2020

Clock Setting Procedure (digital clock page 242 of your owners manual)
1. Press and hold the time button until the hours blink.
2. Adjust the hours by turning the right side Tune/
Audio control.
3. After the hours are adjusted, press the right side
Tune/Audio control to set the minutes. The minutes will
begin to blink.
4. Adjust the minutes using the right side Tune/Audio
5. To exit, press any button/knob or wait 5 seconds.

SETTING THE ANALOG CLOCK (page 238 of your owners manual)
To set the analog clock at the top center of the instrument
panel, press and hold the button until the setting is
correct. The clock will adjust slowly at first and then
quicker the longer the button is held.

2004 Chrysler PT... | Answered on May 07, 2019

Trouble Code: P0572

Brake Switch Signal No. 1 Circuit Low

Trouble Code Conditions:Ignition is on. When PCM recognizes that brake switch is mechanically stuck in the low/on position, a DTC will set. Three global good trips are necessary to turn off MIL.

Possible Causes:

* Brake switch signal circuit is shorted to ground
* BS No. 2 signal open
* Brake switch is damaged or has failed
* PCM has failed

i would check the brake switch first located under dash and when brake is pushed it hits switch turn ignition on and test the wires if all hot then switch is bad, other wise there is a short or bad pcm and these are not easy fixes requires knowledge of car wiring and diagnostic tools/computer

2004 Chrysler PT... | Answered on May 03, 2019

The relay box is under the hood on the drivers side of the vehicle. Should be a schematic inside the cover relating to which relay is which

2004 Chrysler PT... | Answered on May 20, 2018

My friend is a part time mechanic he gets his solutions from www.reliable-store.com he gets from their every single detailed info, instructions, diagrams, error codes, troubleshooting, transmission etc. everything on all
vehicles, and factory manuals for service, repairs, parts, owner's, operations, maintenance etc.
U can get help from there
there is a girl at chat she can help you

2004 Chrysler PT... | Answered on Mar 20, 2018

My personal suggestion would be to go for these repair catalogs. I know this website www.reliable-store.com that i used to get manuals from, and they have all models online.
I also brought for my 1989 BMW, such old model, they had it and it was very good manual. Go ahead, I bet.

2004 Chrysler PT... | Answered on Mar 14, 2018

Testing the starter electrical circuits is how to find the problem . Viewing wiring diagrams to see what all is involved in the starting of your vehicle ? Most vehicles have a starter relay that is energized by the PCM/ECM - engine computer . B+ voltage comes from the ignition switch going through the starter relay control side to the PCM - which will ground that circuit turning on the relay sending B+ voltage to the S terminal on the starter solenoid .
Do you know what a automotive relay is an how to test ? How to test for B+ voltage at the starter ? How to use a DVOM - digital volt ohm meter ? Free wiring diagrams here http://www.bbbind.com/free-tsb Enter your vehicle info. year , make , model and engine size. Under system click on engine ,then under subsystem click on charging system . Click the search button then the third blue link , this is the starter electrical circuit . This diagram doesn't show the park neutral safety switch input to the PCM . Speaking of the park neutral switch , put transmission in neutral an see if it starts then , could be the switch is bad .

2004 Chrysler PT... | Answered on Feb 19, 2018

When you turn the key and it doesn't start, what happens? Do any of the dash warning lights come on? Does the engine turn over but not start?
1. If the dash lights DO come on every time, but the engine doesn't turn over every time, it's probably not a problem with the switch. Might be a bad starter relay.
2. If the dash lights DON'T come on every time, then it could be the switch (electrical contacts only working sometime). First, try spraying WD-40 or electrical contact cleaner into the lock area to see if that helps. If it doesn't, then you probably need a switch. Do a search for "ignition switch 2004 PT Cruiser" and you'll probably find what you need, including instructions. Be sure to disconnect battery before replacing the switch and follow precautions against activating airbag accidentally.

2004 Chrysler PT... | Answered on Feb 09, 2018

Sounds like you have a vacuum leak,check all vacuum hoses for leaks but if your car has a plastic intake it might be cracked or it might have a bad gasket on intake.but I need to know what the dealership said ,and have you had a tune up on it .

2004 Chrysler PT... | Answered on Feb 09, 2018

You shouldn't have any gas smells, maybe a little if the engine were cranking over without starting. But your car is not even cranking, right? Or will it crank and not start? In that case you might smell a little gas, so next step would be to check for spark.

The leak on front passenger side: if that is where the front of the engine is, check carefully your water pump for leaking (then it is bad) and also check all hose connections there for leaks.

Sudden no-start conditions are usually loss of either spark or gas to the cylinders. These are the first things to check when it won't start.

2004 Chrysler PT... | Answered on Dec 13, 2017

Perhaps you better learn to trust the mechanic .

2004 Chrysler PT... | Answered on Dec 10, 2017

just like any computer, unplugging it for 30 seconds or so may cause it to revert to initial settings.... if you take the battery terminal off you will reset everything and that is not necessary.... find the fuse for the radio and yank it.... see if it helps. IF NOT, probably a burned programming mode... hope you like that station....

2004 Chrysler PT... | Answered on Nov 19, 2017

you need to eliminate one thing at a time and this is how . inspect the oil cap where you put oil into your car and make sure there is no white discolouration build up on the underside of the cap (if there is this can indicate water has mixed with the oil head-gasket leaking )the water pump can be checked after the car has been running for a few mins by feeling any rubber water hoses going to and from the radiator both should be about the same temp . The fan will come into play after the motor has reached a higher temp and can be seen spinning if not they are at fault .a inspection of the water reserve tank should prove to be clean and not contain any oily build up if so it might be contaminated by oil ( head gasket leaking ) you may need to flush the coolant system mainly the radiator by using a chemical wash to help unblock any build up .

2004 Chrysler PT... | Answered on Nov 18, 2017

It is on the rear of the engine, passenger side. You need to access it from the underside and it is halfway up the block between the head and the oilpan. It is real close to where the engine and transmission meet.

2004 Chrysler PT... | Answered on Nov 10, 2017

You must have the engine control fault codes read with a scanner.

2004 Chrysler PT... | Answered on Nov 09, 2017

have alternator checked again . put 3 new ones from azone before i got a good one, remanufacture parts have problems, thats why there cheaper

2004 Chrysler PT... | Answered on Sep 19, 2017

Most auto parts stores will come out to your car and connect a 'code reader' to the On Board Diagnostic (OBD) connector under your dashboard for free. The code often helps you identify what's not working correctly.

2004 Chrysler PT... | Answered on Aug 18, 2017

Not finding what you are looking for?
2004 Chrysler PT Cruiser Logo

948 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Chrysler Experts


Level 3 Expert

85239 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8984 Answers

Are you a Chrysler Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

PT Cruiser Chrysler

  • PT Cruiser Chrysler

Most Popular Question

replased head 04 pt cruiser cranks but

  • Cars & Trucks