20 Most Recent 2004 Chevrolet Express Questions & Answers



PLEASE DON'T FORGET TO RATE--You didn't post the size of motor so please pick the applicable one:

Accessory serpentine belt routing—4.8L, 5.3L and 6.0L engines

Accessory serpentine belt routing—4.3L, 5.0L and 5.7L engines without A/C

Accessory serpentine belt routing—4.3L, 5.0L and 5.7L engines with A/C

Accessory serpentine belt routing—6.5L Diesel engines

Accessory serpentine belt routing—7.4L engine

Accessory serpentine belt routing—8.1L engine
2/16/2021 12:13:10 PM • 2004 Chevrolet... • Answered on Feb 16, 2021

Door stop is broken on left side passenger door

Striker post If you need further help, reach me via phone at https://www.6ya.com/expert/ralph_f3d50d49191a7202
10/24/2017 9:36:18 AM • 2004 Chevrolet... • Answered on Oct 24, 2017

Chevy express conversion van air conditioning

notify chevy of your complaint this fixya we are not affiliated or associated with chevrolet or their vehicles
7/8/2017 11:29:29 PM • 2004 Chevrolet... • Answered on Jul 08, 2017

2004 chevy express 3500 no shifting properly

if you have specific details as to the times , rpms , conditions that cause the problems take it to an accredited auto transmission specialist shop and have it diagnosed with your details they should be able to pinpoint the fault as it will not be uncommon
6/8/2017 10:30:15 PM • 2004 Chevrolet... • Answered on Jun 08, 2017

Replacing blend door actuator on chevy express van

The actuator is probably way up under the dash and impossible to see until you remove AC pipes or glove box. Check shop manual if possible.
3/25/2017 2:27:08 AM • 2004 Chevrolet... • Answered on Mar 25, 2017

Where is orifice tube on 2004 Chevy express?

Should be in the upper line that goes into the evaporator
8/22/2016 10:38:21 PM • 2004 Chevrolet... • Answered on Aug 22, 2016

Why won't it turn over?

This may be related to the antitheft system The system is known for turning off the starter and/or injectors when it fails. Is there a light on the dash that says SECURITY? This is a common problem worth looking into. http://www.diy-gm-security.com/ 26024633-vycpj41x2iphfdmbx4v0vfed-3-2.jpg
12/30/2015 5:37:53 PM • 2004 Chevrolet... • Answered on Dec 30, 2015

Where is the cabin filter located?

Check your shop manual.
10/2/2015 9:04:36 PM • 2004 Chevrolet... • Answered on Oct 02, 2015

How do you set the clock on a 2004 Chevy Express Van

The HR arrow is the left one and the MIN arrow is on the right.

Here's the instructions from the manual:

Press and hold the HR or MIN arrow for two seconds.
Then press HR until the correct hour appears on
the display. Press and hold MIN until the correct minute
appears on the display. The time may be set with the
ignition on or off.
Hold either arrow down for two seconds and then you can adjust the hour and minutes.

5/4/2015 6:27:25 PM • 2004 Chevrolet... • Answered on May 04, 2015

Why won't 2004 chevy express start when security light is on?

because ignition key has a chip that allow ecm to start the engine if you are using a key copy it will not working, if you don't have the original key with the chip on it you must take vehicle to the dealer to disable the security program on engine computer
4/23/2015 5:15:16 AM • 2004 Chevrolet... • Answered on Apr 23, 2015

Howoften doyouchange differential flluid

50 thousand miles
4/23/2015 5:07:42 AM • 2004 Chevrolet... • Answered on Apr 23, 2015

99 chevy 3500 van 5.7 liter drive belt diagram

see attached - I assumed you have ac 21887722-b2l3qrdyfwartoeunww2aiqc-4-0.gif
1/4/2015 3:19:05 PM • 2004 Chevrolet... • Answered on Jan 04, 2015

2004 Chevy Express 3500 transmission will only shift into reverse the shifter will not go any further

Check for damaged linkage cable or the shifter it self.
11/6/2014 4:55:28 PM • 2004 Chevrolet... • Answered on Nov 06, 2014

Turn signal relay location

Turn signal doesn't have a relay. If your talking about the flasher, it is built into the hazard switch. Which yours may or may not be in the turn signal switch. If the hazard is on the column, then it is in the switch. In the dash, it's not. I haven't worked on the express, but that's where GM puts them.
8/21/2014 10:55:19 PM • 2004 Chevrolet... • Answered on Aug 21, 2014

Engine 1 fuse keeps blowing?

had the same problem. Trace pink wire in harness rubbing on dogbox frame in engine compartment.
8/1/2014 12:15:13 AM • 2004 Chevrolet... • Answered on Aug 01, 2014

Trouble removing fan clutch on 2004 chevy express

  • Yea that fan seems like a pain but all you have to do is stabilize it. A strap wrench is ideal but a belt will work too. Use this to stabilize your fan.
  • Now there is a nut on the back. Trick is this is a left handed thread. Right turns to loosen.

Regards, Tony
8/1/2014 12:01:04 AM • 2004 Chevrolet... • Answered on Aug 01, 2014

Right power outlet not working

Hello. there are two fuses for the power outlets. check them both to make sure they are good. here is the fuses you need to check. both of these fuses are located in the fuse block under the hood.

CIGAR FUSE numbered 30 it is a blue 15 amp fuse.
the other fuse is AUX PWR numbered 29 it is a yellow 20 amp fuse
7/17/2014 5:06:42 PM • 2004 Chevrolet... • Answered on Jul 17, 2014
Not finding what you are looking for?

336 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Chevrolet Experts

Ronny Bennett Sr.
Ronny Bennett Sr.

Level 3 Expert

6963 Answers

john h

Level 3 Expert

25714 Answers

Ryan Lutton
Ryan Lutton

Level 3 Expert

1267 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Express Chevrolet

  • Express Chevrolet

Most Popular Question

need diagram routing serpentine belt

  • Cars & Trucks