Question about Suzuki 2005 KingQuad 700 4X4

1 Answer

Hi, I own a Suzuki '00 Kingquad 300 atv, My problem is that it only charges the battery when I turn my lights on, when I shut them off it stops charging. I changed the voltage regulator, but still no change. What can cause this? could it be a bad ground? or stator but why would it charge when my lights are on?Can anyone help me out?

Posted by cameron claude on

Ad

1 Answer

Scott Tx

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Prodigy:

    An expert who has answered 500 questions.

  • Suzuki Expert
  • 604 Answers

I'd guess bad wiring from the regulator. mine regulator burned up and I had to run a new wire from it to the battery.

Posted on Nov 12, 2017

Ad

5 Related Answers

Anonymous

  • 13 Answers

SOURCE: the wires going to the voltage regulator keep burning up.

Common problem with poor quality parts, the regulator is the problem, the generator is working other wise you would not have fried the wiring, you answered your own question. someone telling porkies to get more money from unsuspecting client?
The regulator controls the voltage not the generator, the generator only supplys the voltage it cannot overcharge unless the regulator is not working properly, simple!

Posted on Jul 28, 2009

Ad

Anonymous

  • 221 Answers

SOURCE: wire connector between stator & voltage reg/rectifier burnt

your voltage/reg. can be tested in a couple different ways check ground res. check res. then revs. bias on diodes you have ac in dc out it sounds like you may have a diode gone bad allowing ac curent to flow causing the wires to get hot

Posted on Jul 31, 2009

Benimur

Louie Role

  • 6966 Answers

SOURCE: wiring from stator to regulator/rectifier to cdi on chinese atv

Hi and welcome to FixYa,

Would this help? From the stator:

  • 3 yellows to the rectifier/regulator combo;
  • blue & green from the pulser coil to the CDI.  The blue here is actually connected to the ground.  The CDI's ground wire is black/white;
  • (near the stator) single blue to the CDI.

Good luck and thank you for asking FixYa.

Posted on Aug 17, 2009

czaa

Arnie Burke

  • 6329 Answers

SOURCE: Voltage Regulator Problem?

u want to chec alternator as well-ther r test u can do so buy a clymer manual which r very detailed-iv seen hd books in library sec 629

Posted on Aug 19, 2009

ckoira57

ckoira57

  • 267 Answers

SOURCE: wiring for 78 suzuki gs550e stator ant regulator

The site below (exploded views - part chart) should get you mobile again, see electrical and wiring harness sections . The rest of the bike is there also. Cheers.

http://www.cmsnl.com/suzuki-gs550e-1977-1979-usa_model16028/partslist/

Posted on May 20, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

My 2013 Suzuki 750 King quad EFI will start but if you move the steering it shuts down. Also, when slowing to a stop, the bike stalls. Each time the bike stalls it immediately starts.


Sounds like you have a wire that is ALMOST broken or the insulation is worn off and grounding, or turning is pulling a wire loose from a connection. .. this type of problem is HARD to trace down sometimes... good luck

Sep 04, 2017 | Suzuki 2006 KingQuad 700 4X4

1 Answer

Checking oil on a king quad 300


there's a round glass window back near the right rear wheel. oil should be between the lines while on level ground and turned off for a few minutes

Jul 08, 2015 | Suzuki 2005 KingQuad 700 4X4

1 Answer

Suzuki king quad problems


Personally i would check and see if you have any water in the carb before anything. this seems to be a common prob.

Jul 23, 2014 | Suzuki 2006 KingQuad 700 4X4

1 Answer

Oil heat light stays on my 2000 kingquad 300


are you low on oil?incorrect oil?

Sep 30, 2013 | Suzuki ATVs

Not finding what you are looking for?
Suzuki 2005 KingQuad 700 4X4 Logo

Related Topics:

547 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki ATVs Experts

Marvin
Marvin

Level 3 Expert

85239 Answers

Paul Bade

Level 3 Expert

1662 Answers

Philip Morand

Level 2 Expert

205 Answers

Are you a Suzuki ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...