Question about Polaris 2014 Ranger Midsize 800

1 Answer

How to fix injector yourself - Polaris 2014 Ranger Midsize 800

Posted by Cliff morris on


1 Answer

Huseyin Huseyin

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points


    An expert that got 20 achievements.


    An expert that got 10 achievements.


    An expert that got 5 achievements.

  • Master
  • 3,469 Answers

Look below for workshop/repair manuals

Posted on Jun 01, 2015


Add Your Answer


Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

2010 Polaris ranger 800xp gas getting in the oil

leaking injector , injector seal or if carby , needle and seat not sealing off and flooding into the manifold

Apr 18, 2018 | ATVs

1 Answer

2006 suzuki king quad won't start. FI light is flashing all the time. What's wrong?

Check the earth side of the injector. You may be getting the correct voltage in but the return side (neg) could be the culprit. (volt drop)

May 05, 2017 | ATVs

1 Answer

Where is the starter on the 2005 kawasaki prairie 360 4x4

In front of the crankcase....its a small, cylindrical piece with a single large wire connect to it...
It has a gear riding on the end of the shaft that is inside of the crankcase on the shifter side.. it WILL fall if you remove the starter without taking care with the gear and chain first.. just make sure the chain doesn't get away...its not a hard fix.. you can purchase a brush kit for the starter and fix it yourself .. if you have access to a lathe to turn the armature where the brushes ride.. don't forget to undercut the mica.(the grooves between the copper ridges)..or take the starter and brush kit to your local starter/alternator repair shop.. and have them fix it.

Mar 12, 2017 | ATVs

1 Answer

Honda atv efi rough idel

clean injectors
use an injector cleaner

Feb 10, 2017 | ATVs

1 Answer

2005 suzuki lt-700a will not start will crank over but not starting fuel is going to fuel injector but not coming out of injector even though it's good

Have you checked to see if the spark plug is firing??
How do you know the "injector" is good?

Is the spark plug wet after you try to start it for a few minutes??

More info please...

Jan 05, 2017 | Suzuki 2005 KingQuad 700 4X4

1 Answer

My Polaris sportsman 600 twin 2003 starts and idles but won't reve seems to be missing and blowing black smoke ?

black smoke is over fueling--choke on or leaking injector or injector seals
check for blocked air cleaner

Dec 02, 2016 | ATVs

1 Answer

What does error code 021 mean for my 2013 Polaris XP900 mean

I found a list that might apply. Not specific to Polaris, but general for electrical. Code 021 reads accelerator fault safety lock out inspect accelerator resistance and wiring

Here's the complete list.

Hope this gives you something to look at

I also found this list specifically for Polaris:

21 Loss of Synchronization
22 TPS Circuit: Open and Short To Ground
22 TPS Circuit: Short To Battery
23 RAM Error: Defective ECU
25 Transmission Input - Invalid Gear
26 Vehicle Speed Sensor - Implausible
41 Air Temp Sensor: Open or Short Circuit to Sensor Voltage (ECU)
41 Air Temp Sensor: Short Circuit to Ground
42 Engine Temperature Sensor Circuit: Short To Ground
42 Engine Temperature Sensor Circuit: Open or Short to Battery
45 Barometric Pressure Sensor: Circuit Low Input
46 Barometric Pressure Sensor: Circuit High Input
51 Injector 1: Open Load
51 Injector 1: Short Circuit to Ground
51 Injector 1: Short Circuit to Battery
52 Injector 2: Open Load
52 Injector 2: Short Circuit to Ground
52 Injector 2: Short Circuit to Battery
54 Engine Temperature Lamp: Open Load
54 Engine Temperature Lamp: Short Circuit to Ground
54 Engine Temperature Lamp: Short Circuit to Battery
55 Diagnostic Lamp: Open Load
55 Diagnostic Lamp: Short Circuit to Ground
55 Diagnostic Lamp: Short Circuit To Battery
56 Pump Relay Open Load
56 Pump Relay Short Circuit to Ground
56 Pump Relay Short Circuit to Battery
58 Cooling Fan: Open Load
58 Cooling Fan: Short Circuit to Ground
58 Cooling Fan: Short Circuit to Battery
61 End of Diagnostic

Jul 22, 2016 | Polaris 2013 RZR XP 4 900 EPS Black /...

2 Answers

How to replace a fuel injector?

Turn the power off. Disconnect the hose(s) unscrew - replace

Jul 16, 2015 | ATVs

1 Answer

Have error code 652 on Polaris 800 ranger?

injector code, what does it say at the bottom of the display, if it is giving a number then that the injector thats malfunctioning.

If you need further help, reach me via phone at

Oct 11, 2014 | Polaris 2014 Ranger 800 EPS Sunset Red LE

Not finding what you are looking for?
Polaris 2014 Ranger Midsize 800 Logo

1,210 people viewed this question

Ask a Question

Usually answered in minutes!

Top Polaris ATVs Experts

john h

Level 3 Expert

23504 Answers


Level 3 Expert

85239 Answers

Tom Chichester

Level 3 Expert

60292 Answers

Are you a Polaris ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides