Questions & Answers for: mobility scooter brushes hot

...scooter and at low speeds it shutters and gets worse when it gets hot and worse in reverse.. that could be the speed pot , try moving the throttle lever upwards to see whether it stops shuttering, if ...

...brushes are not worn badly. You can also chek the rear of the scooter where the brake and the motor are attached and after a period of driving this area can be warm but not very warm or hot to touch. ...

SCOOTER UNTILL IT STOPS OR 10 MINUTES WHICH EVER COMES FIRST. THEN BEING CAREFUL NOT TO GET BURNED ( THE BRAKE CAN BE VERY HOT) FEEL THE BRAKE, IF IT IS HOT REPLACE IT, IF THE BRAKE IS NOT HOT YOU MAY

...scooter and the motor gets hot-could it be that the brake has to be replaced or the motor the rear wheels started to make a clicking noise before the circuit braker would kick out First check to see ...

...brushes once again if they touching at a point yes they could arcing and result of that smoke, however i believe your motor could be breaking down, resistance wise , hence the fact it getting too hot ...

...long stretch would be breaker and lastly motor if cables get hot try replace them first with larger wire sounds like a resistance problem assumeing your batteries are good and motor brushes ...

mobility scooters. After 20 minutes of use the motors on both scooters are getting very hot and then stop. The motor first gets hot where the brushes make contact with the armature. Then it spreads to

have 2 turn it back on to go.Drives slow. Interacting lights go on but not showing up at back of scooter The controller is probably getting hot. Worn motor brushes or going up hill too long will do it

...the problem. They are not difficult to replace. its recommended you change at 9mm length if you need new ones visit this great site for all scooter motor brushes http://www.mrcarbonbrush.com/ ...

...Mobility Products Sounds like the motor is getting too hot. Several reasons for that. The brushes in the motor can be worn, too much weight on the scooter, rider + whats in the basket or is being ...