Question about Hifonics BX2200D Car Audio Amplifier

Open Question

I purchased bx2200 new a few yrs ago, and it sat new in the box until a month or so ago. Upon installation it made a loud "pop" and began to smoke. I immediately shut it off. I took it apart and had blown 1 of the 4 caps marked 400v 3300uf. I believe they are a "snap-in" cap for filtering power. Where can I purchase these caps? I've looked online at mouser, parts express and many others. Seems to be a hard size to locate. What could have caused this cap to blow?

Posted by on

3 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 231 Answers

SOURCE: my bx2200 cut off as soon as it was turned on and started smoking?

these are the trasistors..The ones closest to the power connectors are probably the ones for power supply and or 15 volt regulators..The rest are for amplifier section.Im guessing all except regulatos will be MOSFET transistors .If you are to replace them ..Stick to original parts..You can probably find these at mcmelectronics.com or mouserelectronics.com Just give then the numbers on transistors .Also make sure all other parts around shorted parts are okay before you install new parts..

Posted on Dec 09, 2007

  • 631 Answers

SOURCE: my bx2200 cut off as soon as it was turned on and started smoking?

It sounds like the power supply transistors have failed. You'll need to pull the clamps and get the numbers off of the transistors. It's also possible that the 47 ohm gate resistors have failed. After removing the old transistors, you need to check the resistors individually.

Since you're new to repair work, read the following page.

Basic Repair Introduction

Post the part numbers if they are incomplete and you can't find the correct replacements. mouser.com is probably the best place to buy small quantities if you're in the US.

You also need to check the output transistors to see if any are shorted. If they are, the repair will be more difficult (especially if there is damage to the driver board).

Posted on Feb 15, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

My Crosley oven has a new element and timer and still will not heat up


It sounds like you need to replace the burner receptacle, in either the broiler or the bottom oven burner( heating element) or both. When it exploded it burned the contacts in the heating element.

Apr 11, 2014 | Ovens

1 Answer

Car won't start. it tries to turn over, but just doesn't .battery replaced several months ago so it's not that. The red "GEN" light pops up. Is that the generator signal? Manual doesn&


Interesting. They haven't used generators in over 50 yrs.
But yes that was the warning light for the generator.
If you have a volt meter that would tell you what the system is doing.
If the engine will not crank, and the battery is fully charged, you would need to check the connections at the starter for voltage and ground.
And the red warning lights would normally come on until the engine starts.

Jan 13, 2013 | 1996 Jeep Cherokee Sport

2 Answers

Heard a loud pop and picture went bad, very bad.


Loud pop is usually (99%) a capacitor. More than likely on the power supply. Needs to be serviced.
-=/ Daft Tech /=-

Oct 23, 2009 | Zenith Z50PX2D 50 in. Plasma HDTV

1 Answer

91 oldsmobile cust cruisr, shuddering, engine loping


do u have a OBD 1 scan tool? try and find one on ebay for your car, I sold mine some time back, was $400 new got $50 for it, but I fixed allot of problems like yours because it allowed me to look at real time engine data going to and out of the engine control computer (ECM)

Feb 11, 2009 | 1991 Oldsmobile Custom Cruiser

1 Answer

Canon PIXMA MP530 printer repeatedly getting LCD Error Message: "CHECK INK U071 5Bk". I have removed, reinstalled, reseated the 5Bk and all other ink tanks multiple times. Usually when this...


I have Canon M560 printer installed 8 months ago. I replaced the CLI 221 Magenta and CLI221 Cyan ink cartridges, won't work and got this message Error 1411. Tried repeatedly to reinstall the ink cartridges and still have this message coming back. Any solution you could offer? I would appreciate it. Thank you.
ben

Nov 06, 2008 | Office Equipment & Supplies

1 Answer

There is an odour coming from our auto top loader washer we purchased in 2005 model #lxr7244pq0 after it has been used and has sat idle overnite. What do you suggest??


a lot of people don't use chlorine bleach much any more ..see a lot more complaint of odor that did 20 yrs ago best solution fill with hot water pour in 2-3 cups old fashion clorax let agitate untill thoroughly mixed shut off let sit 30-45 min or longer restart and let finish cycle ..leave lid open between use if possible and do clean every few months if odor starts agin or use bleach more often

Jun 18, 2008 | Whirlpool Washing Machines

1 Answer

Dryer


i used to do warranty work for LG needless to say, after finding out customers were waiting up to 2 1/2 months just to get parts i stopped doing any work for them. if it were me, i would take both the washer and dryer back and buy a bosch instead. much more reliable and there customer service is great

Nov 28, 2007 | Dryers

Not finding what you are looking for?
Hifonics BX2200D Car Audio Amplifier Logo

Related Topics:

35 people viewed this question

Ask a Question

Usually answered in minutes!

Top Hifonics Car Audio & Video Experts

Professor_V
Professor_V

Level 2 Expert

92 Answers

Matthew Spark
Matthew Spark

Level 3 Expert

1066 Answers

Radames Pagan
Radames Pagan

Level 3 Expert

196 Answers

Are you a Hifonics Car Audio and Video Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...