What oil to use for a passat 1.9 tdi 2003 - 2003 Volkswagen Passat

Question 1

0helpful

1answer

Vw Passat 03 dti.when i accelerate i hit a flat spot

Thread: passat 1.9tdi 115bhp 2000 model excesive flat spots - VW ...

www.vwaudiforum.co.uk/.../21982-passat-1-9tdi-115bhp-2000-model-e...
Apr 8, 2015 - Hi everyone I'm new to this forum stuff so if I'm posting in the wrong place about the wrong thing ,pm me and let me know.I've just bought 1.9 tdi passat 115 bhp ... Thread: 1.9 tdi smoking under acceleration
Apr 9, 2015
Thread: 2004 1.9TDI white smoke
Apr 7, 2015
Thread: Audi a3 2.0 tdi flat spot sluggish
Jan 7, 2013
Flat spots in acceleration when less than 60mph in 6th? 2006 TDi ...
Dec 6, 2010
More results from www.vwaudiforum.co.uk

Sep 28, 2015 • Cars & Trucks

2helpful

1answer

Volkswagon passat tdi engine problems

hello : my proplem is began after i drive my passat 5 kilometer the EPC yellow light is appear and i dont know what that mean . thanks foer your help .. my passat 2003 model petrol . 2000 cc .
Rami Safran
PALESTINE

Apr 12, 2012 • 2004 Volkswagen Passat

2helpful

1answer

Oil warning light on saying oil pressure pump STOP engine Oassat diesel 2.00litre First Reg Nov 2005 mileage 56,5000 approx.On standard servicing schedule not long life

STOP the engine immediately !!! There is an oil pump failure of 2.0 TDI engines !
Remove the oil pan and the oil pump & balancer shafts assembly.

Either the shaft driving the pump from the balance shaft rounds off or the balance shaft drive gears eat themselves.
The same issue ... low oil pressure warning light, noisy rattling engine, and the turbo has gone. Diagnosis: oil pump balancer shaft assembly ...

Many Passat show excess chain noise and wear anywhere from 50,000-100,000+ miles. Cars have broken the chains/tensioner as low as 65,000 miles. This is just a range of cars that have been reported, diagnosed, and repaired. The actual statistics on dealer repairs or failures is unknown and I've heard cars over 100,000 miles that, in my opinion as a non mechanic (most mechanics wouldn't recognize this sound and problem either), aren't noisy. From what has been reported, noticeable noise/chain-tensioner wear/greater risk of breaking is around 60,000-150,000 miles. Your case may vary. The most obvious symptom is a rattling loose noise from the oil pan. Unless you listen to a Passat TDI with a tight chain and one with a loose chain, it's hard to describe the difference other than rattling chain noise.
The reason the gear drive oil pump modification was started is because a few mechanics who specialize in TDI have seen many worn oil pump chains/sprockets/tensioners. There will always be a few defective parts that come off the assembly line and all mechanical components like chains wear out sooner or later, but in my opinion, the failure rate is abnormal considering the number of Passat TDI sold versus the number of reported oil pump failures. This does not necessarily mean that every or even most Passat TDI will have this problem, just that the reported failure rate is high enough to consider this part a design failure. Nobody, not even VW-Audi knows the average time between failure for these parts and the percentage of cars that will have this problem, but they changed this design and if you want to not have this specific failure, the only sure way is to swap to the geared module.

Apr 15, 2011 • 2006 Volkswagen Passat

0helpful

1answer

Got a vw passat 1.9 tdi got oil in water but no water in the oil,changed the oil cooler which was recomended.still finding oil in water is it just still in the water system or a deeper problem

you could have oil in the system for years,as it sticks to the waterways/pipes,so shows as a "slick"Just check you levels every week, to make sure nothing is untoward.

Jan 31, 2011 • 2003 Volkswagen Passat

0helpful

1answer

463A COD ERROR VW PASAT

hi i need help i have vw passat 1.9 tdi 66 kw 99 year i have problem the car dont have power to go . turbo its on bot car dont have speed and i have fault 463A and fault 04D5 can same 1 help me pls
ty

Jul 18, 2010 • 2003 Volkswagen Passat

2helpful

1answer

My 2000 vw passat 1.9 TDI manual grinding gears

as 2nd/3rd are the most used gears chances are the syncromesh on both these gears has gone,you need to strip g/box completly/or buy a recon box.

Apr 28, 2010 • 2000 Volkswagen Passat 4Motion

0helpful

1answer

RE: 2004 VW Passat - Fuel Cap Light and MFI

it could happened after washing , i think they have wash the car and some amount of water got in side of fuel flap sensor , try to clean it, or you have to replace it. thanks.

Feb 26, 2010 • 2003 Volkswagen Jetta TDI

0helpful

2answers

Location of oil filter on a VW 1.9 TDI passat 2003

WELL THAT YEAR DOSE NOT COME WITH 1.9 BUT ANY WAY IT SHOULD BE UNDER CAR NEAR RIGHT AXLE OR LEFT SOME TIMES

Aug 31, 2009 • 2003 Volkswagen Passat

2helpful

1answer

Rear noise vw passat 1996 tdi estate

change anti roll bar bushes.Allso check coil springs are not brocken.

Jul 04, 2009 • 1996 Volkswagen Passat

0helpful

1answer

Transmission, where do i put fluid in on a 2003 vw passat 2.8

wen the car is hot on the center of transmission pen big plug use only vw fluid you need a oil needle car need to be running hot and horizontal good luck

Aug 04, 2008 • 2000 Volkswagen Jetta TDI

Question 2

Anonymous

Master 5,081 Answers
Posted on Oct 16, 2009

Anonymous

Master

Joined: Jul 03, 2009

Answers

5081

Questions

3

Helped

2236602

Points

18738

In order of preference:
Amsoil 5W-40
Valvoline 5W-40
Both meet the VW spec.

Answer 2 · 3/24/2009 12:00:00 AM

Marvin

85242 Answers
Posted on Mar 24, 2009

SOURCE: how much oil for oil change 2003 Jetta TDI

I looked it up, add 4.5 quarts oil and filter

Earl Norager

355 Answers
Posted on Aug 31, 2009

SOURCE: Location of oil filter on a VW 1.9 TDI passat 2003

WELL THAT YEAR DOSE NOT COME WITH 1.9 BUT ANY WAY IT SHOULD BE UNDER CAR NEAR RIGHT AXLE OR LEFT SOME TIMES

Anonymous

4793 Answers
Posted on Apr 28, 2010

SOURCE: my 2000 vw passat 1.9 TDI manual grinding gears

as 2nd/3rd are the most used gears chances are the syncromesh on both these gears has gone,you need to strip g/box completly/or buy a recon box.

Answer 3 · 3/24/2009 12:00:00 AM

Marvin

85242 Answers
Posted on Mar 24, 2009

SOURCE: how much oil for oil change 2003 Jetta TDI

I looked it up, add 4.5 quarts oil and filter

Answer 4 · 8/31/2009 12:00:00 AM

Earl Norager

355 Answers
Posted on Aug 31, 2009

SOURCE: Location of oil filter on a VW 1.9 TDI passat 2003

WELL THAT YEAR DOSE NOT COME WITH 1.9 BUT ANY WAY IT SHOULD BE UNDER CAR NEAR RIGHT AXLE OR LEFT SOME TIMES

Answer 5 · 4/28/2010 12:00:00 AM

Anonymous

4793 Answers
Posted on Apr 28, 2010

SOURCE: my 2000 vw passat 1.9 TDI manual grinding gears

as 2nd/3rd are the most used gears chances are the syncromesh on both these gears has gone,you need to strip g/box completly/or buy a recon box.

Related Topics:

Trustworthy Expert Solutions

What oil to use for a passat 1.9 tdi 2003 - 2003 Volkswagen Passat

1 Answer

Anonymous

3 Related Answers

Marvin

Earl Norager

Anonymous

Add Your Answer

Attachments: Added items

Related Questions:

Vw Passat 03 dti.when i accelerate i hit a flat spot

Thread: passat 1.9tdi 115bhp 2000 model excesive flat spots - VW ...

Volkswagon passat tdi engine problems

Oil warning light on saying oil pressure pump STOP engine Oassat diesel 2.00litre First Reg Nov 2005 mileage 56,5000 approx.On standard servicing schedule not long life

Got a vw passat 1.9 tdi got oil in water but no water in the oil,changed the oil cooler which was recomended.still finding oil in water is it just still in the water system or a deeper problem

463A COD ERROR VW PASAT

My 2000 vw passat 1.9 TDI manual grinding gears

RE: 2004 VW Passat - Fuel Cap Light and MFI

Location of oil filter on a VW 1.9 TDI passat 2003

Rear noise vw passat 1996 tdi estate

Transmission, where do i put fluid in on a 2003 vw passat 2.8

Not finding what you are looking for?

2003 Passat

Vw Passat 03 dti.when i accelerate i hit a flat spot

Ask a Question

Check Out the Latest Top Trucks Report!

Top Volkswagen Experts

ZJ Limited

Bradley

Thomas Perkins

Are you a Volkswagen Expert? Answer questions, earn points and help others

Manuals & User Guides

Related Topics:

Trustworthy Expert Solutions

What oil to use for a passat 1.9 tdi 2003 - 2003 Volkswagen Passat

1 Answer

Anonymous

3 Related Answers

Marvin

Earl Norager

Anonymous

Add Your Answer

Attachments: Added items

Related Questions:

Vw Passat 03 dti.when i accelerate i hit a flat spot

Thread: passat 1.9tdi 115bhp 2000 model excesive flat spots - VW ...

Volkswagon passat tdi engine problems

Oil warning light on saying oil pressure pump STOP engine Oassat diesel 2.00litre First Reg Nov 2005 mileage 56,5000 approx.On standard servicing schedule not long life

Got a vw passat 1.9 tdi got oil in water but no water in the oil,changed the oil cooler which was recomended.still finding oil in water is it just still in the water system or a deeper problem

463A COD ERROR VW PASAT

My 2000 vw passat 1.9 TDI manual grinding gears

RE: 2004 VW Passat - Fuel Cap Light and MFI

Location of oil filter on a VW 1.9 TDI passat 2003

Rear noise vw passat 1996 tdi estate

Transmission, where do i put fluid in on a 2003 vw passat 2.8

Not finding what you are looking for?

2003 Passat

Vw Passat 03 dti.when i accelerate i hit a flat spot

Related Topics

Ask a Question

Popular Questions

A circle with a triangle

Low heat from my 2001 Passat heater

Vw passat radio code

Immobilizer active reset on 2006 volkswagon passat

Need fuse diagram for 2016 vw passat

Check Out the Latest Top Trucks Report!

Top Volkswagen Experts

ZJ Limited

Bradley

Thomas Perkins

Are you a Volkswagen Expert? Answer questions, earn points and help others

Manuals & User Guides