Question about GASKET Garden

1 Answer

My mercury 9.9 2 stroke bogs down in gear and "chugs" (not backfire but hesitates) when in gear unless I have the choke pulled all the way. Neutral is fine, revs up with no issue.

I disassembled the lower end and found the exhaust pipe clogged with carbon (couldn't see through it) I cleaned it all out and reassembled. No change. I do have black oil coming from the prop (exhaust duct). I rebuilt the carb with a new gasket and diaphram kit, no change. Tested the coils, adequate spark. I'm running out of ideas.

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Master:

    An expert who has achieved Level 3.

  • Master
  • 604 Answers

You need a complete rebuild

Posted on Apr 23, 2017

×

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I have 20hp mercury in neutral can rev high but when in gear full throttle it's like trolling speed


Take the cover off and check that the throttle linkages are all secured to the clips. May also be bad fuel, or moisture in the fuel. I use stabiliser over the winter. With a motor stored that long, it would be prudent to get it professionally serviced.

Jan 26, 2017 | Mercury Cars & Trucks

1 Answer

How do i replace a shift lever on a mercury 6 hp 4 stroke outboard 2006


Hello, is it the external shift handle you want to replace?

Then you'll have to remove the engine block from the driveshaft housing.
To do so: Drain the engine oil.
Disconnect the throttle cable from the carburettor.
Disconnect the start-in-gear cable from the recoil starter housing.
Disconnect the fuel lead at the fuel connector
Disconnect the choke puller at the carburettor.
Disconnect the white and black wire from the stop button at the engine-block and engine wires.
Remove 6 bolts holding the engine-block to the driveshaft housing.
Lift the engineblock.
The shift lever is fixed with a M6 bolt in the front-top of the driveshaft housing. You'll need a new gasket, Part Num 803508-9

Good luck!

May 04, 2014 | Mercury Marine 4hp & 6hp Stroke Outboards...

1 Answer

Mercury elpto 90


i HAD THIS ISSUE SERVERAL YEARS AGO , TURNED OUT THAT THE PROP WAS SIZED WRONG,

Jun 27, 2013 | Boating

1 Answer

1994 grand cherokee 5.2l starts fine but hesitates and bogs down when put in gear


Manual says that it is flooding.I won't say that for sure.Check choke and spring on carb to make sure it is working properly.Of course once my emergency brakes were stuck even after release.

Jun 24, 2012 | 1994 Jeep Grand Cherokee

2 Answers

Is my choke on my 97 suzuki vz800. Supposed to be


You should be able to adjust the choke to where it will stay in without holding it by turning the rubber piece behind the choke clockwise towards you until the choke stays out on its own. You can adjust this so the choke automatically adjust as the bike warms.
Hope this helps..
Jeff

Apr 09, 2010 | 1997 Suzuki VZ 800 Marauder

1 Answer

Blazer hesitates, backfiring and bogging out


auto choke sticking on get it checked out..

Nov 18, 2009 | 1993 Chevrolet S-10 Blazer

1 Answer

1998 Pontiac Bonneville SE 3.8L Backfires/ Sputters


sounds like the ignition module is going bad.

Aug 04, 2009 | 1998 Pontiac Bonneville

Not finding what you are looking for?
Garden Logo

Related Topics:

65 people viewed this question

Ask a Question

Usually answered in minutes!

Top GASKET Garden Experts

Dennis Key
Dennis Key

Level 3 Expert

2478 Answers

john h

Level 3 Expert

12173 Answers

yadayada
yadayada

Level 3 Expert

76164 Answers

Are you a GASKET Garden Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...