What does free mean? - ATVs

po635 should be for power steering issue.

I think it's over voltage, possibly your voltage regulator causing it.

new doesnt mean free from defects --floats may need adjustment or fuel adjustment not correct

By everything, I am assuming you mean the charge coils, regulator/rectifier and the battery? Then all you are left with is wiring. Bad charge coils means low or no output. Bad regulator/rectifier can mean either the regulator prevents the charge from getting to the battery or the rectifier is bad and dumping charge to ground or sending AC (Alternating Current) into the battery, which will kill it is short order. If there is no water in the battery or the plates are shorted, it will not accept a charge.

If you mean revs when you turn the handle bars your throttle cable needs to be longer. Or check the routing of your cable and see if you can get more free travel.

Hi the cable needs slack if you take all the adjust out meaning the is no free play in the cable your taking the pressure off of the clutch plates causing it to not be engauged.

That is equivalent to a "Check Engine" light, meaning that a condition exists which requires attention. Check all fluid levels, and readout codes from the ECU as a starting point for diagnosis.

From Repair Pal:

Auto Systems and Repair

Engine Coolant Temperature Circuit Intermittent Our emissions expert has put together the following information about the P0119 fault code. We have also included diagnostic procedures you can take to your repair shop if the mechanic is having difficulty analyzing the code.
OBD II Fault Code

• OBD II P0119

Fault Code Definition

• Engine Coolant Temperature Circuit Intermittent

What does Mean?The Engine Coolant Temperature Sensor measures the rise and fall of the Engine Coolant Temperature. This provides critical data needed for the Powertrain Control Module (PCM) to control the Air Fuel Ratio, the Ignition Spark Timing, the cooling fans, and many components of the Emissions Control Systems. The Engine Coolant Temperature Sensor converts the coolant temperature into a voltage that is high when the engine is cold and low as the engine warms up.
Code P0119 indicates an intermittent voltage input from the Coolant Temperature Circuit to the PCM.

check the wires at the speed sensor, depending on what unit you have its usually on bottom of rear transmission. I just replaced mine, must have been a stick that hit it and broke the plug.

means you've just been in a head on collision, call 911