Question about Samsung DLP HL-P5663W 56" TV

7 Answers

Samsung DLP loud vibrating noise

My Samsung 65" DLP is almost 3 years old. While watching tv a very loud vibrating sound stated coming from within the tv. I turned the power off for an hour then tried it again. As soon as the power came on the same loud vibrating sound could be heard, (there was still a picture) so I immediately trurned the set off. I'm not good at reapairing the set myself. Any idea what it might be or do I need to take it in to be repaired. Would it be expensive to repair?Thank you

Posted by on

  • 1 more comment 
  • gblack Jan 06, 2008

    What if it doesn't go away?

  • jkyker Jan 08, 2008

    I have a 50" Samsung DLP model P5063W/HL and I have a loud hum and vibration coming from the set. I checked and on the back is a panel which was vibrating and I put rubber washers behind the screws which took away the vibration but has made the hum more noticeable and just read one of the postings. The set is only two years old and has had the hum for most of its life. Will the color wheel take care of the problem and is it easy or consumer friendly to install?

  • markmacq Sep 06, 2008

    I have a 56" HL-R5678W DLP that has a loud buzzing (not squealing) sound and vibration coming from the TV whenever it's powered on. The problem started all at once (wasn't gradual) and I'm also getting all 3 lights on the power button flashing. I removed the bulb and reinstalled and got a picture for a while, although poor/dull color and flickering. Now I'm back to no picture and 3 lights flashing. It also takes a while for it to power down and will power itself off, then quickly on for ~ 3 times over a minute or so before totally shutting itself down.. Once off the sound goes away but not the flashing lights. Not sure if the problem is the color wheel or fan, or something else. Any help would be appreciated. Thanks.

    Mark

×

Ad

7 Answers

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Novelist:

    An expert who has written 50 answers of more than 400 characters.

    Governor:

    An expert whose answer got voted for 20 times.

  • Expert
  • 192 Answers

The color wheel is the most common problem in DLPs that cause noise. To determine the cause: Turn the set off. If the noise goes away after about five seconds, then, the problem is the color wheel. If the noise goes away one to two minutes after shut off, then, the problem is a fan. You can find an Authorized Servicer in your area that can tell you the price of repair, by clicking on the Samsung link: http://www.samsung.com/Support/ServiceLocations/index.htm

Posted on Apr 22, 2007

Ad
  • Level 1:

    An expert who has achieved level 1.

    Mayor:

    An expert whose answer got voted for 2 times.

  • Contributor
  • 1 Answer

To stop the noise from the colorwheel(for us cheapies) apply about 20 lbs but not much to the back of the tv panel( i jam a log between wall and tv to apply pressure which tilts tv ever so slightly) in the bottom area near the lamp but Do not cover any vents of course and nosie of color will stop ...it works don't laugh..I'm also working on same lamp from 5 years a go by just reseting it o.oo hours used everytime it starts to blink or cut out after a few mins..

Posted on Jan 08, 2010

Ad
  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 7 Answers

Just to let every one know that from my own experience that replacing the color wheel was a breeze; my part number was a bp96-01579a for my Samsung HLT5675S. Here is a pretty nifty guide that I used: http://www.fixyourdlp.com/guides/samsung/bp96-01579a.php at first i called a tech to the house and he charge me 50 bucks just to inspect the tv, and another 300 for getting a new color wheel and replacing it. That’s crazy. After a lot of thought I decided to do it my self, I got the wheel at http://www.discount-merchant.com/ for little over 90 bucks with shipping.
Good luck.

Posted on Mar 18, 2010

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

Is there or was there any other sound when the color wheel went bad on your TVs? I was watching last night and heard a pop followed by the very loud hum! I still have a picture, but cant watch over the hum. I have been having color issues for about a month, and then a slight humming sound. I guess it all came to a climax last night!

Posted on Nov 15, 2011

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

I had the same problem. It is the color wheel. Mine was in warranty. I think you will have to call Samsung on the part.

Posted on Aug 28, 2009

  • backwardsk Dec 14, 2010

    If your Samsung color wheel is bad (note the buzzing or whirling type sound), you can fix it yourself! I did. It took me a few hours, but I saved a ton of cash over a repairman. I bought the part via this website, which had the best price I found while shopping online.

    bp96-00674a color wheel replacement

×

Check out this site. This guy has a pretty good idea of what that sound is and how to fix it. If the humming is loud enough to hear from the couch over the TV then there is certainly a problem. Hope this helps.

http://www.jangro.com/a/2006/07/24/samsung-dlp-replace-color-wheel/

Posted on Jan 08, 2008

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

PLEASE HELP! For the last couple of week my tv has been making a loud noise reminiscent of someone put a piece of paper against a fan. This noise continued for a few seconds after the tv was turned off. Suddenly this morning it stopped worked. The TV will turn on however there is no picture only sound and it turns off all together after a very short period.After careful research I was certain it was the color wheel. However after calling Samsung they have me convinced it could be a multitude of problems. I turn the tv all of the lights blink the bulb lights up and I hear the sound moments last the tv powers itself down and the bulb goes out the sound continues for seconds and then dissapears. Please help how do I know what the problem is without spending a fortune.

Posted on Aug 04, 2010

4 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

  • 1 Answer

SOURCE: dlp tv will not "fire up"

It doesn't have a flyback or an HOT genius. It's a DLP.

Posted on May 24, 2008

fillmore85
  • 62 Answers

SOURCE: I own a Samsung HL-R5067W 50

Check your color wheel. There is a DIY guide for replacing the color wheel. Mine did the same thing yours is and my color wheel was all busted up. Unfortunately after replacing the color wheel my set continues to do the same thing, but this could mean I need to replace the ballast as well.

Posted on Oct 20, 2009

  • 55 Answers

SOURCE: Samsung HL-P6163W Dlp TV has a loud humming sound

If you get a chance. Please post more details. Specially about the sound you hear in the back of tv is it like a humming or buzzing?

Posted on Mar 29, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Mitsubishi 65 dlp


SOUND LIKE A BAD COLOR WHEEL...HEAR A LINK TO SEE IF THAT THE SOUND YOU ARE HEARING ....http://www.youtube.com/watch?v=hUiYRqrNxxU

Dec 24, 2013 | Televison & Video

1 Answer

Samsung HLR5064W DLP TV load vibrating noise like a fan blade hitting something, lamp light is one, Tv will light up but discolored


Sounds like a bad color wheel----remove lamp---the wheel faces it--look for missing pieces or the wheel shattered---these are known for the wheel making a loud high pitched sound or even a grinding sound if the wheel shatters.

if wheel bad You Tube has video instructions for replacing it---seen several people able to do this themselves in about a hour. Google the model number to ("color wheel") to locate a replacement on the internet.10_24_2012_3_58_01_pm.jpg

Oct 24, 2012 | Samsung HLR5064W DLP Projection TV

1 Answer

Have a 65inch Mitsubishi DLP. acouple years old, just heard a loud pop,smelled like it was burning,it turns on but just sound????


hi,
Check the lamp of you tv. The lam is burned. that's why you heared a pop up sound and burning smell. Just check it and replace it. you will get the picture back.
ok

Apr 16, 2011 | Mitsubishi WD65737 65" DLP TV

1 Answer

Samsung 60" DLP - 6


Hello.
It looks like you ignored lamp replacement in your TV. It have to be replaced every 2.5 years of average use. It's like oil change in a car. Regular scheduled service.
You can read info about lamp replacement in your TV owner's manual, buy lamp on-line and replace it by yourself to save some money.
Regards.
Russ.

Dec 01, 2010 | Televison & Video

1 Answer

Samsung DLP TV repair or replace that is the question!


Color wheel sounds like it needs replacement. The set will often shut down when the color wheel gets bad and wont power up.

Jul 10, 2010 | Samsung HLN5065W 50" Rear Projection...

1 Answer

We have a Mitsubishi 65 inch dlp hd 1080p and we had a bad storm but we do have a surge protector on the tv. When we went to watch the tv after the storm it turned on fine but the dish had to reboot. After...


Something died in there - perhaps a capacitor or a solid state device just blowing and cracking into pieces. happens. Open up the set and see if you can spot it around the power supply area.

Aug 30, 2017 | Mitsubishi WD-62525 62" Rear Projection...

1 Answer

Samsung DLP making noise and is picture out


Lamp probably went out. Refer to your manual regarding lamp replacement.

May 16, 2010 | Samsung DLP HL-P5663W 56" TV

Not finding what you are looking for?
Samsung DLP HL-P5663W 56" TV Logo

17,047 people viewed this question

Ask a Question

Usually answered in minutes!

Top Samsung Televison & Video Experts

The Knight
The Knight

Level 3 Expert

75767 Answers

Donald DCruz
Donald DCruz

Level 3 Expert

17130 Answers

Jerry Greenberg
Jerry Greenberg

Level 3 Expert

1689 Answers

Are you a Samsung Televison and Video Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...