Question about 2007 Diamo Tracer 150

1 Answer

I have a 2005 Diamo 150 scooter. It always starts when the engine is cool but it sometimes stops or fails to start when it is warmed up. What is the problem with my scooter?

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Diamo Master
  • 41,921 Answers

Hi, Jerry the following applies to carbureted also fuel injected models and the usual suspects are:

1. Severely discharged or a damaged battery, 9 volts or lower.

2. Failed alternator/generator and or voltage regulator.

3. Loose or corroded battery terminals and or cables especially the "NEGATIVE" cable, look for loose, corroded, or broken connectors inside the cable harness at "BOTH" ends.

4. Failed main circuit breaker or ignition switch, check for loose connections and continuity.

5. Failed system and or ignition relay, check for continuity.

6. Failed ignition coil, ignition/electronic module.

7. Failed CKP, CPS, CMP, MAP, TPS, or BAS sensor, corroded, loose or broken wire connector pins/sockets.

8. Throttle cables and or idle speed improperly adjusted hot idle speed should be 950 RPM to 1000 RPM.

9. Air/fuel mixture screw improperly adjusted.

10. Water or dirt in the fuel system, carburetor or filter.

11. Restricted, blocked or kinked fuel line.

12. Fuel tank empty.

13. Gas cap is not venting properly or fuel tank venting system blocked.

14. A failed fuel pump, pressure regulator and or fuel injectors.

15. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.

16. Needle and seat stuck closed in the float bowl.

For more information about your issue and valuable "FREE" downloads that you need please visit the websites below. Good luck and have a nice day.

http://www.apriliaforum.com/forums/showthread.php?174841-My-scoot-won-t-start-sometimes-when-engine-is-warm

scooter wont start when hot

http://www.carlsalter.com/diamo-service-manuals.asp

Scooter Parts for Chinese Scooters Atvs

Chinese ATV Owners Repair Manuals

Posted on Mar 09, 2016

Ad

5 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad
  • 2 Answers

SOURCE: Aprilia scooter Leonardo 150

what do you go?? how much..

Posted on Jun 15, 2009

  • 139 Answers

SOURCE: My Honda X8R scooter starting problem when warm

sound like the engine might be worn out do a compression test

Posted on Oct 08, 2009

emissionwiz
  • 76164 Answers

SOURCE: I need a wiring diagram

Hi
I am sorry but we have no wiring diagrams available for dwonload for this scooter. The diagrams are contained in the factory repair manual, it is copyrighted and can't be downloaded. I suggest you buy the factory manual, if you are going to do work on this yourself it is as essential as a set of screwdrivers and wrenches. Thanks

Posted on Jun 10, 2011

  • 218 Answers

SOURCE: I dont know what type

as with any motorcycle you want to use a good oil i personnally use amsoil 20/50 it keep engine clean and lubes better for less friction

Posted on Jul 07, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Whats wrong with my electric start it only clicks when you push the button on a 2006 diamo retro scooter


Sounds like the ejector has failed on the starter, just like with a car starter. If you take it off and put it on a table, then apply power to it from the battery, you should see the fail. There's a good chance it is only the solenoid and not the entire starter assembly,

Jul 12, 2014 | 2006 Diamo Fury 150

1 Answer

Valve clearance diamo turista


Hi, Matthew and the usual suspects are:
1. Throttle cables misaligned or misrouted.
2. Damaged or restricted fuel tank venting system.
3. Inlet system air leak.
4. Vacuum piston malfunction.
5. Accelerator pump leaking or no output.
6. Plugged bowl vent.
7. Fuel level in bowl too low.
8. Restricted fuel supply passages.
9. Plugged jets or passages.
10. Worn or damaged needle or needle jet.
12. The enricher valve not seated or leaking.
For more information about your issue and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
http://www.carlsalter.com/diamo-service-manuals.asp
Scooter Parts for Chinese Scooters Atvs
Chinese ATV Owners Repair Manuals
Diamo Turista 300 2008
Tips Tricks

Mar 28, 2014 | 2005 Diamo Fury

1 Answer

Secondary vin


Hi, Anonymous your secondary VIN # is the engine serial number for more information about your question and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
http://www.carlsalter.com/diamo-service-manuals.asp
Scooter Parts for Chinese Scooters Atvs
Chinese ATV Owners Repair Manuals
Diamo Fury 2005
Tips Tricks

Mar 24, 2014 | 2005 Diamo Fury

1 Answer

Diamo scooter kick starts electric starter not wiring


Hi, Anonymous and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
5. Faulty starter button/switch.
6. Faulty jiffy stand or clutch pull in switch/sensor.
7. Security alarm needs a reset.
8. Starter control circuit, relay, or solenoid faulty.
9. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
For more information about your issue and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have nice a day.
Scooter Troubleshooting Scooter won start All about Scooters
http://www.linnbenton.edu/auto/perform/no_start.html
The Ultimate GY6 Starter Ignition Troubleshooting Tutorial http://scmotorized.com/image/data/pdf/scooter-repair-manuals/Retro-150--Parts-Catalog-V.12.07.pdf
Diamo Retro 150 2007

Sep 24, 2013 | 2007 Diamo Retro 150

1 Answer

Where can I find a 2009 diamo Velocity 150cc scooter manual


Hi, Anonymous sorry you can't find the first and best tool you ever bought for your Derbi despair, not for a mere $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
http://www.carlsalter.com/diamo-service-manuals.asp
Scooter Parts for Chinese Scooters Atvs
Chinese ATV Owners Repair Manuals
Diamo Velocity 150 2011
Tips Tricks

Sep 12, 2012 | Diamo GTS 125 Super Motorcycles

1 Answer

2009 diamo Velocity 150cc scooter manual


Hi, Anonymous sorry you can't find the first and best tool you ever bought for your Derbi despair, not for a mere $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
Tips Tricks
Diamo Velocity 150 2011
Chinese ATV Owners Repair Manuals
Scooter Parts for Chinese Scooters Atvs
http://www.carlsalter.com/diamo-service-manuals.asp

Sep 12, 2012 | Diamo GTS 125 Super Motorcycles

1 Answer

Battery size for a DIAMO TRACER 150


Hi, Anonymous for this situation I would call my local dealer or reputable shop's service/parts department and inquire about any possible quick fix, answers, or parts inquiry. If necessary, transport your bike to the dealer or shop and have a professional technician take it for a test drive, if it is in running condition, and give you a written estimate of repairs and answer any specific questions you may have about your problem. For more information about your issue and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
http://www.carlsalter.com/diamo-service-manuals.asp
Scooter Parts for Chinese Scooters Atvs
Chinese ATV Owners Repair Manuals
Diamo Tracer 150 2007 Tips Tricks

Jan 09, 2012 | 2007 Diamo Tracer 150

2 Answers

My Honda X8R scooter starting problem when warm


sound like the engine might be worn out do a compression test

Jul 12, 2009 | 2002 Honda Xr Baja

Not finding what you are looking for?
2007 Diamo Tracer 150 Logo

56 people viewed this question

Ask a Question

Usually answered in minutes!

Top Diamo Experts

yadayada
yadayada

Level 3 Expert

76164 Answers

L Pfaff
L Pfaff

Level 3 Expert

11573 Answers

kakima

Level 3 Expert

102366 Answers

Are you a Diamo Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...