Check brake pads for wear and check to see if the brake dust shield is rubbing the rotor. Most are metal, but yours may be plastic.
TSB 08-18-4
Some 2006 Zephyr, 2007-2009 MKZ, 2006-2009 Fusion and Milan vehicles built before 8/5/2008, may exhibit a popping, rubbing, grunting, squeaking, crunching or creaking type noise from the front strut mount when going over bumps, while driving at 1-10 MPH (1-16 Km/h) and/or during parking lot maneuvers. Typically, the noise is heard in the front outboard wheel while turning at low speeds. This noise may be caused by the jounce bumper rubbing against the dry strut plate.ACTION:
Follow the Service Procedure steps to correct the condition.SERVICE PROCEDURE
Raise the vehicle as described in Workshop Manual (WSM), Section 100-02.
Remove front shock absorber and spring assembly per WSM, Section 204-01.
Disassemble the shock absorber and spring assembly per WSM, Section 204-01 under Disassembly and Assembly section.
Apply Motorcraft® Silicone Brake Caliper Grease and Dielectric Compound 360° around the upper and lower contact surfaces of the shock absorber piston bounce bumper. (Figures 1 - 2)
×
SOURCE: squeaking noise from front end in cold weather
Bad ball joints. check out front end and make sure nothing else is bad. Good lucka nd thanks for using FIX YA
3,854 views
Usually answered in minutes!
×