Question about 2005 Harley Davidson FLSTC - FLSTCI Heritage Softail Classic

1 Answer

Need to replace tank, remove fuel injection parts in gas tank for 09 crossbones

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Harley Davidson Master
  • 43,120 Answers

Hi Mandr2333, for more information about your question please visit the websites below. Good luck and have nice day.
Motorcycle Repair How to Replace the Fuel Filter on 2008 Harley Davidson...

Posted on Jun 19, 2015

Ad

3 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
tundrajet
  • 80 Answers

SOURCE: removing harley davidson ultra classic gas tank

Drain the fuel either by siphening or removing the cross over tube at the front of the tank and letting it drain that way or just block off those cross over lines and leave the fule in the tank for removal.

0) remove seat
1) drain fuel
2) undo cross over line (bottom front of gas tank.
3) shut off pet **** and remove fuel line from pet ****.
4)there should only be 2 bolts holding the tank on, one at the top front of the tank and one at the back of the tank.

All in all a pretty easy (but possibloy messy) job.

Posted on Jun 06, 2009

  • 269 Answers

SOURCE: removing gas tank on harley flhtci

remove seat, remove console on top of tank, disconnect wiring from console to tank, disconnect vent line if present, disconnect fuel line on tank, disconnect fuel gauge (up under tank on left side, 3 wires, 4 wire connector, wires are yellow, orange, and black), remove bolt at rear of tank, remove two side bolts up front under tank (coil bracket is there also, carefully cut clamp on cross over hose located up front under tank.
This works better with three hands remove one side of cross over hose, fuel will flow freely so the extra hands are good at "plugging" the hose and the tank. Gently remove tank tilting front of tank as much as you can till you get it clear of the frame, while still tilted at a steep angle put the cross over hose back on.
To make things easier drain all fuel out of tank before reversing the process to reinstall tank. Hope this helps.

JP

Posted on Aug 17, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Where is the fuel filter located on a 2000 harley davidson fatboy


To clean the carbureted model's filter, you drain the gas from the tank, remove petcock and filter, clean filter with compressed air, reinstall. The fuel injected model requires that you drain the tank, remove the entire pump assembly from inside the tank, and then replace the filter (it can't be cleaned).

The carbureted model's filter is supposed to be inspected and cleaned every 20k miles. The fuel injected model's filter is supposed to be replaced every 25k miles.

Sep 06, 2014 | Motorcycles

1 Answer

Can a fuel pump relay cause poor gas delivery


NO, the relay will either work or it won't. (Unplug it and look at it; if the terminals look corroded... replace it.) Most cars have fuel injection systems these days. In addition to the fuel pump that pumps fuel out of the gas tank... there is an injection system pump which is quite expensive. In order of operation: 1) have your injectors cleaned or replaced as needed (new ones run about $30 each), 2) have the injection system pump pressure checked and get a rebuilt pump if needed (brand new one ~$850), and 3) check the fuel pump. If the car has more than 80K miles on it, then suspect clogged or partially obstructed injectors. A BOSCH SERVICE CENTER has a machine to test and clean most makes of injectors. At the same time, replace your fuel filter and use good gas when you fill up. NEVER fill up from a station that just had a fuel truck delivery (if you see the tank truck) as the garbage on the bottom of the tank takes a day or so to settle back down again. Magneti Marelli Check Star also offers good injection system servicing. The dealership should be your last resort as they just replace parts until the problem goes away... leaving you with a hefty bill and a bag of old parts

Aug 27, 2012 | Cars & Trucks

1 Answer

1995 GMC JIMMY WONT START UNLESS I PRIME IT THEN IT JUST DIES ITS FUEL INJECTED


It sounds like you have a defective fuel pump. The pump is locate inside the fuel tank, the fuel tank must be removed to replace the pump. Please follow this procedure to remove the fuel tank.
Disconnect neg battery cable, safely raise vehicle, place floor jack under tank, loosen gas tank straps and allow tank to slowly drop halfway, disconnect( this is the hard part) fuel lines,and power connections at tank. Drop tank. With a brass hammer/punch carefully remove retaining ring/seal.Reverse to install.A new pump module will cost you $300-$400 at the dealer. Don't use a cheap pump replace the entire assembly because this is a float/sender/pump/ in one. Replace your fuel filter too or the fuel pump warranty is voided..

Jun 20, 2012 | 1995 GMC Jimmy

1 Answer

How to remove the gas gauge sending unit on an


Hi Colhand, for more information about your question please visit the websites below. Good luck and have nice day.
How to replace Harley Davidson fuel filter on Fuel Injected models Part 1

Jun 05, 2010 | 2000 Harley Davidson FLHR-FLHRI Road king

3 Answers

Where is the fuel pump on a 93 geo prizm


the fuel pump is electric and located inside the gas tank.

May 21, 2010 | 1993 Geo Prizm

3 Answers

Looking for the fuel pump on a 2000 oldsmobile aurora...


It's in the gas tank, gas tank will have to be drop to get to it'

Jan 16, 2010 | 1995 Oldsmobile Aurora

1 Answer

Treated gas for moisture. Got high octane additive.


Even a small amount of bad gas can cause your problem.
So the first thing you need to do is remove your fuel tank so you can drain all of the old fuel out,then remove the fuel sending unit and fuel pump assembly thats in your fuel tank and clean the filter screen, after that you can reinstall the fuel tank,replace your fuel filter and I would have a fuel injector sevice done.
Unless you are very skilled in automotive repair, leave this one to a pro.

Jul 24, 2009 | 2001 Chrysler Town & Country

1 Answer

Triumph 955i not starting


gotta be fuel, bad fuel (gummed up carbs or injection) Berrymans B12 fuel additive system cleaner is very good. double dose and mix in gas tank.
also check or change fuel filter

http://www.carlsalter.com/motorcycle-manuals.asp

go here for free pdf service manual

Jan 11, 2009 | 2001 Triumph 955i Speed triple

3 Answers

Noisy Fuel Pump?


Greetings from America!!

As long as the vehicle is running I wouldn't worry about it unless the noise is annoying.

Yes fuel pumps do make a little noise but you normally can not hear them while the engine is operating.

You can replace the fuel pump, you need some tools, some fuel cans, a hose, a friend, car jack, jack stands, and a 6 pack of brew.

You start off by putting the hose into the place where you put gas in from the gas station. **** on the hose gently until you get fuel flowing and put the gas into the gas cans. Once you get all or most of the gas out, drop the fuel tank down and thats the hard part.

You could take it to any shop to replace the fuel pump.

Sep 05, 2008 | 1992 Audi 80

Not finding what you are looking for?
2005 Harley Davidson FLSTC - FLSTCI Heritage Softail Classic Logo

205 people viewed this question

Ask a Question

Usually answered in minutes!

Top Harley Davidson Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

Mike

Level 3 Expert

4340 Answers

yadayada
yadayada

Level 3 Expert

76682 Answers

Are you a Harley Davidson Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...