Question about Suzuki SV 650 Motorcycles

1 Answer

My 2006 sv 650 will not start. I bought it and the fuel pump was frozen. So I replaced the pump and it primed but did not start. I held the throttle open and it would start and immediatley die. So far I have bought a new battery, new spark plugs , tested the stator, tested the TOS sensor aivated the " Dealer mode " with no luck. Dealer mode reads C00 ( no issue ). The bike is getting spark and it smells like its getting gas too. All the gauges are working , the starter is turning just fine and the pump as I said is primming. Not sure where to go from here..... Please help

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Suzuki Master
  • 4,536 Answers

R u gitten gas from the tank fawcett? is pump hooked up rite and producing pressure--carb or injectors may need ajustin--buy a clymer manual

Posted on Oct 08, 2010

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get 2 Free calls (no credit card required) and instant help on almost anything you can think of (from cars to computers, appliances, handyman, and even pets).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2006 suzuki sv 650 will not do anything when u hit the stater switch relay new starter good batt good will pop start and start when u arc the relay what els could it beeeee ?????????


First prove its not the switch that is the problem, unplug it from the loom & short the cables with a paper clip (OW & YG) that would be my first step.

Wiring diagram

Mezo.

Jun 08, 2011 | 2006 Suzuki SV 650 S

3 Answers

I have a chevy colbalt 2006 ls .it is fuel injected. i ran out of gas and now it will not start even after making sure fuel tank is full ......


It probably needs a little priming. In order to do such priming, I would turn the key on for about 20 seconds, until the fuel pump goes off. Then, turn it off, do it again. Do it twice more, and it should be primed. Just to make sure, spray some ether down the air intake, and try and fire it off.

Jun 05, 2011 | 2006 Chevrolet Cobalt

1 Answer

2002 Suzuki SV 650 S won't start


Hi, Bwilliams239 and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead acid batteries.
14. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
15. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
16. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
17. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
18. Faulty neutral, clutch lever, or kickstand safety switch.
19. Faulty fuel pump or fuse or relay.
20. A stuck bent or burnt valve.
21. Tilt sensor needs a reset.
22. Security system not disarming alarm needs a reset.
23. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
2002 SV650 Wont run
What to do When Your Motorcycle Won Start
Suzuki SV650 Service Manual
OEM parts for Suzuki
Suzuki SV650 Owner Manual

Jun 30, 2017 | 2002 Suzuki SV 650 S

1 Answer

My 2006 sv 650 will not start. I bought it and the fuel pump was frozen. So I replaced the pump and it primed but did not start. I held the throttle open and it would start and immediatley die. So far I...


Hi, Ldeelena and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the enrichner.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. A severely discharged or damaged battery, you need 12.5 volts or better and be able to pass a load test if necessary.
13. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
14. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
15. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
16. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
17. Faulty neutral, clutch lever, or kickstand safety switch.
18. Faulty fuel pump or fuse or relay.
19. A stuck bent or burnt valve.
20. Tilt sensor needs a reset.
21. Security system not disarming alarm needs a reset.
22. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
sv650 won start fairly detailed
SV650 Starting Problems
Suzuki 1999 SV650 Service Manual
Suzuki 2007 SV650K7 Supplementary Service Manual
OEM parts for Suzuki
Suzuki SV650 Owner Manual

Apr 24, 2017 | 2006 Suzuki SV 650

1 Answer

650 yamaha vstar 2006 stalls out when giving it gas


Hi, Donjkiii and the usual suspects are:
1. Idle port, transfer ports, slow air jet clogged.
2. Idle adjusting screw set too low.
3. Air fuel mixture adjustment too lean.
4. Pilot/slow fuel jet clogged.
5. Faulty accelerator pump.
6. Float level too low.
7. Float bowl contaminated old fuel, water, dirt, rust, etc.
8. Carburetor bowl vent line clogged/blocked/pinched.
9. Fuel line to carburetor kinked or pinched.
10. Fuel filter clogged.
11. Intake manifold leak.
12. The gas cap is not venting properly or fuel tank venting system blocked.
13. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.
14. Needle and seat stuck closed in the float bowl.
15. Multi carburetors not in sync.
16. Faulty fuel pump.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
650 idles on choke and dies on throttle in 650 Star Tech Forum
http://www.starbikeforums.com/forums/49-v-star/68346-650-starts-but-dies-throttle.html
Yamaha XVS650 Service Manual
OEM parts for Yamaha
YAMAHA XVS650 Owner Manual

Sep 07, 2010 | 2006 Yamaha XVS 650 Dragstar Classic

1 Answer

Where is the petrol tap located?


The 2006 SV650S (US model) is electronic fuel injection which means it utilizes a fuel pump and has no petcock (US term for petroltap).

Dec 21, 2009 | 2006 Suzuki SV 650 S

1 Answer

Fluchuating idle & bucking, Like a running out of gas sensation.


how many miles are on the bike? those are the symptoms of needing a valve adjustment. if valve clearances ar good , it's in your fuel system.

Jun 14, 2009 | 2006 Suzuki SV 650 S

2 Answers

Bike not starting


Sounds l
ike a carb problem

remove air filter take starting fluid and spray in carb as you try to start it

keep spraying to keep it going

If it runs as long as you spray into carb

you will need to have the carb worked on

Jan 06, 2009 | 2005 Suzuki SV 650 S

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

343 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

76649 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4535 Answers

Richard
Richard

Level 2 Expert

83 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...