Question about Honda CBR 600 RR Motorcycles

3 Answers

Hi. I have a 2004 Honda CBR 600RR that turns when you push the starter button. She wont start. The fuel pump does not pump when you switch the bike on, and there is no spark when you try to start the bike.

Posted by on

Ad

3 Answers

  • Level 1:

    An expert who has achieved level 1.

    Mayor:

    An expert whose answer got voted for 2 times.

  • Contributor
  • 2 Answers

Hi cfarrell704. My 04 cbr 600rr is doing the same thing. did you ever figure out what was wrong? my bike has same simtoms as yours. Thank you

Posted on Oct 25, 2010

Ad
  • Level 1:

    An expert who has achieved level 1.

    New Friend:

    An expert that has 1 follower.

  • Contributor
  • 2 Answers

Check the position sensor it is behind the headlight if it isnt working it won't allow the fuel pump to turn on or any spark. If that isn't the problem check the ground wires on the left side of the bike should be a bundle of green wires

Posted on Jul 03, 2013

Ad
  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 2 Answers

Relay!

Posted on Jan 29, 2012

  • bmschenk1991 Jan 29, 2012

    There should be three on the left side take the left fairing off and you will see them I believe it will be the one in the middle.

×

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
A 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
The service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Good luck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

1998 Honda CBR 600 F3 will not start


Hi, Lionel sounds like you have faulty/contaminated off/run or starter button switch otherwise the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Quick disconnect check ball stuck.
14. Compression below 75 PSI.
15. A stuck-bent-burnt valve.
16. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
17. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
18. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
19. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections are loose or connected to the wrong cylinders.
20. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
21. Faulty neutral, clutch, kickstand safety switch.
22. Faulty fuel pump or fuse or relay.
23. Faulty or corroded run/stop switch.
24. Tilt sensor needs a reset.
25. Security system not disarming alarm needs a reset.
26. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
CBR600F3 won start Help CBR Forum Enthusiast forums for Honda CBR Owners
http://www.fireblades.org/forums/honda-cbr-600/67213-help-honda-cbr-600-f3-starting-problems-wont-start.html
Need SERVICE MANUAL for 97 CBR F3 CBR Forum Enthusiast forums for Honda... free manual ZIP file
1995 1998 CBR600F3 Repair Manual Download Manuals Technical $15
https://www.partsfish.com/page/oem-parts-for-honda
http://www.hondampe.com.au/docs/owning_a_honda/owners_manuals/motorcycles/CBR600F-1998.pdf

Feb 26, 2018 | Honda Motorcycles

1 Answer

My 2005 Honda cbr 600rr won't start i was riding it when it just stopped running no power I replaced the siloniod now it lights up but when you turn the power button on it shuts down everything ?


Hi, Wes and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
5. Faulty starter button/switch.
6. Faulty jiffy stand or clutch pull in switch/sensor.
7. Security alarm needs a reset.
8. Starter control circuit, relay, or solenoid faulty.
9. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
For more information about your issue and valuable free downloads that you will need please visit the websites below. Good luck and have nice a day.
Another 03 cbr 600rr will not crank
HONDA CBR WONT START TRY THESE TIPS
2005 2006 Honda CBR600RR Service Manual Moto Data Project

Feb 26, 2016 | Honda Motorcycles

1 Answer

The hiss system gives me nonsense. If you switch bike on(cbr 600rr 2004 model) the hiss light is off and Al 4 flickers stays on. Bike won't start. What to do please


Hi, Hennie and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
5. Security alarm needs a reset.
6. Starter control circuit, relay, or solenoid faulty.
7. Faulty starter button.
8. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
For more information about your issue, please visit the websites below. Good luck and have nice a day.
HONDA CBR WONT START TRY THESE TIPS
2004 Honda CBR600RR starting problems fixed
2003 2004 Honda CBR600RR Service Manual Moto Data Project

Dec 25, 2015 | Motorcycles

1 Answer

1987 CBR 600 will not start when hot


Hi, Anonymous and the usual suspects are:
1. Faulty ignition coil.
2. Faulty spark plug cables.
3. Faulty temperature sensor.
4. Faulty starter motor.
5. Valves adjusted too tight.
6. Spark plug gap too wide.
7. Fuel has vapor lock.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Wont start when hot slow crank like battery dead but not dead CBR Forum...
04 600rr Won start when hot starts fine when cold
http://www.home-business-host.com/images/cbr/CBR1000F%20SC21%20(1987-1996).pdf
http://www.partsfish.com/page/oem-parts-for-honda
Honda CBR600F Owner Manual

Jul 29, 2013 | 1987 Honda CBR 600 F Hurricane

1 Answer

2003 Honda CBR 600 RR bypass ignition switch


Hi, Taners2003 for this scenario you will need your service/owners manual if you can't find the best tool you ever bought for your Honda, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Ignition switch bypass
Honda Motorcycle Wiring Diagrams
2003 2004 Honda CBR600RR Service Manual Moto Data Project
http://www.partsfish.com/page/oem-parts-for-honda
Honda CB Owners Manuals

Mar 19, 2012 | 2003 Honda CBR 600 RR

1 Answer

2004 Honda CBR 600 RR will not turn over


Hi, Rick before testing any electrical component in the Starting Circuit it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage, the battery is faulty and must be replaced. AGM type batteries fall into this scenario more so than lead-acid batteries.
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Engine Run Switch is "FAULTY" or corroded.
4. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter.
5. Bank angle sensor needs a reset or is faulty.
6. FOB battery low or dead.
7. Faulty ignition switch.
8. Faulty starter button.
9. Faulty kickstand, clutch, neutral safety switch.
10. Security alarm needs a reset.
11. Starter relay, solenoid, starter motor or circuit wiring faulty.
12. Starter armature or field coils have failed.
13. Main fuse or circuit breaker may be blown or faulty.
14. Faulty ignition relay.
15. The electric starter is working but starter clutch has failed.
16. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
2004 Honda CBR won start
HONDA CBR WONT START TRY THESE TIPS 2001 2006 CBR600F4i SERVICE MANUAL Highly Detailed FSM PDF Preview... $15
https://www.partsfish.com/page/oem-parts-for-honda
Honda 2004 CBR600RR Owner Manual

Jul 22, 2011 | 2004 Honda CBR 600 RR

1 Answer

2009 HONDA CBR 600RR FUEL PUMP IMAGE


Hi, Gm2enter for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Honda, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
2009 HONDA CBR 600RR FUEL PUMP IMAGE Google Search
03 06 HONDA CBR 600rr 600 rr FUEL PUMP GAS 90 DAY WARRANTY VIDEO PETROL...
2007 2009 Honda CBR600RR Service Manual Moto Data Project
https://www.partsfish.com/page/oem-parts-for-honda
Honda CBR600RR 2007 Owner Manual

Feb 15, 2011 | 2009 Honda CBR600RR

1 Answer

HOW DO I KNOW IF THE FUEL PUMP ON MY 2007 600RR IS NOT WORKING


if your fuel pump is not working, then your bike wont start

May 20, 2010 | 2007 Honda CBR 1000 RR Fireblade

2 Answers

Bike wont actually 2003 honda cbr 600rr


In cleaning your bike you have caused some sort of problem. Start with checking the battery terminals to make sure they are connecting properly. That is what your problem sounds like. Then check to make sure you have not dislodged any electrical wires, and lastly, get your battery checked to make sure that it has not dis-charged during your cleaning operation. This would be easier with a manual if you have one.

Jan 18, 2010 | 2003 Honda CBR 600 RR

2 Answers

Honda CBR 600RR 04 electrical problem


Does anyone no what problem i have?
I`v got a honda cbr 6 rr 05,tiptop condition starts everytime, runs really well. but when i turn off the engine. " like for filling up or just for 5min" It wont start or reluctant to start first time, but 2hrs later starts perfectly again!
can any one solve this problem please.
thanks. justin

Feb 05, 2009 | 2004 Honda CBR 600 RR

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

598 people viewed this question

Ask a Question

Usually answered in minutes!

Top Honda Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4825 Answers

yadayada
yadayada

Level 3 Expert

79123 Answers

bazzz7071
bazzz7071

Level 2 Expert

342 Answers

Are you a Honda Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...