Question about 2000 Harley Davidson FLHTCUI Electra Glide Ultra Classic

1 Answer

I have a 2000 Harley FLHTC. When I start the bike, the check engine light comes on, then goes out. This is normal. But very shortly after, it comes on for a couple seconds then goes out again. I have been told, to do a self diagnosis by using the odometer reset button. I've done this and codes 1-10 read clear, however, after 1-10 it reads CAL 03. What is this code, and should I be concerned? I've tried to clear it to see if it is an old code or new, but it doesn't clear. Is it normal? I've only had this bike for a couple months, and am not quite sure what to expect, and haven't had a chance to buy a manual. Thanks.

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Harley Davidson Master
  • 41,919 Answers

Hi Duprat_desig, no worries mate it's just the system or speedometer recalibrating itself and it's too bad you can't find the very first and best tool you ever bought for your Harley Davidson. Despair not, for a mere $6.50 you may be able to download another one from the website below and good luck.
Harley Davidson Manuals Mark Workshop

Posted on Jun 21, 2015

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad
robotek
  • 1512 Answers

SOURCE: 2000 FLHRI turns over but won't start

Hi,
I found this info for you.  Have you tried the built in diagnostic in your speedometer? You can access them by: 

1) While you ignition is off hold the reset button 
2) Turn the key to the on position. 

Now from each reset button push the speedometer will test the following: 

d01 Speed sensor power output shorted low 
d02 Speed sensor power output shorted high or open 
d03 Not Used 
d04 Not Used 
d05 Speed sensor return shorted high 
d06 Speed sensor return shorted low 
d07 Not Used 
d08 Speedometer power over voltage 
d09 Speed output shorted high 
d10 Speed output shorted low or open 

The last number CAL14 is the calibration number. 
To reset all codes while in diagnostic mode, hold the reset button in for 5 seconds. 

Each test will read dXXSEt if there is a problem, or dXXCLr if there is not. (XX being the number of the list above) The 

From what I can tell it will test if your speed sensor, speedometer, or wiring is the problem. 

Hope it helps. Cheers
regards robotek

Posted on Jan 05, 2009

  • 1 Answer

SOURCE: Engine Check Light on

I disconnected the battery, pulled the maxi fuse and 15amp ecm fuse. I waited a while and put the fuses back in and connected the battery and it was cleared.

Posted on May 08, 2009

wd4ity
  • 4565 Answers

SOURCE: Need the torque specs on clutch for a 85 FLHTC

The torque specs are the same as with any Evolution engine. The compensator sprocket 150-165 foot pounds.
Clutch hub nut (left handed threads) 60-80 foot pounds.

Use Loctite 271 on threads. Two lines in nut on Compensator and one line in clutch hub nut.

Posted on Sep 24, 2009

  • 1 Answer

SOURCE: my 2004 harley davidson sportster 1200c chugs

Had this same problem with my wife's 2004 XL1200C. Took it to the dealer and they discovered the batt cable was just a little loose. They tightened it and we've had no problems with that since...that was 2 yrs ago.

Posted on Jan 18, 2010

Mitchy123
  • 216 Answers

SOURCE: check engine ligh goes on for a few seconds when i start the bike

That is exactly what it is engineered to do --

Posted on Apr 06, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Sometimes my check engine light and battery light come on while riding and will go off after a short time. Other times it stays on until I shut the bike off. What is causing this?


Check engine light and battery light. Seriously concerned. - Page ...

www.hdforums.com/.../741724-check-engine-light-and-battery-light-seri...
Mar 9, 2012 - Page 2- Check engine light and battery light. ... I'm more worried that I'm doing lasting damage by continuing to ride it however it's my .... When those two lights come on.....it's time to QUICKLY get home or to a place for repair. *2006 street bob battery light and check engine light came on ...
Mar 31, 2013
Check Engine and Battery light on.
May 24, 2012
Check Engine / Battery Light
May 1, 2012
Check engine light and battery light came on with code P0562 ...
Aug 8, 2011
More results from www.hdforums.com

check engine light and battery light - 1130cc.com: The #1 Harley ...

www.1130cc.com/forums/showthread.php?t=125147

Jul 20, 2009 - 15 posts - ‎8 authors
Both of these lights were coming on today on my ride home. When I left the gas station eveything was fine. Then i noticed both lights were on.

check engine and battery light is on - The Sportster and Buell ...

xlforum.net > ... > Sportster Motorcycle General Discussion and Problems

Sep 21, 2015 | Saddlemen Heated Road Sofa Deluxe Touring...

2 Answers

The engine light comes on after start up then about 3 sec. goes off and the bike runs good and doesn't come back until start up, any ideas?


Hi Robert, when the ignition switch is turned on, it is normal for the engine light to come on for 3-4 seconds while the engine management system runs a series of self diagnostics. If it comes on again after your bike starts please visit the website below to retrieve any generated codes, if you still have issues with the engine light contact me at xlch@mail.com. Good luck and have nice day. Harley Diagnostic Codes 04 to Present

Jul 22, 2015 | 2007 Harley Davidson FLHTC Electra Glide...

1 Answer

Engine light goes out after starting and idling. When riding speedometer is eradic and engine light comes on. Bike running fine


I would remove the speed sensor on the transmission and clean it..Just wipe it of. It's probably loaded with metal shavings. If cleaning doesn't work then you'll probably have to replace it. I own a 2000 FLHTC and I have to remove and clean mine at least 2 times a year. As for the engine light being on. The engine light should shut off within 5 to 8 seconds of the bike being started. You need to run the diagnostics through your speedometer. If you don't know how then you need to buy a service manual for the bike so you can do the diags and look up the codes.

Jan 19, 2013 | 2003 Harley Davidson FLHTCUI Electra Glide...

1 Answer

Have a 2000 electric glide classic, no spark at the plugs after washing bike


The bike threw a code. My guess is a misfire code. I would check to make sure you didn't get water in the kill switch at the right handlebar control. Water in the run/off switch could short out the switch and cause the problem you are having.

Jun 16, 2012 | 2002 Harley Davidson FLHTCUI Electra Glide...

1 Answer

01 heritage. Engine light comes on, odometer goes blank, speedo freezes or goes to zero, bike still runs. Loose connection? Short?


yes thats a good place to start-always check wiring 1st-sometimes things that appear normal can be corroded but i think your alternator battery or regulator is failing-test it dew u have a manual!!

Aug 05, 2009 | 2001 Harley Davidson FLSTC - FLSTCI...

1 Answer

Check engine light comes on at 40 mph after i slow down goes off,


First, read the code on the dash. Check to see if it is saying front or rear engine not firing. Usually it is just a loose spark plug wire and it is sending the code to the computer. You can look up how to read the codes on the dash of your bike. Any Harley dealer can tell you how to read it by using the switch and and how to clear any codes. Hope this helps. TOM

Feb 14, 2009 | 2003 Harley Davidson FLHTC Electra Glide...

Not finding what you are looking for?
2000 Harley Davidson FLHTCUI Electra Glide Ultra Classic Logo

294 people viewed this question

Ask a Question

Usually answered in minutes!

Top Harley Davidson Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4525 Answers

Mike

Level 3 Expert

4340 Answers

yadayada
yadayada

Level 3 Expert

76164 Answers

Are you a Harley Davidson Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...