Question about 1991 Suzuki GSX 1100 GM

1 Answer

No spark at the plu

I have a suzuki volusia 800 just replaced the spark plugs I am getting no spark to the plugs but when holding the wires I do get shocked what should the plugs be gapped at and is this my problem I did not gap the new plugs assumed that they were factory gapped

Posted by on


1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points


    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.


    An expert that has over 500 points.

  • Expert
  • 144 Answers

Generally gap is required for the plug, this is due to less power from the wire, kindly call the electrician and check the spark strength and the plug model. Then you come to know whether the problem is in electric side or mechanic side.
Kindly rate my help+++ Thank you.

Posted on May 09, 2010


1 Suggested Answer

  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

A 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
The service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Good luck!

Posted on Jan 02, 2017


Add Your Answer

Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer


Hi, Have you checked and cleaned your spark plugs, remember it's usually the simplest thing that causes poor starting and or running issue's.

Jun 16, 2015 | 2004 Suzuki VL 800 Volusia

1 Answer

Where do you fill and drain the gear box for a Suzuki Volusia intruder 2002 800

I figure that engine and gearbox use the same oil filling; but check the following:
  1. Need 2002 Suzuki Volusia 800 Owners Manual - Suzuki ... Apr 26, 2009 - Suzuki Volusia Forums : Intruder Volusia and Boulevard Forum ... Thanked 0 Times in 0 Posts. Need 2002 Suzuki Volusia 800 Owners Manual ...

Apr 28, 2015 | Suzuki Motorcycles

1 Answer

My 2003 suzuki volusia 800 will not turn on it cranks but doesn't turn on

Hi Oscar, and the usual suspects are:
1. Fuel tank empty.
2. Fuel supply valve/petcock turned off.
3. Fouled spark plugs.
4. Engine flooded as a result of over use of enrichner.
5. Vacuum hose to fuel supply valve/petcock disconnected, broken, cracked, or pinched.
6. Fuel valve/petcock or filter clogged.
7. Discharged battery, loose, corroded or broken battery terminal connections especially the "NEGATIVE" cable inside the harness at both ends.
8. Loose or corroded wire connection at the coil, battery or plug between ignition sensor and module.
9. Spark plug cables in bad condition and shorting, cable connections loose, or connected to the wrong cylinders.
10. Ignition timing incorrect due to faulty ignition coil, ignition module or sensors (MAP, CMP CKP and/or BAS).
11. Sticky or damaged valve or pushrod wrong length.
12. Primary cam sprocket spline sheared or missing spacer.
13. Security alarm needs a reset.
For more information about your issue, please visit the websites below, Good luck and have a nice day.
2003 Suzuki Motorcycle Service Repair Workshop Manuals

Mar 10, 2014 | 2003 Suzuki VL 800 Volusia

1 Answer

How do you remove spark plugs? How do you remove

You need to remove the gas tank to access the plugs.

*Remove the rear seat
*Remove the front seat
*Remove the single bolt holding the tank on
*Remove the 3 screws holding the speedometer on, left the speedo and unplug the wiring harness
*Disconnect the fuel line on the left side of the tank
*Lift the tank and unplud the wiring harness from under the tank (California models have an extra hose to disconnect
*Carefully lift the tank up and back to remove the tank from the bike.

Dec 14, 2010 | 2003 Suzuki VL 800 Volusia

1 Answer

Where is the spark plug located on 2003 suzuki vl 800

You will need to partially or completely remove the fuel tank to get access to the spark plugs.

Nov 21, 2010 | 2003 Suzuki VL 800 Volusia

1 Answer

How to replace spark plugs

The easiest way is to remove the gas tank to access the spark plugs.

Aug 19, 2010 | 2003 Suzuki VL 800 Volusia

1 Answer

Where are the spark plugs located on a 2003 suzuki intruder motorcycle 800cc.

Follow the spark plug wires, you will find them. they are in the heads of the bike, somewhere, probably buried in a well, with the plug wire coming out. Check it out.

Aug 13, 2010 | 2003 Suzuki VL 800 Volusia

1 Answer

How hard is it to change the spark plugs in my 2002 VL 800?

not hard at all just need the proper sized spark plug socket and a gap gauge

Mar 29, 2010 | 2003 Suzuki VL 800 Volusia

1 Answer

Where can I get a free wiring diagram for a 2004 suzuki volusia 800?

Free wiring diagram? At the library.

Thanks for your interest in

Feb 16, 2010 | 2004 Suzuki VL 800 Volusia

Not finding what you are looking for?
1991 Suzuki GSX 1100 GM Logo

167 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts


Level 3 Expert

78238 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4724 Answers


Level 2 Expert

83 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides