Question about 2002 Yamaha TT-R 225

1 Answer

2002 Yamaha TT-R 225 will not start

I have a Yamaha ttr225 I have spark and fuel but won't start what do you think might be wrong for it not to start

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Yamaha Master
  • 43,120 Answers

Hi, Chavezpedro7 and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the enrichner.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead acid batteries.
14. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
15. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
16. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
17. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
18. Faulty neutral, clutch lever, or kickstand safety switch.
19. Faulty fuel pump or fuse or relay.
20. A stuck bent or burnt valve.
21. Tilt sensor needs a reset.
22. Security system not disarming alarm needs a reset.
23. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
2004 ttr225 wont start
What to Do Check When Dirt Bike Won Start
http://tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
Yamaha TTR225S Owner Manual

Posted on Jun 09, 2017

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
susho
  • 18 Answers

SOURCE: Problems starting my 2003 Yamaha TTR225

The cylinder is the coil. It might be bad but it is expensive and you would not replace it till you know for sure there is no spark. You can take the plug out and then put it on the wire and ground it against the engine while a friend cranks the starter. Look for the spark flash. Make sure the kill switch is in the "on" position.
If that shows a spark then you will need to move into a different line of troubleshooting. I always recommend that people buy a Clymer manual.

Posted on Jul 31, 2009

  • 5 Answers

SOURCE: ttr225 i only get spark for a second then nothing

I do not know I would rebild the carb

Posted on Feb 03, 2010

  • 653 Answers

SOURCE: 2003 yamaha ttr225 will not start. charged a new

Check all fuses state, wiring connections, vacuum lines and ignition wiring.

Posted on Mar 28, 2010

nedkelly900
  • 345 Answers

SOURCE: ttr225 won't start.

carburetta blockage, can you dismantle and clean out the carby

Posted on May 18, 2010

  • 35 Answers

SOURCE: i have a yamaha 2002 TTR225. it starts but once

The only fuel filter that all bike should have is in the fuel tank if you have open stop res. tap, or you might have dirt in the carb. some bikes have a cut out switch on the side stand if you have one disconnect it and try again.

Posted on Sep 10, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2002 Yamaha TT-R 225 replace shift shaft seal


Hi, Anonymous for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Yamaha, despair not, for a mere $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have a nice day.
TTR Shifter shaft seal replacement TTR
Replace Shift Shaft Oil Seal in Seconds 2 Stroke 1998 YZ125 Example
http://www.tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
http://www.tjsconcepts.com/ttr225/TTR225_Owner_Manual.pdf

May 10, 2014 | 2002 Yamaha TT-R 225

1 Answer

What is the oil capacity of a 2002 ttr 225?


Hi, Anonymous for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Yamaha, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
TTR225 total oil amount oil change
TTR225 Oil Filter Change
http://www.tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
Yamaha TTR225S Owner Manual

Aug 10, 2012 | 2002 Yamaha TT-R 225

1 Answer

2002 Yamaha TT-R 225 fuel line routing


Hi, Anonymous for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Yamaha, despair not, for a mere zero $ you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
2002 Yamaha TTR 225 fuel line routing Google Search
2001 Yamaha TTR 225 carb questions
http://www.tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
Yamaha TTR225S Owner Manual

Jul 27, 2012 | 2002 Yamaha TT-R 225

1 Answer

04 ttr 225 carb appears to be gummed up. Full throttle is OK but need choke on full to idle and run at slow speeds


Hi, Shall582 and the usual suspects are:
1. Fuel cap or fuel tank is not venting properly.
2. Fuel filter clogged.
3. Fuel line pinched or kinked.
4. Vacuum line from the petcock to intake manifold cracked.
5. Float needle and seat sticking.
6. Float level too low.
7. Carburetor bowl vent line clogged/blocked/pinched.
8. Idle adjusting screw set too low.
9. Air/fuel mixture screw set too lean.
10. Idle port, transfer ports, slow air jet clogged.
11. Slow fuel jet clogged.
12. Faulty fuel pump.
For more information about your issue and valuable "Free" downloads that you will need please Click on the blue links below. Good luck and have a wonderful day.
TTR125 won idle except with the choke on
2001 TTR225 wont run unless choke is on
http://tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
Yamaha TT R250 Owner Manual

Jun 29, 2011 | 2004 Yamaha TT-R 225

1 Answer

2002 Yamaha TT-R 225 oil and filter change


Hi, Jcmentzer for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Yamaha, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
oil change on 02 225
TTR225 Oil Filter Change
http://tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
http://tjsconcepts.com/ttr225/TTR225_Owner_Manual.pdf

Jun 29, 2011 | 2002 Yamaha TT-R 225

1 Answer

2002 yamaha ttr 225 idles high when let off gas but eventually idles down on its own and hard to start when cold with choke or without


Hi, David and the usual suspects are:
1. Throttle cables improperly adjusted, pinched or need lubrication.
2. Idle adjusting screw needs to be backed off.
4. Air fuel mixture adjusted too lean start with 2 full turns.
5. Intake system air leak.
6. Fast idle choke ramp is not releasing.
7. Broken throttle return spring.
8. Damaged diaphragm or slide.
9. Faulty MAP, TPS, ATS, O2, sensors or wiring/connector
10. Multi carburetors not in sync.
For more information about your issue and valuable "FREE" downloads that you will need please click on the links blue below. Good luck and have a wonderful day.
TTR 225 Carb Problems
TTR 125 Idle Issues
http://tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
http://tjsconcepts.com/ttr225/TTR225_Owner_Manual.pdf

Jun 21, 2011 | 2002 Yamaha TT-R 225

1 Answer

2002 Yamaha TT-R 225 timing


Hi, Rnorfolk for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Yamaha, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "Free" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
timing marks How You Do That XT225 250 Rider Group
Checking Adjusting Valves Finding TDC
http://tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
Yamaha TTR225S Owner Manual

Apr 24, 2011 | 2002 Yamaha TT-R 225

1 Answer

What is the spark plug gap for a 2002 ttr225


Hi, Dtaylor601 for this scenario you will need your service/owners manual if you can't find the best tool you ever bought for your Yamaha, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
TTR 225 spark problems
DIY XT 225 spark plug maintenance How You Do That XT225 250 Rider Group
http://tjsconcepts.com/ttr225/TTR225_Service_Manual.pdf
OEM parts for Yamaha
Yamaha TTR225S Owner Manual

Sep 18, 2010 | 2002 Yamaha TT-R 225

1 Answer

I have a yamaha 2002 TTR225. it starts but once in gear it dies. does it have a fuel filter that ay be clogged if so where is it? or could it be something else


The only fuel filter that all bike should have is in the fuel tank if you have open stop res. tap, or you might have dirt in the carb. some bikes have a cut out switch on the side stand if you have one disconnect it and try again.

Sep 10, 2010 | 2002 Yamaha TT-R 225

1 Answer

Ttr225 won't start.


carburetta blockage, can you dismantle and clean out the carby

May 17, 2010 | 2004 Yamaha TT-R 225

Not finding what you are looking for?
2002 Yamaha TT-R 225 Logo

Related Topics:

66 people viewed this question

Ask a Question

Usually answered in minutes!

Top Yamaha Experts

dhnguyen

Level 2 Expert

281 Answers

Steve Sweetleaf
Steve Sweetleaf

Level 3 Expert

1144 Answers

Tony

Level 3 Expert

2600 Answers

Are you a Yamaha Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...