Question about 2004 KTM SX 200

1 Answer

KTM 250SX WITH WEAK SPARK. HAS SPARK WITHOUT CAP ONCE I PUT THE CAP BACK ON i GET NO SPARK. I'VE ALREADY TRIED A NEW CAP AND PLUG BUT STILL NO SPARK. dON'T HAVE THE MANUAL FOR THIS BIKE. HELP ME OUT.

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    President:

    An expert whose answer got voted for 500 times.

  • Master
  • 2,702 Answers

Try changing the HT leed the spark plug cap screws into this leed if its past its sell by date the plug cap dont make good contact with the carbon fibers inside the HT leed so just change it,,,

Posted on Feb 06, 2010

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How do I put a 2011 ktm 250sx rear fender on?


Hi, Dylan for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your KTM, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Back fender instal procedure KTM 530 exc
New Acerbis Plastics Install on KTM 300 XC Time Lapse Video
KTM 250 sxf 2016 Repair Manual
http://www.partsfish.com/page/oem-parts-for-ktm
KTM 250 SX 2010 Owner Manual

Mar 28, 2017 | 2011 KTM 250 SXF

1 Answer

I've got a KTM 125sx 2002 I've done a top end rebuild piston etc and put a new coil and plug on it and the bike won't start with the kicker, only with a bump start took the plug out and its got a weak


Hi, Ian and the usual suspects are:
1. Fouled spark plugs.
2. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
3. Loose connection at ignition coil or plug between ignition sensor and module.
4. Spark plug cables in bad condition, shorting / leaking, spark plug cable connections loose.
5. Faulty ignition coil or ignition / electronic module
6. Failed CKP, CMP, or BAS sensor.
7. Faulty ignition switch.
8. Security alarm failing to disarm needs reset
For more information about your issue and valuable free downloads that you will need please visit the websites below. Good luck and have a nice day.
125sx won kick start please help me KTM 2 Stroke
ktm 85 sx no spark
1999 2003 KTM 125 200 SX MXC EXC Service Manual Moto Data Project

Feb 23, 2016 | KTM Motorcycles

1 Answer

My 1997 ktm 250sx runs smove but wen u give it a fist full there is now power band just shonds like its missing eney help just going round is sercules thanks


All being as it should it is either ignition or fuel problem. Check air filter is clean or take for run without to see difference. Do a hard cut to check spark plug reading for lean out or fouling (run engine open throttle until high revs snd cut ignition while closing throttle and pulling clutch in to stop engine. Check plug lead. Change plug. Ignition grounded. All the basics

Nov 07, 2014 | KTM Motorcycles

1 Answer

My ktm cut out now won't start and got no spark


have u tried a new plug ? is power gettin to coil , put plug in cap and hold against a good earth point on head and crank over and see if plug sparks , if you dont see a spark try holding the plug and crank engine and if you dont feel voltage in your hand then remove cap off ht lead and repeat and if no voltage then check kill switch , if ok then check coil wires etc !

Nov 15, 2013 | KTM Motorcycles

1 Answer

Ktm 250sx 03 shifter shaft sticking


Is this a genuine part if not the part may be at fault also if not is there any dirt through the hole in the crank case the gear shaft goes through a simple solution is to use a multi tool and sand the shaft or crank case hole

Oct 10, 2013 | Motorcycles

1 Answer

I was riding my KTM 250sx when it suddenly lost power and blurred out to a stop I tried kicking it over but their was nothing I took it back to the garage and tried kicking it over a few more times and...


SOUNDS LIKE YOU MAY HAVE A DICKY KILL SWITCH . TRY TO FIND IT'S CONNECTOR( COULD BE UNDER THE TANK NEAR THE HEAD STOCK)UNPLUG THE CONNECTOR AND YOU SHOULD GET A SPARK. IF SO CHAGE THE SWITCH . MAKE SURE YOU CHECK TRY A NEW SPARKPLUG FIRST.....CHEERS.

Jul 31, 2011 | 2003 KTM SX 250

1 Answer

New stator new pick up new coil but still have very weak spark


You have replaced all the ignition components,
How do you determine weak spark?
If you can see or hear a spark, with the plug in the cap and it earthed against the head, its probably ok.
It can be hard to see in daylight
other problems could include a faulty kill switch or water or a short in the ignition switch

Feb 06, 2011 | 2004 KTM EXC 450 Racing

1 Answer

Kick start is jammed


Put the bike in 3rd, 4th or 5th gear, the higher the better. Sit on the bike, with your hand off the clutch lever, and rock the bike back and forth to rotate the clutch hub. This might free up the lever. You will need to drain the oil and remove the right side casing to see and service the kick starter. If I recall correctly, there is a spring clip that allows the kick gear to engage the clutch hub. The piece could be broken, weak or out of position.

Please rate this answer. Thanks Shay!

Apr 06, 2009 | 2002 KTM SX 250

Not finding what you are looking for?
2004 KTM SX 200 Logo

Related Topics:

512 people viewed this question

Ask a Question

Usually answered in minutes!

Top KTM Experts

yadayada
yadayada

Level 3 Expert

75077 Answers

Gino Cussen
Gino Cussen

Level 2 Expert

216 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

Are you a KTM Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...