Question about 2000 Harley Davidson FLTR-FLTRI Road Glide

1 Answer

2001 Road Glide Harley

Battery not charging when hooked up, charges fine on charger. Need schematics for charging system

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Harley Davidson Master
  • 420 Answers

Your bike has a stator and a voltage regulator. On the right front down tube you will find the plug for the stator and the voltage regulator, unplug the stator from the voltage regulator and use a meter to read the out put from the stator. I don't know the value's off hand but as you rev the motor the voltage should climb. If it doesn't your stator is bad, major job. If it does measure the voltage on the battery cables, when you rev the motor they should climb to a little over 14V's.

Posted on Sep 08, 2009

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Where can I find 2001 Harley Davidson FLHT Electra Glide color code wiring diagram schematics?


Most aftermarket repair manuals tend to befilled with mistakes. If you go to Harley and purchase the service manuals there...you will go broke. Check on Ebay or Craigslist for the factory manual you need. You tend to get a good price and so what if it is used....you will have oil smudges on it soon enough.

I purchased mine on Ebay for my 99 Road King Classic for about 40% of what Harley wanted.

Semper Fi,
Z

May 11, 2014 | 2001 Harley Davidson FLHT Electra Glide...

1 Answer

FLHTCI charging quit, replace regulator worked fine for two days then went out again.


Hi Anonymous, you need to do a complete charging system test, load test battery, regulator bleedback, alternator condition and output test plus condition of all wiring and connections. If you need a cheap ($6.50) service manual please visit website below:
Harley Davidson Manuals Mark Workshop
Good luck

Mar 03, 2014 | 2006 Harley Davidson FLHTCI Electra Glide...

1 Answer

Harley charging systems


Hi David, perform the following tests:
1. Fill acid type batteries to proper levels.
2. Charge battery overnight at 1-2 amps you need 12.5 volts or better after charging.
3. Hook up battery positive cable, then with your multimeter on the milliamp scale connect one lead to the negative battery post and the other lead to the ground cable. Meter should read 3 milliamps or less, 10 milliamps with a radio, 15 milliamps with radio and CB. If your meter reads higher you need to isolate the circuit by pulling fuses and circuit breakers one at a time and observe meter for drop in aprerage then get out your test light and track down the short in that circuit.
3. Make sure all connections are clean and tight especially the negative cable at "BOTH" ends.
4. Hook up volt meter to battery and start engine, if meter falls below 9.5 v while cranking replace battery.
5. With engine running at 3600 RPM battery should read 14.3-14.7 volts if not continue tests.
6. Unplug voltage regulator from alternator at crankcase by front of primary cover.
7. To test voltage regulator go to: https://www.youtube.com/watch?v=F8EjV0IjW9Q
8. With ohm meter, one lead grounded, touch alternator pin meter should read infinity, if not replace stator.
9. With ohm meter, both leads touching alternator pins meter should read 0.1 to 0.2 ohms on 1989 and later models. 0.2 to 0.4 ohms 1988 and earlier models, if not replace stator.
10. With volt meter set on AC scale, both leads touching alternator pins meter should read
16 to 20 volts AC for every 1000 RPM'S 1989 and later and 19 to 26 volts AC for every 1000 RPMS. If not replace rotor.
17. For a free wiring diagram please visit the website below. Good luck and have nice day.
Harley Davidson Wiring Diagrams and Schematics

Jun 12, 2012 | 2001 Harley Davidson XL Sportster 883...

1 Answer

Engine and battery light are coming on on my 2006 harley davidson road glide


Hi Jody_adams19, perform the following tests:
1. Fill acid type batteries to proper levels.
2. Charge battery overnight at 1-2 amps you need 12.5 volts or better after charging.
3. Hook up battery positive cable, then with your multimeter on the milliamp scale connect one lead to the negative battery post and the other lead to the ground cable. Meter should read 3 milliamps or less, 10 milliamps with a radio, 15 milliamps with radio and CB. If your meter reads higher you need to isolate the circuit by pulling fuses and circuit breakers one at a time and observe meter for drop in aprerage then get out your test light and track down the short in that circuit.
3. Make sure all connections are clean and tight especially the negative cable at "BOTH" ends.
4. Hook up volt meter to battery and start engine, if meter falls below 9.5 v while cranking replace battery.
5. With engine running at 3600 RPM battery should read 14.3-14.7 volts if not continue tests.
6. Unplug voltage regulator from alternator at crankcase by front of primary cover.
7. To test voltage regulator go to: https://www.youtube.com/watch?v=F8EjV0IjW9Q
8. With ohm meter, one lead grounded, touch alternator pin meter should read infinity, if not replace stator.
9. With ohm meter, both leads touching alternator pins meter should read 0.1 to 0.2 ohms on 1989 and later models. 0.2 to 0.4 ohms 1988 and earlier models, if not replace stator.
10. With volt meter set on AC scale, both leads touching alternator pins meter should read
16 to 20 volts AC for every 1000 RPM'S 1989 and later and 19 to 26 volts AC for every 1000 RPMS. If not replace rotor.
17. For a free wiring diagram please visit the website below. Good luck and have nice day.
Harley Diagnostic Codes 04 to Present

Mar 26, 2012 | 2005 Harley Davidson FLHTC - FLHTCI...

1 Answer

2001 road king charging system


Hi Anonymous, perform the following tests:
1. Fill acid type batteries to proper levels.
2. Charge battery overnight at 1-2 amps you need 12.5 volts or better after charging.
3. Hook up battery positive cable, then with your multimeter on the milliamp scale connect one lead to the negative battery post and the other lead to the ground cable. Meter should read 3 milliamps or less, 10 milliamps with a radio, 15 milliamps with radio and CB. If your meter reads higher you need to isolate the circuit by pulling fuses and circuit breakers one at a time and observe meter for drop in aprerage then get out your test light and track down the short in that circuit.
3. Make sure all connections are clean and tight especially the negative cable at both ends.
4. Hook up volt meter to battery and start engine, if meter falls below 9.5 v while cranking replace battery.
5. With engine running at 3600 RPM battery should read 14.3-14.7 volts if not continue tests.
6. Unplug voltage regulator from alternator at crankcase by front of primary cover.
7. To test voltage regulator go to: https://www.youtube.com/watch?v=F8EjV0IjW9Q
8. With ohm meter, one lead grounded, touch alternator pin meter should read infinity, if not replace stator.
9. With ohm meter, both leads touching alternator pins meter should read 0.1 to 0.2 ohms on 1989 and later models. 0.2 to 0.4 ohms 1988 and earlier models, if not replace stator.
10. With volt meter set on AC scale, both leads touching alternator pins meter should read
16 to 20 volts AC for every 1000 RPM'S 1989 and later and 19 to 26 volts AC for every 1000 RPMS. If not replace rotor.
17. For a free wiring diagram please visit the website below and good luck.
Harley Davidson Wiring Diagrams and Schematics

Mar 04, 2012 | 2001 Harley Davidson FLHR - FLHRCI Road...

2 Answers

NEED TO CHARGE BATTERY FOR 2005 DYNA WIDE GLIDE CAN I CHARGE WITHOUT REMOVING SEAT AND HOW ?


Yes. Hook the positive cable to the starter solenoid terminal, (where the battery cable mounts) and hook the ground to an exposed bolt,(or nut), near the starter, (or anywhere on the frame).

Nov 04, 2010 | 2005 Harley Davidson FXDWG - FXDWGI Dyna...

1 Answer

No voltage charge when running 1999 Harley road glide


Charging system defective. We need more information in order to diagnose. Is this an Evo engine or TwinCam?

Nov 02, 2010 | Harley Davidson FLTR-FLTRI Road Glide...

1 Answer

2000 HD Road Glide Alternator replacement


Before you spend for the new alternator, look for loose or dirty connectors. That's common on large twins.
You gave us no idea of automotive/Bike/Repair skills, so I don't know how easy/Hard it will be for you.

May 03, 2010 | 2000 Harley Davidson FLTR-FLTRI Road Glide

1 Answer

My lighter works fine but won't charge my phone or i pod, 2009 H/D road glide


Voltage regulator will not allow enough current to the lighter to charge sophisticated electronics. Install a 12v outlet directly to the battery or re wire your lighter to connect the positive directly to the battery.

Jul 08, 2009 | 2000 Harley Davidson FLTR-FLTRI Road Glide

2 Answers

Bike won't start/clicking coming from starter relay


Have you tried charging the battery or jumpstarting it with another battery?

Mar 27, 2009 | 2002 Harley Davidson FLHR - FLHRCI Road...

Not finding what you are looking for?
2000 Harley Davidson FLTR-FLTRI Road Glide Logo

495 people viewed this question

Ask a Question

Usually answered in minutes!

Top Harley Davidson Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

Mike

Level 3 Expert

4340 Answers

yadayada
yadayada

Level 3 Expert

76846 Answers

Are you a Harley Davidson Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...