Question about Suzuki Motorcycles

1 Answer

My Suzuki Volty TU250 will not start what's the problem?

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    One Above All:

    The expert with highest point at the last day of the past 12 weeks.

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

  • Suzuki Master
  • 47,276 Answers

Hi, Musthaq and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the enrichner.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. A severely discharged or damaged battery, you need 12.5 volts or better and be able to pass a load test if necessary.
13. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
14. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
15. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
16. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
17. Faulty neutral, clutch lever, or kickstand safety switch.
18. Faulty fuel pump or fuse or relay.
19. A stuck bent or burnt valve.
20. Tilt sensor needs a reset.
21. Security system not disarming alarm needs a reset.
22. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
http://tu250riders.com/viewtopic.php?t=280
found this helpful answer from motorcycle mechanic on JustAnswer com
Suzuki TU250X 2009 2017 Motorcycle Printed Service Manual by Cyclepedia
OEM parts for Suzuki
http://mybikemanuals.com/suzuki

Posted on Apr 25, 2017

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
A 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
The service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Good luck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

All information on Suzuki Grass Tracker 2002 in totally original condition. 250cc


Hi, Robbie the vast majority of service, parts fiche, and owners manuals on the internet are "FREE" to download and all service manuals contain wiring diagrams in the back pages. The rest usually charge a modest fee around $10 and there is a handful of obscure, rare, obsolete, and very old models that are no longer or never were available, for these rare occasions I shall look on eBay and find the cheapest one available. Most of the manuals will cover your exact make, model, and year otherwise one will be provided that comes as close as possible to your bike and will have most of the same info that an exact manual would have. If there is no $ sign after the manual link it is free to download for viewing or printing. To download your manual please click on the blue links below. Good luck and have a wonderful day
TU250 Suzuki Motorcycle Online Service Manual Cyclepedia $27
OEM parts for Suzuki
http://mybikemanuals.com/suzuki
Suzuki Grasstracker BigBoy 2002
Suzuki TU250 Wikipedia

Oct 01, 2017 | 2005 Suzuki Grasstracker

1 Answer

HOW TO BYPASS STARTER RELAY ON SUZUKI 1400


Hi, Robin for more information about your question and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Suzuki intruder 1500 no start definite fix
Suzuki Intruder 1400cc Starting Problems
Suzuki Intruder VS1400 Service Manual
OEM parts for Suzuki
Suzuki VS1400 Owner Manual

Jun 10, 2017 | Suzuki VS 1400 Intruder Motorcycles

1 Answer

How to tunup carburator


Make sure the jets and air passages are all clean. if you can see a brass screw on the of the carb. make sure it's between 1 1/4 and 1 3/4 turns out form lightly seated.

Dec 15, 2013 | 2002 Suzuki Volty

1 Answer

Where do i fill brake fluid on my 2011 suzuki tu250? I disassembled everything from the bars and when I put them back on and everything back together, everything worked except the front brake has no...


Attached to the front brake handel is a black box type reservoir with two screws in it. Make sure the reservoir is level remove the screws and the cover then inside is a rubber boot and plastic piece make sure they go in the same way they came out. Except the rubber piece will be collapsed into its self when the oil is replaced. Fill the reservoir with DOT4 brake fluid and re bleed the front brakes to be sure you got all the air out of the system. you do not have to replace the cover to bleed the brakes just be careful not to get any brake fluid on the painted surfaces of the bike it is not good for the paint.

May 21, 2011 | 2011 Suzuki TU250

1 Answer

My volty is making a large sound when I hit the start switch I just changed the starter motor , but still making a horrible sound when trying to start it.?


U forgot to CHECK the BENDiX gear!
Thats the thing that makes that horrible sound!
It might STOCK or needs a lubricant!
Check that and i assure u thats the fault of that noise!

Nov 23, 2010 | 2000 Suzuki Volty

1 Answer

A/c and heater fan quit , it was working fine and just quit i checked all fuses all were fine could it be the fan switch?


yes and it possibly could be the motor to check you need test equipment for starters a volty ohmn meter to see if your getting power to the motor and a continuity checker for the switch to see taht it is working properly

Aug 22, 2010 | 2000 Volkswagen Beetle

1 Answer

Hy. i just bought a moped or scooter and it won't start at all. the kickstart won't work as when i opend it there was only the leaver and nothing else inside. and the electric start is just clicking on the...


No guarantees without inspecting it but it sounds like a starter issue. Try changing the starter or contact the company/dealer you bought it from and ask. Do no tell them that you will fix it. They like to get paid for labor and I recently had a bad coil but they wanted 75 an hour to fix it. So I just spent 80 on both the coil and control box and replaced them myself, instead of spending $115 for them to replace the bad $40 part. Try the starter. It sounds like a bad one

Apr 05, 2010 | 2002 Suzuki Volty

1 Answer

Valve adjustment procedure for Suzuki TU 250


Get hold of workshop manual ,all you need to know is there .

Mar 11, 2010 | 2002 Suzuki Volty

1 Answer

Noisy starter gears


the chain and chain sprocket should be replaced.

Jul 04, 2009 | 2002 Suzuki Volty

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

54 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

78267 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4749 Answers

Richard
Richard

Level 2 Expert

83 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...