Question about Jonway Motorcycles

1 Answer

How do I test for spark on 150cc jonway

It does not want to start. Can't get spark on sparkplugs

Posted by on

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 4 Answers

Simple my friend and fellow biker. Remove the plug from the cylinder head, attach the plug lead again and rest the plug on the metal head ( don't actually hold it, it will spark at 18000 volts) and gently turn the engine over, it will be easy to do as there will be no compression with the plug out, if the electrics are ok, you will see the plug spark ( difficult in bright sunlight so, do it in a workshop or the shade) good luck

Posted on Dec 15, 2014

Testimonial: "I have done that. There is none. When the sparkplug is out what else can I do?"

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
A 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
The service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Good luck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Jonway 125 will not start


Hi, Koos and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the enrichner.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
14. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
15. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
16. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
17. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
18. Faulty neutral, clutch, kickstand safety switch.
19. Faulty fuel pump or fuse or relay.
20. A stuck bent or burnt valve.
21. Tilt sensor needs a reset.
22. Security system not disarming alarm needs a reset.
23. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
My chinese scooter wont idle or start Check the fuel petcock
Fix Chinese 49cc Scooter that won start
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
Jonway Scooter Parts
http://absolutelyscooterparts.net/pdf/CGEN_dawg_scooter_manual.pdf

Aug 15, 2017 | Jonway Motorcycles

1 Answer

Jonway 125 will not start


Hi, Koos and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the enrichner.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead acid batteries.
14. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
15. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
16. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
17. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
18. Faulty neutral, clutch lever, or kickstand safety switch.
19. Faulty fuel pump or fuse or relay.
20. A stuck bent or burnt valve.
21. Tilt sensor needs a reset.
22. Security system not disarming alarm needs a reset.
23. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
cranks but wont start
Scooter Troubleshooting Scooter won start All about Scooters
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
parts JONWAY GT 125 parts jonway aztral parts jonway js120 125cc 150cc...
http://absolutelyscooterparts.net/pdf/CGEN_dawg_scooter_manual.pdf

Aug 15, 2017 | Jonway Motorcycles

1 Answer

Why wont my 50cc gator moped start has fuel and spark


Hi, Ruth and the usual suspects are:
1. Fuel tank empty.
2. Fuel supply valve/petcock turned off.
3. Fouled spark plugs.
4. Engine flooded as a result of overuse of the enricher.
5. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
6. Fuel valve/petcock or filter clogged.
7. Fuel line to the carburetor or throttle body pinched or kinked.
8. Carburetor float stuck.
9. Fuel injectors clogged.
10. Severely discharged or damaged battery you need 12.5 volts or better and be able to pass a load test if necessary.
11. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
12. Loose or corroded wire connection at the coil, battery or plug between ignition sensor and CDI box.
Spark plug cables in bad condition and shorting check for leakage in the dark, cable connections loose, or connected to the wrong cylinders.
13. Ignition timing incorrect due to a faulty MAP, CKP, O2, TPS, sensors.
14. Faulty neutral, clutch lever, or kickstand safety switch.
15. Faulty fuel pump or fuse or relay.
16. Faulty CDI box.
17. A stuck bent or burnt valve.
18. Tip over sensor needs a reset.
19. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Scooter Troubleshooting Scooter won start All about Scooters
Fix Chinese 49cc Scooter that won start
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
Service Support China Jonway Group
http://www.dirtcheapmotorsports.com/jonway-gator-50-moped.html

Feb 20, 2017 | Jonway Motorcycles

1 Answer

2008 jonway 150cc scooter wiring diagram


Hi, Shayne what you need is a wiring diagram that you can find in the back of your service manual if you can not find the first and best tool you ever bought for your bike, despair not, I have found one for you that costs zero dollars. For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have a nice day.
2008 jonway 150cc scooter wiring diagram Google Search
http://www.atv4usa.com/catalogs/XY150T-WiringDiagram.pdf
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
Service Support China Jonway Group
Free Jonway Motorcycle Service Manuals for download

Nov 18, 2016 | Jonway Motorcycles

1 Answer

Where is fuse box jonway 150cc scooter


Hi, Theresa for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Jonway, despair not, for a mere $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have a nice day.
Where is fuse box jonway 150cc scooter Google Search
Guide How To Check Your Fuse On Your Moped scooter madness motorbike...
Where the fuse box live
http://www.49ccscoot.com/manuals/Arrow_150_Engine_Service_Manual.pdf

Oct 29, 2016 | Jonway Motorcycles

1 Answer

What spark plug do i buy gor my jonway YY50QT-6 MOPED


Hi, Steve for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Jonway, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Amazon com NGK C7HSA SPARK PLUG GY6 49CC 50CC 150CC CHINESE SCOOTER PIT...
AKA Roketa Scooter MC 07 50 Baja SC50 Strada RX 50 Jalon JL50QT 21 falcon...
http://www.carlsalter.com/pdfs/Jonway%20YY50QT-21.pdf
http://www.carlsalter.com/pdfs/Jonway%20YY50QT-6.pdf
http://www.carlsalter.com/pdfs/Jonway%2050CC%20ENGINE.pdf

Jun 19, 2015 | Jonway Motorcycles

1 Answer

2013 Jonway Madness 125 no key fob will not start


Hi, Mark the answer to this question is way above my pay grade for this situation, I would call or visit my local dealer or reputable shop's service/parts department and inquire about any possible quick fix, answers, or parts inquiry.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Bypass stupi chinese alarm
Jonway madness problem
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
Service Support China Jonway Group
http://absolutelyscooterparts.net/pdf/CGEN_dawg_scooter_manual.pdf

Feb 10, 2015 | Jonway Motorcycles

1 Answer

Jonway Master 250 spark plug location


Hi, Abdul for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Jonway, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Jonway Master 250 spark plug location Google Search
How to change your Spark Plug on Scooter Part 1
http://www.family-motorsports.net/GY6-50cc-150cc.pdf
Jonway 250cc Scooter Parts
http://absolutelyscooterparts.net/pdf/CGEN_dawg_scooter_manual.pdf

Jan 08, 2015 | Jonway Motorcycles

1 Answer

How do I test the rectifier on the jonway 150cc.


It's not the rectifier which is the problem as this is part of the charging system. If the rectifier is faulty, the bike will still drive with a good battery till it runs out of power.
Your problem sounds more like a bad starter motor, try push starting the bike to see if it drives.

Dec 15, 2014 | Jonway Motorcycles

1 Answer

Jonway eletric start and lights problem.


Recommend contacting your nearest authorized service center directly or online here:

http://www.jonway-motor.com/contact.html


helpful-fbhtsuujths3pkuos2jmb534-4-0_7.png

Feb 03, 2018 | RTO Gas Motor Scooter 150cc

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

123 people viewed this question

Ask a Question

Usually answered in minutes!

Top Jonway Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4821 Answers

Steven Wander
Steven Wander

Level 3 Expert

593 Answers

Andrew Taylor
Andrew Taylor

Level 3 Expert

19616 Answers

Are you a Jonway Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...