Question about Motorcycles

1 Answer

My 1991 Suzuki 250 quadrunner 4x4 will not run if the vacum line is hooked up on the carburetor not sure how the vacum system works?

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 579 Answers

It sounds to me like there may be a clog of some kind at one end or other end of this vacuum hose. This is what you will have to check. GOOD LUCK FRIEND

Posted on Nov 17, 2014

  • Derek Mess Nov 17, 2014

    The port on the carburetor that sucks air into it I can't blow through tha line would that be the problem

  • dannydoesita Nov 17, 2014

    You may have a small carbon clog where this hose goes. Try gently pushing a peice of wireinto this area and see if you can clean out before you start to disassemble carb. This seems to me to be an emissions port on your carb.

×

2 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

mxtras
  • 194 Answers

SOURCE: where do all the hoses go to a suzuki quadrunner carb

There is one supply hose (larger) and a bunch of vent tubes. The vent tubes really don't matter how they are connected as long as they vent. The vents that point vertical - just loop the tube up and then down towards the ground.

Posted on Oct 08, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Pullcord starts my 1995 250 quadrunner suzuki electric start turns it over but it won't kick in


battery / starter motor problem
the starter or start circuit is not getting enough power to run the ignition system when the starter is in use
have a load rest done on the battery and if ok have the starter bench tested

Jul 04, 2017 | Suzuki Motorcycles

1 Answer

Is a 2000 Suzuki LTF250 quad runner Ina 4 stroke or 2 stroke


Joe, 2000 Suzuki LTF 250 is 4 stroke. Check the attached links,instruction and guides, Good luck
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."
2001 ltf250 oil change
Suzuki LTF250 Quadrunner 4x4 Oil Filter Replacement Oil Filters
2000 Suzuki Quadrunner F250 ATVs

Jul 10, 2016 | Suzuki Motorcycles

1 Answer

I got a 1995 250 4x4 Suzuki quadrunner starter spin but engine want rotate


pull the starter
there is either a problem with the solenoid connecting the terminals inside before engaging the pinion gear (plunger disconnected from lever that moves the pinion gear forward
OR
the over run clutch of the pinion gear has failed and is not locking the gear in the drive position

Mar 05, 2016 | Suzuki Motorcycles

1 Answer

What is best manual for 1996 Suzuki quadrunner


Hi, Anonymous sorry you can't find the first and best tool you ever bought for your Suzuki despair not for a mere $5 you can download another one. For more information about your issue and valuable free downloads that you will need please visit the websites below. Good luck and have a nice day.
https://www.tradebit.com/filedetail.php/262744474-suzuki-quadrunner-250-kingquad-280-service
Suzuki Parts Free Shipping in for OEM MotorcycleATV
Suzuki motorcycle and ATV owner manual

Feb 06, 2016 | Suzuki Motorcycles

1 Answer

My 2007 Suzuki eiger quadrunner 4004 4x4 won't go into reverse.


Hi, Anonymous for this situation I would call my local dealer or reputable shop's service/parts department and inquire about any possible quick fix or parts inquiry. If necessary transport your vehicle to the dealer or shop and have a professional technician take it for a test drive, if it is in running condition, and give you a written estimate of repairs and answer any specific questions you may have about your issue. For more information about your issue please visit the website below. Good luck and have a nice day.
4x4 LT250 Quadrunner wont shift Suzuki ATV Forum

Aug 05, 2015 | Suzuki Motorcycles

1 Answer

Mikuni carb


Hey Anon,, WHY are you needing to replace the carb?? In my 40+ years of being a motorcycle/atv mechanic, I have only replaced 3 carbs,,,and CLEANED and repaired HUNDREDS AND HUNDREDS. reply to me on here.... I'll help you

Jun 28, 2017 | Suzuki 2005 QuadSport Z400

1 Answer

Suzuki problems


Hi, Anonymous what ever you do hang on to this bike as long as you can it is an extremely rare bird and worth lots of "DRACHMA" in good condition as for your issue the usual suspects are:
1. Severely discharged or a damaged battery, should have 12.5 volts or better and be able to pass a load test if necessary.
2. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
3. Spark plugs in bad condition or partially fouled.
4. Spark plug cables in bad condition and leaking check for spark leakage in the dark
5. Spark plug gap too close or too wide.
6. Faulty ignition coil, module, and or sensor.
7. Loose, dirty, or corroded ignition module connector at crankcase.
8. Faulty CKP or CMP, MAP, ETS, ATS, TPS, O2 sensor.
9. Dirty air filter.
10. Intake air leak.
11. Water, dirt, or rust in the fuel system.
12. Carburetor damaged, contaminated, sticky float, plugged jets.
13. Multiple carburetors out of sync.
14. Fuel filter clogged.
15. Old or contaminated fuel.
16. Fuel tank vent system plugged or carb vent line closed off.
17. Gas cap diaphragm valve faulty.
18. Vacuum line from intake manifold to fuel valve is broken, cracked, pinched, or missing.
19. Carburetor controls misadjusted.
20. Incorrect valve timing.
21. Valve springs floating, weak, or broken.
22. Damaged intake or exhaust valve.
23. Incompatible performance parts.
24. Control module may be in "LIMP" mode
25. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
LT Z250 wont idle
quadrunner 250 4x4 idle issues
Suzuki Rgv250 1990 1996 Workshop Service Repair Manual Download Manuals... $10
http://www.ebay.ie/itm/SUZUKI-RGV250N-HOP-UP-COMPETITION-MANUAL-/142349211318?hash=item2124ac96b6%3Ag%3AO20AAOSwXYtYwtiC
http://www.ebay.ie/itm/SUZUKI-TV-250-Wolf-parts-catalogue-List-manual-*****-RGV250-wolf-VJ21-A-/311847083462?hash=item489b88ddc6%3Ag%3Ab~cAAOSwt5hYjjWk

May 02, 2017 | Suzuki Motorcycles

1 Answer

No fuel getting from tank to carburetor. Cleaned and checked fuel position valve on the bottom of the tank and traced line to front junction block under the left front fender. Model not listed 1999...


the fuel line leaving tank to the box is your fuel pump,it may not be working,take the line from the tank to pump and check to see if you have fuel flow through that line,if you do reconnect it and disconnect line leaving box to carb, push start button to see if you have fuel from pump,if not,check to see if there is a vacuum line connected to pump,it may be vacuum operated,you can also just run the fuel line from tank straight to carb to see if it will start,then you will know if its your fuel pump.

Feb 23, 2011 | Suzuki ST 250 Motorcycles

1 Answer

Where do all the hoses go to a suzuki quadrunner carb


There is one supply hose (larger) and a bunch of vent tubes. The vent tubes really don't matter how they are connected as long as they vent. The vents that point vertical - just loop the tube up and then down towards the ground.

Oct 08, 2009 | 2004 Suzuki ST 250 E

4 Answers

Battery is not charging for atv suzuki atv


try replacing your rectifire becuase that is what charges the battery

Mar 09, 2009 | 2001 Suzuki Burgman 250

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

219 people viewed this question

Ask a Question

Usually answered in minutes!

Top Motorcycles Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

yadayada
yadayada

Level 3 Expert

75066 Answers

kakima

Level 3 Expert

102366 Answers

Are you a Motorcycle Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...